2006 Workhorse W24 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Workhorse W24, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Brakes150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2007 Itasca Suncruiser built on a 2006 Workhorse W24 Chassis. The contact stated while driving at an undisclosed speed, the propane alarm sounded. The contact veered to the side of the road. The contact stated that upon inspecting the propane tank, he noticed that the bracket that held the propane tank into position, was loosened. An independent mechanic repaired the bracket. The dealer was not notified of the failure. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 69,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WORKHORSE W-24 PARK BRAKE ONE TIME USE FOR EMERGENCY THEN FAILS WITHOUT WARNING WHO WAS THE IDIOT THAT APPROVED SUCH A SYSTEM MOST OF THE GENERAL MOTORS COACHES ARE WITHOUT ANY EMERGENCY OR PARK BRAKES ,YOU CAN NOT REPAIR CRAP THAT WILL NOT WOK AS DESIGNED WITH A FAILURE RATE OF 100% WITHIN THREE YEARS. I THINK YOU HAVE TAKEN OR JUST DO NOT HAVE THE BALLS TO APPLY THE LAWS THAT YOU SPONSORED THRU CONGRESS. REPAIR PARTS ARE NOT READILY AVAILABLE ONLY NEW PART FROM WORKHORSE. 1 THE FAILURE ONE TIME USE ITEM,IT DOES NOT SAY THAT IN ANY WRITTEN MATERIAL FROM WORKHORSE2MY BATTERY POWER CABLE TO MY COACH FAILED,THE POWER LOSS OPENED ALL CONTACTS SO NO POWER TO BRAKE LIGHTS,EMERGENCY FLASHERS EVERYTHING DEAD ...I HAD TO USE THE TOAD FLASHERS TO HOLD TRAFFIC AT BAY TILL A TOW TRUCK ARRIVED. MY PARKING BRAKE WORKED ON LEVEL GROUND BUT WHEN I PARKED ON A HILL IT WAS A SCRAMBLE TO APPLY THE BRAKE WITH ENGINE OFF. FROM A MOTORHOME TO ROLLING CRAP IN 2 SECONDS WITH NO WARNING 3 THE FIX IS TO PURCHASE THE NEW---NEW PARK BRAKE ASSEMBLY FROM WORKHORSE,NOT IN THE NEAR FUTURE, THIS SYSTEM IS ALSO IN BUS FRAMES THAT CARRY OUR CHILDREN TO SCHOOL. YOU GUYS BLEW THIS ONE, CONFESS UP, AND FIX IT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .