RoadVitals

2005 Bigdog N-Chopper

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Aug 8, 2007
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2005 Bigdog N-Chopper. 1 safety recall has been issued covering this model year; and 4 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
07V356000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Aug 8, 2007
7,611 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, A WARPED BUS BAR WITHIN THE VOLTAGE REGULATOR CAN CAUSE A SHORT CIRCUIT.
The risk: THIS COULD POSSIBLY RESULT IN A FIRE.
The remedy: DEALERS WILL REPLACE THE EXISTING CIRCUIT BREAKER LOCATED BETWEEN THE VOLTAGE REGULATOR POSITIVE BATTERY LEAD (B+ LEAD) AND THE POSITIVE BATTERY TERMINAL WITH AN ALTERNATIVE CIRCUIT PROTECTION DEVICE THAT WILL PREVENT A THERMAL EVENT IF THERE IS A SHORT TO GROUND. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BIG DOG AT 1-316-219-9129 OR EMAIL TO [email protected].
BIG DOG MOTORCYCLES, LLCView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

SIL-0008

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BIG DOG MOTORCYCLE: ELECTRICAL SIDE COVER CONTACT WITH BELT GUARD. A WIRE BUNDLE MAY PROTRUDE INTO THE RIGHT ELECTRICAL SIDE COVER. *PE

SB-1106

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BIGDOG MOTORCYCLE: NEW PRIMARY INSPECTION COVER GASKET. INSTALL NEW INSPECTION COVER GASKET ON ALL 2005-2008 BIG DOG MOTORCYCLES. *PE

SB-1102

EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT:ELECTRICAL

BIGDOG MOTORCYCLE: HIDDEN SHOCK ELECTRICAL COVER HARDWARE REPLACEMENT. ELECTRICAL SIDE COVERS MAY CRACK OR BREAK. 243-000011-00 FOR ALL MODELS EXCEPT 2006 K9. 243-000013-00 FOR 2006 K9 MODEL. *PE

SB-1099

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

BIGDOG MOTORCYCLE: FUEL TANK VENT MAY BECOME FLOODED WITH FUEL, CAUSING THE MOTORCYCLE TO RUN POORLY DUE TO A FUEL MIXTURE THAT IS TOO RICH. *PE

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.