RoadVitals

2003 Autocar Wx Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Newest Jun 21, 2005
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

4 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

05V295000

BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT

Jun 21, 2005
649 units potentially affected
The defect: ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE BACKUP ALARM MOTION SENSOR MAY NOT HAVE BEEN INSTALLED CORRECTLY AND MAY NOT SENSE WHEN THE VEHICLE MOVERS BACKWARDS UNDER ANY CIRCUMSTANCES.
The risk: THE VEHICLE MAY ROLL BACKWARDS WITHOUT THE BACKUP ALARM SOUNDING WITH THE RISK OF RUNNING OVER OR CRUSHING A PERSON STANDING OR WORKING BEHIND THE VEHICLE.
The remedy: DEALERS WILL REPOSITION THE MOTION SENSOR IN RELATION TO THE MAGNETS THAT ROTATE WHEN THE VEHICLE MOVES. THE RECALL BEGAN ON OCTOBER 19, 2004. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.
AUTOCAR, LLCManufacturer number A-0402-AView on NHTSA.gov
05V032000

SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

Feb 3, 2005
140 units potentially affected
The defect: ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH BENDIX AUTOMATIC BRAKE SYSTEMS (ABS), THE BRAKES MAY HAVE A SYSTEM FAULT THAT MAY NOT BE DETECTED BY THE ABS ELECTRONIC CONTROL UUNIT (ECU) AND THEREFORE WILL NOT GENERATE AN ABS WARNING LIGHT ON THE DASH OF THE TRUCK.
The risk: THE ABS BRAKES MAY NOT PERFORM AS DESIGNED AND IN AN ABS ASSISTED STOP THE DRIVER MAY NOT BE ABLE TO MAINTAIN STEERING CONTROL OF THE VEHICLE. WHEN VEHICLE CONTROL IS COMPROMISED THERE IS A CHANCE FOR A CRASH.
The remedy: DEALERS WILL INSPECT, RESET AND CHECK THE ECU FOR FAULT LIGHTS AND CHECK THE ABS BRAKES FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 11, 2005. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.
AUTOCAR, LLCManufacturer number A-0501View on NHTSA.gov
04V390000

WHEELS:LUGS/NUTS/BOLTS/STUDS

Aug 10, 2004
33 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH ACCURIDE 22.5 X 9.00 - HUB PILOT H.D. STEEL WHEEL RIMS, THE REAR AXLE WHEEL STUDS ARE TOO SHORT. THESE STUDS MAY NOT BE ABLE TO RETAIN THE WHEEL NUT TORQUE AND COULD LOOSEN ALLOWING THE LOSS OF A WHEEL.
The risk: IF A VEHICLE LOSES A WHEEL WHILE TRAVELING DOWN A ROADWAY, A CRASH COULD OCCUR, PROPERTY DAMAGE TO FOLLOWING VEHICLES OR PERSONAL INJURY TO PERSONS OUTSIDE THE VEHICLE.
The remedy: DEALERS WILL REPLACE THE REAR AXLE WHEEL STUDS. THE RECALL BEGAN ON SEPTEMBER 3, 2004. OWNERS SHOULD CONTACT AUTOCAR AT 1-877-973-3486.
AUTOCAR, LLCManufacturer number A-0401View on NHTSA.gov
03V493000

POWER TRAIN

Nov 26, 2003
834 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH ALLISON HEAVY DUTY TRANSMISSIONS, THE BOLTS FASTENING THE PROPSHAFT TO THE TRANSMISSION YOKE WERE NOT TIGHTENED SUFFICIENTLY. LOOSE BOLTS CAN CAUSE DISLOCATION OF THE PROPSHAFT.
The risk: THIS CONDITION COULD CAUSE THE VEHICLE TO LOSE POWER TO ITS WHEELS AND RESULT IN A CRASH.
The remedy: DEALERS WILL INSPECT AND RE-TIGHTEN BOLTS TO THE REQUIRED SPECIFICATIONS . CUSTOMERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUTOCAR AT 1-765-489-5499.
AUTOCAR, LLCManufacturer number A-0307View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources