2019 Alfa Romeo Giulia Fuel system Problems

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated that while exiting a gas station, the vehicle shut off with the "Check Engine" and "Service Electronic Throttle Control" messages displayed. The manufacturer was made aware of the issue but offered no assistance. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ID

11754974

Incident

Apr 1, 2025

The vehicle is subject to Alfa Romeo Safety Recall 93C (NHTSA Campaign 25V586) for a defective Fuel Delivery Module. The safety defect is an active, un-remedied hazard. The vehicle is currently located at [Name of Alfa Romeo Dealership] for an official diagnosis and is available for inspection. The vehicle has an active safety recall for sudden, catastrophic engine stalling at highway speeds due to fuel pump warping. Because the manufacturer has not provided a remedy or a safe alternative transport, I am forced to choose between driving a vehicle with an acknowledged highway-stalling hazard or being completely deprived of my transportation. The vehicle cannot be safely operated in commerce until Recall 93C is performed. The vehicle is currently undergoing inspection by the manufacturer's authorized technicians at the Alfa Romeo dealership. It has also been reviewed administratively through a claim with the National Center for Dispute Settlement (NCDS), which was denied based on mileage despite the active federal safety recall. The vehicle displayed an "Excessive Oil" warning and experienced heavy smoking from the engine bay beginning around June 25, 2026. While the vehicle has also been undergoing cooling system repairs, the presence of these severe engine warnings and thermal symptoms creates an immediate escalation of risk when combined with the active 93C fuel pump recall.

NHTSA ID

11747585

Incident

Jun 29, 2026

The contact owns a 2019 Alfa Romeo Giulia. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle hesitated before accelerating as intended. No warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received a recall notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts required for the recall repair were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,000.

NHTSA ID

11742994

Incident

Apr 9, 2026

Mileage

22,000 mi

Check engine light, electronic throttle control warning, and auto start/stop warning lights illuminate intermittently. OBD scan revealed codes P018B and P018D (Fuel Pressure Sensor B Circuit). Freeze frame data shows fuel rail pressure at 20,030 kPa under full throttle load, significantly below expected range. Engine running lean with short term fuel trim at +11.7%. Dealer and FCA confirmed awareness of fuel pump recall 93C covering this vehicle but no remedy currently available. Vehicle poses stall risk under acceleration

NHTSA ID

11742447

Incident

Jun 6, 2026

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ID

11731084

Incident

Apr 14, 2026

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle went into LIMP Mode and stalled. The check engine warning light was illuminated. The vehicle was able to be restarted. The vehicle was taken to Firestone, and an oil change was performed, and the cabin air filter and water pump were replaced; however, the failure persisted, with the check engine, engine oil, and several other unknown warning lights intermittently illuminated. The vehicle was then taken to an independent mechanic, who determined that the fuel pump had low pressure and needed to be replaced. The dealer was made aware of the failure but informed the contact that there would be a charge for a diagnostic test. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

NHTSA ID

11730233

Incident

Oct 15, 2025

Mileage

160,000 mi

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the check engine warning light and several unknown warning lights illuminated, and the vehicle unintendedly shifted to neutral(N) and lost motive power. The contact pulled over to the side of the road, turned off, and restarted the vehicle; however, there was a delay before the vehicle reached 35 MPH while driving. The contact stated that after refueling the vehicle, the warning lights turned off. The failure reoccurred whenever the fuel level was low. The dealer was notified of the failure and informed the contact that the failure was related to the fuel pump, but the part to do the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, and the contact was advised to wait for the second recall notification to proceed with the scheduling of the recall repair. The failure mileage was approximately 100,000.

NHTSA ID

11717805

Incident

Oct 13, 2025

Mileage

100,000 mi

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact expressed safety concerns. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11713741

Incident

Jan 27, 2026

Twice now, my 2019 Giulia, which only has 27,100 miles, has flashed a check engine light and a "flash/lighting" symbol while driving at highway speeds. When this happened, the vehicle's throttle became unresponsive. This resulted in a sudden power loss--the accelerator would not respond to input, which creates a huge safety issue. I had it towed as I did not want to cause an accident. My trusted mechanic ran the diagnostic code (P008a) which indicated low pressure from the fuel pump. This is addressed in recall numbers 93C (Manufacturer) and 25V-586 (NHTSA). However, NHTSA does not show any active recalls for my vehicle VIN. My local dealership indicated this is because Alfa Romeo has not distributed the correct parts to the dealerships. Alfa Romeo customer service said this is incorrect. I am stuck with an unsafe and unreliable vehicle due to the precise recall item that Alfa Romeo says does not apply to my vehicle.

NHTSA ID

11713602

Incident

Jan 25, 2026

The contact owns a 2019 Alfa Romeo Giulia. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). The contact researched online and determined that the part was not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and the manufacturer were not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11712181

Incident

Sep 9, 2025

There is an open safety recall on my vehicle since September 2025 with no updates on when a remedy will be available from Stellantis. The issue is that fuel supply to the engine can be cut off causing the vehicle to lose power unexpectedly and go LOMP. I cannot drive the vehicle in this state because it is dangerous if the engine were to cut off unexpectedly at highway speeds, especially since I have a baby. Safety recall information: Issue date: Sep 09, 2025 Manufacturer Recall Number: 93C NHTSA Recall Number: 25V-586 Recall Status: Recall Incomplete, remedy not yet available It is unacceptable that Stellantis have still not provided a remedy or an ETA to fix the problem even after 4 months. My car is sitting idly in the garage and I'm paying hundreds of dollars every month in loan and insurance costs without being able to drive. I have called my dealership several times and they don't have an update from the manufacturer yet either. I would like to make a formal complaint against Stellantis to fix this issue with immediate urgency since it is dangerous to drive the car in its current state and I'm just losing money without being able to use it.

NHTSA ID

11709563

Incident

Sep 9, 2025

Remedy not available yet

NHTSA ID

11708692

Incident

Jan 3, 2026

Car suddenly got p018c & p018b codes along with (setc) notification while on freeway and continuously would go in and out of limp mode when accelerating or breaking which nearly caused me to crash. when arriving home I check my fuel pump relay and it looked burnt or overheated, I tried replacing sensors as well as relays but the problem remains whenever accelerating or breaking at low speed now, just without the check engine light.

NHTSA ID

11705218

Incident

Dec 14, 2025

My car would not accelerate. “Electronic Throttle Warning” and my “auto start stop” lights popped up on dashboard. Dealer claimed it was something else, had me pay and the problem is still occurring. They cannot figure it out I think it’s the recall and they tell me they’re unsure. My car has a recall in which all these things happen with the recall but they keep saying it’s not.

NHTSA ID

11701290

Incident

Nov 18, 2025

My engine shut off and I was entering my driveway. All the electric was fine. The vehicle would no longer start. I towed it to the dealer and was told that the fuel pump and a module for the fuel pump would have to be replaced. The dealer cannot find the part anywhere because it is on back order. Apparently this is happening a lot. This should be investigated for a safety recall due to it happening while I was driving.

NHTSA ID

11637817

Incident

Nov 8, 2024

When traveling at approximately 40 mph, the vehicle displayed a service electronic throttle control warning. Turned on the engine light, then after 1 second the vehicle shut off while in motion with no warning. This disabled all power including brakes and power steering. After clearing engine code vehicle worked for around 20 minutes before repeating while idle in my driveway. Engine code displayed is p008a. (Low fuel pressure)

NHTSA ID

11636058

Incident

Jan 5, 2025

Car stopped suddenly and won’t start ships I was at traffic light on a county road

NHTSA ID

11629145

Incident

Aug 13, 2024

The contact owns a 2019 Alfa Romeo Giulia. The contact stated while driving at approximately 55 - 60 MPH, the vehicle stalled. The START/STOP, check engine, steering malfunction, and the loss of traction control warning lights were illuminated. The vehicle failed to start. The vehicle was towed to the residence and the vehicle remained parked for the rest of the day. The contact was able to restart the vehicle the following day. The contact stated that a week later while driving approximately 55 - 60 MPH, the failure reoccurred. The vehicle was towed to the residence; however, the vehicle failed to start the following day. The vehicle had not been taken to the dealer, but the dealer was contacted. The dealer informed the contact that there was a known failure with the fuel pump and fuel pump module and the parts were currently not covered under recall or back order. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 46,783.

NHTSA ID

11615349

Incident

Sep 5, 2024

Mileage

46,783 mi

Vehicle has 23862 thousands miles while I was driving on [XXX] from keys to Miami Cara starts to lose power shut off in the middle of the road and kept me stock there for few Hours until was able to get the car home ind meter tells me it low pressure fuel line in few words looking and asking to mechanics it’s the fuel pump and module to be replaced this was one freighter moment INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11608852

Incident

Aug 13, 2024

While driving on the highway I got an error alert "Service Electronic Throttle" and my gas pedal stopped working almost immediately. I was fortunate enough to coast to the next exit and pull off in the shoulder. The car would not start. I unplugged the battery and waited 5 minutes. After reconnecting the battery, I was able to drive 4 miles home, and the next day I drove 7 miles to the Alfa dealer. Since I reset the battery in order to start the car, they told me there were no codes visible and they sent me home with the car. I drove for 70 miles until the same issue happened. This time I was on a road with no shoulder but was able to pull off into a parking lot. I tried to reset the battery again to make it home but I was only able to make it about 100 yards down the road and I pulled off into a construction driveway. I reset the battery once last time to make it another 100 yards down the road until I coasted into a parking lot. Each time the gas pedal completely stopped responding and I was left to cruise as far as I could. If the car turns off and won't start again you are not able to put it into neutral and move it to a safe spot. When I brought it to the dealer the second time they gave me an error code of "P008A-00" and replaced the fuel pump. They also told me I should try to always use the same gas station and never drive below a quarter tank of gas. There is a service bulletin for this issue in 2017-2018 Alfa Romeo Giulia's but I have not seen anything yet for 2019. I was very luck in all 4 instances of the gas pedal failing but if it went out while trying to pull across multiple lanes of traffic I could have easily been hit. You can also only make it as far as the car will coast so I could have been stranded in the middle lane on the highway if there was heavier traffic.

NHTSA ID

11605232

Incident

Jul 9, 2024

WENT TO START COLD CAR IN MORNING, THE ENGINE WOULD NOT CATCH. TRIED FOR A SECOND TIME AND AGAIN, STARTER TURNED OVER FOR 10-15 SECS THEN STOPPED. THINKING IT MAY BE THE BATTERY I EXITED THE CAR TO GET THE JUMP STARTER - AND COULD SMELL GASOLINE. I COULD SEE A GROWING PUDDLE OF GASOLINE ON THE DRIVEWAY UNDER THE FRONT WHEELS AND WHEN I LIFTED THE HOOD THE ENTIRE TOP OF THE ENGINE WAS WET WITH GASOLINE. ALFA DEALERSHIP HAVE DETERMINED IT IS THE EXACT SAME FUEL LINE THAT SPLIT ON THIS SAME VEHICLE IN AUG 2020. SEE NHTSA CASE# 11353843 FOR THE AUGUST INCIDENT. ALFA DEALERSHIP TECH ALSO NOTED THIS IS NOT THE ONLY SPLIT FUEL LINE HE HAS REPLACED WITH EXACT SAME PART NUMBER: 68364747AA. ONCE AGAIN I AM INCREDIBLY LUCKY AND GRATEFUL THAT THIS FUEL LINE SPLIT, LIKE THE FIRST, DID NOT HAPPEN OVER A HOT ENGINE.

NHTSA ID

11385565

Incident

Dec 28, 2020

Mileage

10,000 mi

MY CAR SINCE I HAVE HAD IT HAS HAD 1 RECALL, SOME TYPE OF ELECTRICAL PROBLEM, AND 3 TIMES IT HAD TO GO TO THE SHOP BECAUSE OF FUEL SYSTEM FAILURE. I WAS TOLD IT WAS A LOT OF WATER IN THE SYSTEM, BUT I USED THE SAME GAS STATION THAT THEY USE TO PUT GAS IN THE CAR AFTER IT WAS DRAINED AND REFILLED. EVERY TIME I HAD AN ISSUE WITH MY CAR I WAS ALWAYS IN MOTION. ONCE THIS CAR STOPS YOU ARE STUCK WHEREVER YOU ARE AT BECAUSE YOU CAN NOT PUT THIS CAR IN NEUTRAL TO PUSH IT OUT OF THE ROAD. I HAVE FELT LIKE MY LIFE WAS IN JEOPARDY EACH TIME THIS CAR HAS STOPPED ON ME. I HAVE NO PHOTOS BECAUSE MY CAR IS CURRENTLY IN THE SHOP RIGHT NOW. IT HAS BEEN IN THE SHOP SINCE 10/03/2020

NHTSA ID

11363581

Incident

Oct 3, 2020

Mileage

17,025 mi

(VEHICLE IS 2019 WITH 7404 MILES RECORDED ON DATE OF INCIDENT). MORNING OF 18TH AUG 2020. THE CAR SAT OVERNIGHT SO WAS 'COLD' WHEN I STARTED IT. I IMMEDIATELY SELECTED REVERSE AND BEGAN BACKING UP (EXACT SPEED UNKNOWN, BUT 'SLOW'). APPROX 10 SECS AFTER STARTING THE ENGINE THE VERY STRONG ODOR OF GASOLINE ENTERED THE COCKPIT - I IMMEDIATELY SHUT OFF THE ENGINE. EXITING THE VEHICLE I COULD SEE A TRAIL OF FLUID 10 FT LONG ON THE CONCRETE DRIVEWAY AND THE SCENT IDENTIFIED IT AS GASOLINE. I LIFTED THE HOOD & GASOLINE WAS ALL OVER THE TOP OF THE ENGINE AND DRIPPING DOWN OFF THE UNDERSIDE OF THE HOOD. LOOKING CLOSER I COULD SEE POOLS OF GAS HAD COLLECTED ANYWHERE THERE WAS A DEPRESSION IN WHICH LIQUID COULD COLLECT ON & AROUND THE ENGINE. SEVERAL LITERS OF GASOLINE HAD BEEN EJECTED OVER THE ENGINE. CAR WAS TOWED TO THE NEAREST ALFA SERVICE DEALERSHIP (GOLLING, BLOOMFIELD HILLS). THE DEALERSHIP REPLACED A BROKEN/SPLIT FUEL HOSE ON THE PASSENGER SIDE OF THE ENGINE UNDER WARRANTY. THEY VERBALLY TOLD ME THE PART WAS SENT TO ALFA CORPORATE AND I SHOULD CONTACT THEM TO FOLLOW THE INVESTIGATION. I CONTACTED ALFA CORPORATE AND THROUGH EMAIL EXCHANGES, DISCOVERED THAT ALFA CORPORATE WILL NOT BE INVESTIGATING THIS SAFETY ISSUE AT ALL. I ATTACH ALL THE EMAIL CORRESPONDENCE BELOW. MY VERY SERIOUS CONCERN IS THAT THE DEALERSHIP VERBALLY SAID THEY HAD NO IDEA HOW THIS COULD HAVE HAPPENED - "MAYBE A WEAK SPOT" - BUT ALFA CORPORATE WOULD INVESTIGATE. AT THAT POINT I WAS SATISFIED. THEN SEVERAL DAYS LATER ALFA CORPORATE INFORMED ME THAT THE DEALERSHIP GUESS OF "MAYBE A WEAK SPOT" WOULD BE THE OFFICIAL CONCLUSION AND END OF THE INVESTIGATION. I MENTION IT SEVERAL TIMES IN MY (ATTACHED) EMAILS BUT IT IS OBVIOUS THAT I AVOIDED BEING IN A MOVING FIREBALL BY ONLY MINUTES AND MAYBE LUCK. AN INVESTIGATION BY AN ENGINEER IS THE MINIMUM I WOULD EXPECT FROM ALFA CORPORATE.*DT*DT*JB*DT*JB*AS

NHTSA ID

11353843

Incident

Aug 18, 2020

Mileage

7,404 mi