2018 Alfa Romeo Giulia Fuel system Problems

The contact owns a 2018 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The contact stated that while driving at various speeds on approximately five occasions, the vehicle went into LIMP Mode, lost motive power, and stalled on some occasions. The check engine warning light and the Electronic Throttle Control (ETC) warning light were illuminated twice. The contact stated that while attempting to accelerate, the vehicle failed to accelerate above 30 MPH. The vehicle was taken to an independent mechanic, where it was diagnosed and determined to have a Co pump module failure because the pressure was too high and the Co pump module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,100.

NHTSA ID

11752588

Incident

Jan 1, 2026

Mileage

100,100 mi

The contact owns a 2018 Alfa Romeo Giulia. The contact stated that after driving the vehicle and parking the vehicle, upon returning to the vehicle a short time later, the vehicle hesitated while restarting. On another occasion, the vehicle was started and stalled while driving. Approximately 10 minutes later, the vehicle was able to be restarted. A diagnostic scan of the vehicle indicated a failure with the fuel delivery system. The vehicle was taken to a dealer, where a temporary workaround was performed; however, the vehicle became inoperable shortly after being started and driven. No further repairs were completed. The manufacturer was notified of the failure. The contact associated the failure with NHTSA Campaign Number 25V586000 (Fuel System, Gasoline). The approximate failure mileage was 15,000.

NHTSA ID

11746674

Incident

Jun 19, 2024

Mileage

15,000 mi

Vehicle is affected by FCA recall 93C / NHTSA recall 25V-586 for Fuel Delivery Module / fuel pump failure that can cause fuel starvation and unexpected loss of motive power. NHTSA recall lookup shows the recall is incomplete and the remedy is not yet available. The vehicle is already symptomatic. It has active DTC P008A / low-pressure fuel system pressure too low, check engine light, and Start/Stop unavailable. It also has drivability symptoms: inconsistent acceleration, hesitation/poor response, and sometimes failing to restart after stopping in traffic, such as at traffic lights. This creates a risk of the vehicle being disabled in traffic or losing motive power without adequate warning. The dealer stated final recall parts are not available. Dealer offered only a no-charge interim fuel pump control module replacement, but quoted approximately $1,117 to replace the low-pressure fuel pump assembly / Fuel Delivery Module and O-ring. FCA/dealer has not provided written authorization for no-charge interim FDM replacement, has not guaranteed reimbursement if the owner pays now, has not provided alternate transportation, and has not provided a written safety determination that the vehicle is safe to operate while symptomatic. This issue appears long-known. FCA issued a P008A low-pressure fuel system service bulletin in 2018, NHTSA opened investigation PE24003 in January 2024, and recall 25V-586 was not filed until September 2025. Despite that history, a symptomatic vehicle remains without an available final remedy.

NHTSA ID

11744273

Incident

Jun 9, 2026

Active recall: NHTSA Recall Number 25V-586. My car has now failed twice in traffic and is not safe to drive.

NHTSA ID

11744067

Incident

Jun 13, 2026

NHTSA RECALL #25V-586 Around September of 2025, I notified Alfa Romeo Customer service that my vehicle was experiencing symptoms of this recall. Symptoms include but are not limited to severe fuel pump whine that fluctuates with RPM, as well as intermittent LOMP. The whine is audible 100% of the time. The LOMP occurs intermittently, primarily shortly after starting the vehicle. On multiple occasions, I have to pull my vehicle to the side of the road because it is unable to effectively move under it's own power. Along with this LOMP, symptoms experienced are a heavy misfire along with a few service messages such as "Auto start unavailable, service electronic throttle, and service engine" along with a flashing check engine light. The fix appears to be power cycling the battery so that the fuel pump primes multiple times. I have called Alfa Romeo multiple times about this issue over the last few months, but all they tell me is that they cannot do anything until a remedy is available. Unfortunately, given the wait, symptoms have progressively gotten worse.

NHTSA ID

11740163

Incident

May 21, 2026

Been waiting to have this recall repaired for months. I started the car and excessive amount of fuel was injected into the combustion chamber, cause a smoke cloud.

NHTSA ID

11715569

Incident

Feb 2, 2026

NHTSA #25V-586 Recall #93C 2017-2019 ALFA ROMEO GIULIA, 2018-2019 ALFA ROMEO The vehicle has been experiencing inconsistent fuel readings, an electronic throttle control fault, and a service engine warning. When the electronic throttle control fault occurs, the vehicle loses power, stalls, and struggles to accelerate, which raises concerns about its suitability for commuting. On several occasions, while driving on highways, my vehicle has experienced loss of power, resulting in a significant reduction in speed. This has necessitated extended commute times on streets due to the apprehension of causing accidents. Consequently, I have had to miss several workdays in an attempt to address this issue. Initially, I resorted to using rental vehicles out of pocket until a solution for this recall was found. However, despite my efforts, there has been no resolution, and I am left with concerns about driving my vehicle and potentially causing an accident due to the lack of safety measures or the ongoing financial burden of renting vehicles until a solution for the recall is implemented. Despite multiple attempts to schedule a repair, there has been no resolution, and the date for bringing the vehicle in for inspection continues to be postponed. Despite multiple attempts to schedule a repair, no resolution has been achieved. The date to bring the vehicle in for inspection has been repeatedly postponed, and the date for inspection is now April 1st, 2026.

NHTSA ID

11714311

Incident

Aug 30, 2025

The contact owns a 2018 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the vehicle was hesitating and then lost motive power. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was not available. The VIN was not available.

NHTSA ID

11713689

Incident

Aug 20, 2025

i have been waiting for months received a letter from Alfa Romeo sent them my details, for them to get in touch with me when the remedy for this potential dangerous fault to be rectified. Many crashes have taken place, as the car could potentially cut out whilst on the highways. For Alfa Romeo to leave me in a state where this car could cut out without warning at any stage is not unacceptable. I have to use my car for work, and I am having to resort to using other means with the fear this car could cut out on me on the freeways. They have failed to respond to my email or have they sent me a followup letter to get my car booked in and fixed.

NHTSA ID

11713235

Incident

Nov 1, 2025

The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The check engine and service electric throttle warning lights were illuminated. The contact stated that the failure had occurred while it was hot outside. The contact was stranded and sat in the inoperable vehicle. In addition, the contact was pregnant and very uncomfortable sitting in an inoperable vehicle. The contact waited in the vehicle while waiting for the tow truck. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,500.

NHTSA ID

11689525

Incident

Sep 24, 2025

Mileage

69,500 mi

There were several code error messages describing a fuel pump issue that also creates other engine components to fail. For my concern of the safety my life, I paid to tow my vehicle directly to the car dealership service department to be inspected and am currently waiting to be contacted of their findings. In order to be able to move my car from blocking traffic and out of harm's way, the error codes had to be erased. I took pictures of the error codes prior to erasing and provided them to the service department for their review. Warning lamps and messages flashed simultaneously when my vehicle ceased to function. While driving my 2018 Alfa Romeo Giulia Quadrifoglio September 16, 2025, the engine ceased to function under legal normal driving conditions for no apparent reason. The engine immediately turned itself off, and both the steering wheel and vehicle was locked in place (unable to move). This event jeopardized me, and other affected drivers' lives. It was only due to the quick reaction of defensive driving attentiveness that prevented the potential collision of multiple vehicles including loss of life/lives. I had taken my vehicle to the same service department previously in November 2024 for the exact same type of issue (ceased vehicle, locked in place steering wheel and vehicle). However, because error messages were erased, the service department would not be able to know what steps were needed to fix the problem and that I should bring back my vehicle with error codes intact should this occur again. I have this in writing on my invoice. No police report involved as no physical accident/damage occurred, and everyone who was involved including myself left without further incident, and very traumatized.

NHTSA ID

11688274

Incident

Sep 16, 2025

The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while driving 60 MPH, the vehicle lost automotive power, and the contact pulled over. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the vehicle needed to be taken to the dealer to be diagnosed. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 63,000.

NHTSA ID

11688141

Incident

Sep 8, 2025

Mileage

63,000 mi

UNKNOWN, driving down a busy road and check engine light popped up and service electronic throttle system as well car stalled in the middle of the road and would not start when I tried to it would crank but not start. I noticed this incident was occurring in the past when I was close to half a tank of gas but now it’s occurring when I’m at 3/4 tank. I already addressed the possible issue of being a weak battery as I had to spend $250 on a new battery and the next day it happened again. After going through the forums and speaking with dealers they all have the same diagnosis that the fuel pump is going out. I would buy a fuel pump and replace it myself but you have to replace the module with it and have to have a very expensive scanner to sync the two together.

NHTSA ID

11687946

Incident

Aug 30, 2025

When driving on the highway, the car completely stalled. Without warning service engine and service transmission light illuminated on instrument cluster. P008a low fuel pressure. Safety was put at risk. Unable to move car safely away from traffic at night. The car was just serviced at an alpha romeo dealership three weeks prior with similar symptoms for the 3rd time. After brief research, this seems to be a common issue with these car.

NHTSA ID

11677664

Incident

Jul 30, 2025

The contact owns a 2018 Alfa Romeo Giulia. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel pump module had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 50,000.

NHTSA ID

11638916

Incident

Jan 27, 2025

Mileage

50,000 mi

Vehicle has a known issue with fuel pump which causes it to randomly turn off. Mine stopped in the middle of a busy service road and I had to get towing and police to help with getting the car off the road and diverting traffic. The car has turned off several other times as well, but the incident on 8/8 was documented via tow receipt.

NHTSA ID

11631389

Incident

Aug 8, 2024

The vehicle has a CEL, takes longer than normal to start and shakes at idle. It has also lost motive power while idling and stalled a few times while on the road. I believe this is related to a low-pressure fuel pump failure. The car was taken to the dealership where they confirmed a failing fuel pump. Alfa Romeo released a Technical Service Bulletin but the dealership quoted over $2,000 for the repair with no ETA on the part which should be a recall. Please add this complain to the ongoing investigation and hope to have a resolution soon for my own safety.

NHTSA ID

11624397

Incident

Jun 12, 2024

Fuel pump issues have caused my car to create unsafe driving. My etc system kicks on and off while driving which causes massive loss of power then accelerates to the point of red line. it's like I'm putting my pedal to the floor in traffic when trying to inch up. Fuel lump is on order for me but has been on back order for more than 3 months with no date of shipment. Dealership said car was OK to drive but could ultimately cut off and not start back up till this part is replaced.

NHTSA ID

11622230

Incident

Oct 28, 2024

My fuel pump has been failing multiple times over the last 4 months. It has left me stranded in the middle of intersections, freeways, and highways on multiple occasions that has cause back up traffic and areas of the road completely closed until I can move my car. I have had this car diagnosed twice with a certified mechanic shop and a master tech with these issues and it is confirmed both times that I need a new fuel pump. When contacted Alfa Romeo/ Mike Ward dealership for review, diagnostic scans, and part replacement they told me it could be a couple of weeks until my car can even be looked at. Both my shop and the dealership have told me that this part is on back order with no ETA and no possible way of getting that part so my car can be functional. These issues first appeared when I would accelerate from a complete stop and it would take a few seconds for my car to begin moving. This slowly progressed into my check engine light, auto start/ stop error light, electric throttle error light, and front crash detection light have all turned on and remained on for about 2 months until the car began dying in the middle of the street. This had come to be so servers that the car is now no longer drivable and each time it is driven it dies within a few minutes of driving.Again since there is no ETA there is no way for me to fix my car, this is my only mode of transportation and it has left me ain multiple dangerous situations and now with no transportation now that Alfa Romeo is refusing to make the parts needed for repair.

NHTSA ID

11621179

Incident

Jul 30, 2024

The contact owns a 2018 Alfa Romeo Giulia. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that the failure had occurred twice. In addition, the contact stated that the failure occurred while driving on the highway. The vehicle was taken to the dealer where it was diagnosed with a fuel pump failure. The contact was informed that the fuel pump and the fuel pump module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 29,000.

NHTSA ID

11618146

Incident

Sep 11, 2024

Mileage

29,000 mi

The contact owns a 2018 Alfa Romeo Giulia. The contact stated while driving approximately 15 MPH, the vehicle lost motive power and stalled and failed to immediately restart. The vehicle was eventually restarted; however, while driving approximately 50 MPH on a freeway, the vehicle stalled again. The vehicle was towed to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not yet repaired. The contact was informed of the NHTSA Action Number: PE24003 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 19,200.

NHTSA ID

11615372

Incident

Sep 5, 2024

Mileage

19,200 mi

After a 3 hour drive I had parked curb-side on a busy street to go into a store. I returned within 10 minutes, started the car, and as I was pulling out into traffic the car stalled after moving about 20 feet. All the dash lights came on and it would crank but not start. The car is in the right lane of a busy 3 lane road at this time. Also, after it stopped rolling it put itself in PARK, and because it has electronic transmission selection, I could not get it into Neutral to push it out of the way without the engine running. . The situation was very perilous. A wrecker came and got the car home. Once home I pulled the OBD codes myself and found P0087 Low Fuel Pressure and P008A also Low Fuel Pressure. After researching I have found that this is a known defect in these cars going on several years now. What is the delay in requiring Alfa to issue a recall of these faulty fuel pumps and fuel modules? Had this pump failure happened on an interstate at highway speeds it could have been fatal.

NHTSA ID

11609065

Incident

Aug 2, 2024

While in drive at speed the car would stall and all warning lights would indicate errors such as service engine, auto stop start fault, electronic throttle control, among others. The car could not be put into neutral, and would not restart for several minutes ( 30 minutes). This problem had occured previously (three times before).

NHTSA ID

11608177

Incident

Aug 3, 2024

On July 2, vehicle would not start. When pressing start button it continuously would try to crank but would not start. Check engine light, auto start on/off light, and ETC light came on. After 30-40 minute wait time, car started. Called dealer the following day but after multiple starts the lights/codes on dash went away. Dealer had no way to read the codes. On August 12, car started with the aforementioned lights turned on but after placing car in reverse and backing up some 10 feet it turned off. Car could not start again displaying the same symptoms as on July 2. This happened in a busy Costco parking lot blocking people from being able to get out of their parking spaces. No way to place car into Neutral to push out of way of traffic. After about 20 minutes or so, it managed to start. Drove to local Autozone to get codes read. P0087, P008A codes relate to low fuel pressure Next stop is dealership and hoping the lights do not turn off before dealer can look at. Both times this happened the car went on longer distance trips in hot weather in excess of 95 degrees Fahrenheit.

NHTSA ID

11608121

Incident

Aug 12, 2024

While driving at approximately 45mph, the car was suddenly dropped into "limp mode" which caused a rapid deceleration, loss of power, and required pulling onto the shoulder as the car refused to accelerate. In addition, the check engine light illuminated, along with warnings that the start / stop system was unavailable and to service the electronic throttle. Restarting the car did not fix the condition. It's also important to note the car had approximately half a tank of gas. When serviced, the technicians reported that the P008A and P062A were present, indicating an issue with the fuel pump. The fuel pump was replaced (see attached files).

NHTSA ID

11603000

Incident

Jul 3, 2024