RoadVitals

2011 Workhorse W22 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jul 27, 2010
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

10V348000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Jul 27, 2010
1,328 units potentially affected
The defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 WORKHORSE W22 AND R26 TRUCKS MANUFACTURED FROM FEBRUARY 5, 2007 THROUGH MAY 24, 2010. THE FUEL-FILL CAP ASSEMBLIES USED TO SEAL THE UNUSED SIDE OF THE DUAL-FILL GASOLINE FUEL TANK WERE PRODUCED WITH A HOSE MATERIAL THAT DID NOT MEET DESIGN SPECIFICATIONS. DURING NORMAL USAGE THE HOSE MATERIAL MAY DETERIORATE WHICH MAY RESULT IN FUEL LEAKS.
The risk: A FUEL LEAK INCREASES THE RISK OF A FIRE WHICH MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
The remedy: DEALERS WILL REPLACE THE ORIGINAL FUEL-FILL CAP ASSEMBLIES WITH ONES ASSEMBLED WITH HOSE MATERIAL THAT MEETS DESIGN SPECIFICATIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE OCTOBER 8, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.
NAVISTAR, INCManufacturer number 61101-CView on NHTSA.gov
10V158000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Apr 16, 2010
521 units potentially affected
The defect: WORKHORSE IS RECALLING CERTAIN MODEL YEAR 2010 W42, W62 AND MODEL YEAR 2011 W22 TRUCKS AND BUILT WITH A GENERAL MOTORS GASOLINE ENGINE AND EQUIPPED WITH REMY ALTERNATOR. A LOW RESISTANCE ELECTRICAL SHORT IN THE ALTERNATOR'S VOLTAGE REGULATOR MAY OCCUR.
The risk: AN ELECTRICAL SHORT IN THE ALTERNATOR MAY OCCUR WITHOUT WARNING POSSIBLY RESULTING IN A VEHICLE FIRE.
The remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 2, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
NAVISTAR, INCManufacturer number 80101-CView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources