2019 Audi Q8 Fuel system Problems

engine begin to misfire and felt like it was ready to stall. within a minute of the misfiring the engine light came on. i was in the middle of highway struggling to get my vehicle to the dealership where purchased which thankfully was only 5mins away. tech heard noise coming from fuel pump near the engine and recommended replacing along with spark plug. after replacing tech advised me to take my vehicle to audi to perform a software update that will correct the misfire and prevent the MIL from illuminating. Got that done to only be presented with a knocking noise again a month or two later. Took my car back to Audi to run a full diagnostic to find out my engine is in early engine failure due to metal shavings in the oil filter. tech states shavings in the oil could originate from the fuel pump failure and the debris would have traveled into the engine oil causing critical damage to the engine.

NHTSA ID

11688191

Incident

Jun 27, 2025

There is helicopter type of noise coming from fuel pump and it’s increasing while driving very annoying and i feel steering is loose and I notice on google same problem with so many Audi q8 and sq8

NHTSA ID

11638621

Incident

Jan 14, 2025

I was smelling fuel from my car so stopped to have it checked and was told there is a significant spray of fuel coming from the fuel rail and hitting the electrical wires. I was told that it could go on fire at anytime and the car cannot be driven. Audi has a recall for this exact issue for 2016-2018. This is clearly the same issue but they are not issuing a recall for 2019 models and it’s extremely dangerous.

NHTSA ID

11616547

Incident

Sep 24, 2024

The alternator failed causing the vehicle to shutdown in the middle of traffic. I was on a surface road not the highway so I was able to get local police to assist. When it failed there was no car electrical system function, so I could not even turn on my emergency blinkers. This is apparently very common on Audis, as the same part was used to replace the alternator…. It took a month for the dealership to get the part in stock.

NHTSA ID

11582506

Incident

Oct 22, 2023

May 19th water pump cooling system pump my wife driving right on a highway on a left lane car start streaming and engines suddenly shut off thank God she make it to the left on hwy we throw the car to dealer they says engine went because of water went to engine and after that I have a big issue with the dealers and everything even my insurance pay for the new engine and everything and this is the issue a woman driving this car this is so much risk audi not doing anything about it

NHTSA ID

11550858

Incident

May 19, 2023

Electrical malfunction warning light and assorted other warning lights came on during acceleration on highway. Loss of car functions due to error. Car is waiting on parts due to failed belt start generator as part of its 48 volt mild hybrid system.

NHTSA ID

11548778

Incident

Oct 3, 2023

While driving in heavy traffic on 12/23/22 the entire electrical system shut down and all power was lost. Fortunately I was not hit by another vehicle and coasted into a parking lot with no power. This is very dangerous. Per conversations with the dealership and with Audi (1/10/23), alternators on thousands of vehicles are failing (possibly due to a software issue). The vehicles are sitting on dealer lots and in driveways useless. Audi online forums confirm this as well. There are no alternators available. No recall has been issued and no warning of this unsafe situation has been made by Audi. Per the dealership, they are largely in the dark as well as there has been no meaningful communication by Audi. Someone will get hurt when their car dies on a highway. People are paying thousands for their cars to be undrivable. Audi dealers will not trade the vehicles because they are effectively worthless until repaired.

NHTSA ID

11501011

Incident

Dec 23, 2022

The Generator (Part #: 4N0903028P) failed causing the car to shutoff while driving. This is a known issue by Audi as it has issued a TSB. Further steps must be taken by the OEM to ensure safe operation of the vehicle by its owners. This is a safety issue that must be resolved soonest!

NHTSA ID

11499927

Incident

Dec 19, 2022

Driving down the road when sensors stopped working. Car read electrical system malfunction and engine shut down. Had to coast to the shoulder. This is a known safety issue, and should be completely recalled.

NHTSA ID

11496095

Incident

Nov 28, 2022

The contact owns a 2019 Audi Q8. The contact received notification of NHTSA Campaign Number: 22V516000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11494564

Incident

Nov 22, 2022

The contact owns a 2019 Audi Q8. The contact received notification of NHTSA Campaign Number: 22V516000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated while driving at an undisclosed speed and then stopping at a traffic light, the vehicle stalled. The contact stated that he restarted the vehicle several times however, the failure recurred several times. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 36,700. VIN tool confirms parts not available.

NHTSA ID

11492928

Incident

Sep 4, 2022

Mileage

36,700 mi

I'M VERY UPSET WITH NHTSA AND AUDI. I SUBMITTED A COMPLAINT WITH NHTSA ON 10/22/20 AND THE COMPLAINT NUMBER IS 11365744. AGAIN AS STATED IN MY COMPLAINT THIS IS AN ACTUAL SAFETY ISSUE. I THEN TOOK THE VEHICLE INTO THE DEALERSHIP FOR THEM TO LOOK AT THE PROBLEM. WELL IT TURNS OUT THAT THE DEALERSHIP'S SERVICE DEPARTMENT HAS HAD A NUMBER OF COMPLAINTS JUST LIKE MINE. IT ALSO TURNS OUT THAT AUDI HAS A FIX FOR THE PROBLEM. THE FIX IS A SOFTWARE UPDATE 37M6. I'M GLAD THE ISSUE HAS BEEN FIXED ON MY VEHICLE BUT THE REAL ISSUE IS THAT NHTSA AND AUDI ARE AWARE OF THIS FIX BUT BOTH OF THESE ENTITIES ARE NOT REQUIRING THE FIX TO BE MADE VIA A GOV'T ISSUED RECALL. AUDI CALLS THIS FIX A "CAMPAIGN". AUDI IS AVOIDING THE STANDARD PRACTICES OF NHTSA BY REFERRING TO THIS PROBLEM AND FIX AS A CAMPAIGN WHICH IS OUTSIDE OF THE NORMAL TECHNICAL SERVICE BULLETIN AND SAFETY RECALL PROCESS. HAS NO ONE AT NHTSA OR AUDI LEARNED THE LESSONS OF THE GM DEBACLE WITH THE IGNITION SWITCH. THIS COVER UP BY NHTSA/DOT AND AUDI IS A COMPLETE AN UTTER DISGRACE. TO ALLOW AUDI TO OPERATE OUTSIDE OF THE NHTSA SYSTEM IS A COMPLETE FAILURE. NHTSA NEEDS TO MANDATE AUDI ISSUE A SAFETY RECALL ASAP!

NHTSA ID

11373792

Incident

Nov 5, 2020

Mileage

8,130 mi