RoadVitals

2015 Yamaha WR250R Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Nov 3, 2016
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

16V800000

POWER TRAIN:CLUTCH ASSEMBLY

Nov 3, 2016
2,550 units potentially affected
The defect: Yamaha Motor Corporation , USA (Yamaha) is recalling certain model year 2014-2016 WR250R motorcycles manufactured August 1, 2013, to June 1, 2016. Due to an incorrect assembly process, the clutch push lever oil seal may crack, allowing engine oil to leak out.
The risk: If oil leaks from the engine, the oil may get on the rear tire, causing a loss of control and increasing the risk of a crash.
The remedy: Yamaha will notify owners, and dealers will replace the clutch push lever oil seal, free of charge. The recall began November 11, 2016. Owners may contact Yamaha customer service at 1-800-962-7926. Yamaha's number for this recall is 990108.
Yamaha Motor Corporation, USAManufacturer number 990108View on NHTSA.gov
15V410000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Jun 29, 2015
12,721 units potentially affected
The defect: Yamaha Motor Corporation, USA (Yamaha) is recalling certain model year 2008-2011 WR250X motorcycles manufactured June 1, 2008, to June 1, 2011 and 2008-2015 WR250R motorcycles manufactured June 1, 2008, to June 1, 2015. In the affected motorcycles, the insulation on the stator coil, a component of the alternator, may become damaged and short circuit to due insufficient heat resistance.
The risk: If the stator coil is not insulated, the motorcyle will not charge and the battery will go dead, causing the engine to stall which increases the risk of a crash.
The remedy: Yamaha will notify owners, and dealers will replace the stator coil with one that has sufficient heat resistance, free of charge. The recall began on July 30, 2015. Owners may contact Yamaha customer service at 1-800-962-7926.
Yamaha Motor Corporation, USAView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources