2003 Blue Bird All American Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Blue Bird All American, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Fuel system150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
MAIN FRAME RAILS CRACKING. FOUND BY MICHIGAN STATE POLICE INSPECTOR. BUS IS RED TAGGED AND RENDERED UNUSUABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WE PURCHASE 10 NEW BLUE BIRD ALL AMERICAN SCHOOL BUSES THROUGH OUR LOCAL AUTHORIZED DEALER, WITHIN A MONTH OF RECEIVING THE 10 UNIT THEY STAR PRESENTING CODE 368 RED FAILURE, CAUSING LOSS OF POWER, WHITE SMOKE AND STALLING, THIS WAS REPORTER TO THE DISTRIBUTOR AND THEY REPLACED FUEL FILTERS AND SUGGESTED THAT THERE WAS HUMIDITY IN THE ECM. THIS SAME CODE FAILURE HAS OVERCOME ALL OF OUR UNIT IN THE LAST PAST 3 YEARS TO THE EXTENT THAT NOW WE ARE FACED WITH THE REPLACEMENT OF THE VP44 INJECTION PUMP A VERY COSTLY INVESTMENT FOR UNIT THAT HAVE EXTREMELY LOW MILEAGE (AVERAGE OF 35,000 KMS). WE HAVE FOLLOWED A VERY STICK PREVENTIVE MAINTENANCE SCHEDULE FOR ALL OUR UNIT ACCORDING TO THE MANUALS SUPPLIED THUS AFTER SUSPECTING THAT THERE COULD BE A MANUFACTURE PROBLEM WE STARTED INVESTIGATING OVER THE INTERNET AND EFFECTIVELY WE FOUND THAT THE CUMMINS 225 ISB MOTOR HAVE A HISTORY OF THIS VERY SAME PROBLEM WHICH RELATED BUT THERE ARE NON YET THAT COVER OUR UNIT, SO WE CONSIDER IT IMPORT THAT ALONG WITH ANY OTHERS OF THE SAME MALFUNCTIONING UNITS WE CAN HAVE A RECALL CONSIDERED. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .