RoadVitals

2000 Workhorse W24 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Mar 26, 2006
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Workhorse W24, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

UPON PURCHASING OUR MOTOR HOME AND PUTTING ON ABOUT 17000 MILES WE EXPERIENCED A MAJOR BRAKE PROBLEM WITH OUR VEHICLE. THE PARKING BRAKE AND OR PARK SHIFT LEVER WITCH BOTH ACTIVATE THE BRAKE AROUND THE DRIVE SHAFT ACTIVATED AS WE WERE TRAVELING ON A TWO LANE ROAD. THIS CAUSED THE VEHICLE TO STOP WITH THE BRAKES ACTIVATED AND NO WAY TO DISCONNECT OR FREE THE VEHICLE TO MOVE IT. LUCKILY BEING 10 MILES FROM HOME WE WERE ABLE TO RETURN HOME AND PURSUE REPAIRS. AFTER TALKING TO WORKHORSE, THE MANUFACTURE OF THE CHASSIS ,THEY SAID TO HAVE IT FIXED AND SEND THEM A LETTER EXPLAINING THE REPAIRS AND COSTS IN WITCH WE DID ALONG WITH THE PAID REPAIR BILL. THE PROBLEM WAS EXPLAINED TO ME BE THE SERVICE DEPARTMENT OF A WORKHORSE DEALER AS FOLLOWS: A PRESSURE SWITCH LEAKED AND THE RESEVOIR BECAME LOW WITCH ACTIVATED THE BRAKE SYSTEM. IN TURN THIS CAUSED THE BRAKE SHOES TO BE WORN THIN AND HAD TO BE REPLACED AS WELL AS THE TRANSMISSION TAIL SHAFT SEAL AND SWITCH PUMP AND VALVE ASSEMBLY. THIS WAS A VERY COSTLY AND DANGEROUS SITUATION. AFTER CONTACTING WORKHORSE AGAIN THEY STATED THE VEHICLE WAS OUT OF WARRANTY AND THEY WOULD NOT DO ANYTHING FOR US. THIS PROBLEM STEMS FROM A BAD SWITCH AND IS RECOGNIZED AS A WELL KNOWN PROBLEM ON THIS CHASSIS. WE WERE ABLE TO RETURN HOME SAFELY AND MAKE REPAIRS BUT THIS IS DEFINITELY A SAFETY PROBLEM! *JB

NHTSA ID 10153726 · filed Mar 26, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .