1998 Yamaha FZR600 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1998 Yamaha FZR600, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical2100.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
CONSUMER PLACED KEY IN THE IGNITION OF MOTORCYCLE TO START IT. WHEN CONSUMER REMOVED THE KEY FROM THE IGNITION MOTORCYCLE WOULD STILL BE RUNNING. CONSUMER DROVE THE MOTORCYCLE TO DEALER, AND MECHANIC INFORMED CONSUMER THAT MOTORCYCLE WAS OPERATING NORMALLY. *AK
THE IGNITION SWITCH ON MY 1998 ROYAL STAR WILL CUT OUT AT INTERMITTENT TIMES CAUSING THE ENGINE TO STOP RUNNING. THIS HAS HAPPENED TO ME ABOUT 8 OR 9 TIMES NOW SINCE THE 1ST OCCURANCES (5) ON 9/15/2001. THE MOTORCYCLE IS STILL UNDER FACTORY WARRANTEE AND A REPLACEMENT IGNITION SWITCH IS ON ORDER BUT I FEEL THAT THIS IS DEFINITELY A SAFETY ISSUE. WHEN A MOTORCYCLE ENGINE STOPS RUNNING AT SPEED THERE IS A SUDDEN DECELERATION THAT COULD CAUSE A RIDER TO LOSE CONTROL OF THE MOTORCYCLE. IF THE LOSS OF ENGINE POWER OCCURS WHILE ATTEMPTING A PASSING MANEUVER IT COULD RAPIDLY RESULT IN A SERIOUS SITUATION WHERE THE CYCLIST HAS NO POWER TO MANUVER AND IS FACED WITH ONCOMING TRAFFIC. I WAS (ALMOST) IN THIS TYPE OF SITUATION WHILE TOURING THE GREEN MOUNTIANS IN VERMONT ON 9/15/2001. I LOST ENGINE POWER 5 SEPARATE TIMES DURING THAT TRIP, TWICE WHILE ON MOUNTAIN ROADS WITH NO SHOULDER TO COAST ONTO AND TRAFFIC RIGHT ON MY REAR FENDER. THE ONLY WAY TO RESTART THE ENGINE IS TO SHIFT INTO NEUTRAL, TURN THE INGITION KEY OFF/ON AND THEN PRESS THE STARTER BUTTON. TRYING TO DO THIS WHILE SUDDENLY LOOSING POWER IN FULL TRAFFIC IS TRICKY EVEN FOR AN EXPERIENCED CYCLIST. COMPOUNDING IT WITH THE LOCATION OF THE IGNITION SWITCH (LOW FRONT LEFT FORK) REQUIRING THE RIDER TO REACH DOWN AROUND THE FUEL TANK MAKES FOR A VERY HAIRY SITUATION. IN MY RESEARCH ON THIS COMPONENT I HAVE FOUND THAT YAMAHA IS AWARE OF THE PROBLEM AND HAS REDESIGNED THE IGNITION SWICH ASSEMBLY. BUT THEY WILL NOT REPLACE IT UNTIL AN OWNER ACTIVELY REQUESTS THAT IT BE DONE AND I DO NOT KNOW IF THEY WILL REPLACE THE SWITCH IF THE MOTORCYCLE IS OUT OF WARRANTEE. SINCE THE ROYAL STAR LINE OF MOTORCYCLES STARTED IN MODEL YEAR 1996 AND CAME WITH A 5 YEAR WARRANTEE THE ISSUE OF OUT OF WARRANTEE REPLACEMENT MAY START TO COME TO A HEAD. I BELIEVE THAT THIS PROBLEM SHOULD BE A RECALL AND NOT LEFT UP TO THE FATE OF THE CYCLISTS. I WAS FORTUNATE, OTHERS MAY NOT BE....
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .