RoadVitals

2005 Blue Bird All American Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
13
Newest Aug 13, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

13 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09V328000

SEATS

Aug 13, 2009
37,095 units potentially affected
The defect: BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
The risk: IN THE EVENT OF A CRASH, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT(S).
The remedy: BLUE BIRD WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 18, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R09PMView on NHTSA.gov
09V205000

ELECTRICAL SYSTEM:IGNITION

Jun 9, 2009
2,203 units potentially affected
The defect: BLUE BIRD IS RECALLING 2,203 MODEL YEAR 2003 THROUGH 2010 ALL AMERICAN REAR ENGINE SCHOOL BUSES EQUIPPED WITH OPTIONAL PLUG STYLE VANDAL LOCKS MANUFACTURED FROM JULY 16, 2003 THROUGH APRIL 10, 2009. THE PLUG STYLE VANDAL LOCK IS NOT WIRED TO INHIBIT THE STARTER AT THE IGNITION SWITCH WHEN THE VANDAL LOCK IS IN THE LOCKED POSITION. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."
The risk: THE VEHICLES CAN BE STARTED AND DRIVEN EVEN WHEN AN OWNER MAY THINK THEY CANNOT.
The remedy: BLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 25, 2009. OWNER MAY CONTACT BLUE BIRD AT 1-478-422-2242.
BLUE BIRD BODY COMPANYManufacturer number R09PEView on NHTSA.gov
08V229000

STRUCTURE:BODY:ROOF AND PILLARS

May 20, 2008
23,464 units potentially affected
The defect: BLUE BIRD IS RECALLING 23,464 MY 2005 THROUGH 2009 ALL AMERICAN AND VISION SCHOOL AND TRANSIT MODEL BUSES MANUFACTURED FROM JANUARY 22, 2004, AND MARCH 28, 2008, AND MY 2004 THROUGH 2007 ALL AMERICAN SCHOOL BUSES AND CONVENTIONAL MODEL SCHOOL BUSES MANUFACTURED FROM MARCH 6, 2003, THROUGH JUNE 16, 2006. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP. WITHOUT THE APPROPRIATE AMOUNT OF ROOF RIVETS, THE BUSES FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, "JOINT STRENGTH."
The risk: IN THE EVENT OF A CRASH, THESE PANELS MAY SEPARATE EXPOSING THE OCCUPANTS TO INCREASED RISK OF INJURY.
The remedy: BLUE BIRD WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE BUSES BY ADDING ADDITIONAL RIVETS. THE RECALL BEGAN ON SEPTEMBER 18, 2008. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R08NCView on NHTSA.gov
08V077000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Feb 21, 2008
607 units potentially affected
The defect: BLUE BIRD IS RECALLING 607 MY 2004-2007 ALL AMERICAN REAR ENGINE SCHOOL BUSES AND MY 2006-2007 XCEL 102 COMMERCIAL SERIES TRANSIT BUSES EQUIPPED WITH CUMMINS ISC ENGINES. THE HIGH PRESSURE FUEL LINE MAY CRACK, ALLOWING HIGH PRESSURE DIESEL FUEL INTO THE ENGINE COMPARTMENT.
The risk: THIS CONDITION CREATES THE POTENTIAL FOR A RISK OF FIRE IN THE ENGINE COMPARTMENT SHOULD THE ATOMIZED DIESEL FUEL VAPOR CONTACT AN IGNITION SOURCE.
The remedy: OWNERS WILL BE ADVISED TO CONTACT THEIR CUMMINS DEALERS TO HAVE THE REPAIR WORK PERFORMED AS SOON AS POSSIBLE. THE RECALL BEGAN ON FEBRUARY 28, 2008. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R08MZView on NHTSA.gov
05V382000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Aug 31, 2005
5,863 units potentially affected
The defect: CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.
The risk: SHOULD THE BUS SHUT DOWN WHILE IN OPERATION, A VEHICLE CRASH COULD OCCUR.
The remedy: BLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05KAView on NHTSA.gov
05V239000

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

May 20, 2005
8,894 units potentially affected
The defect: CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
The risk: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05JVView on NHTSA.gov
05V251000

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

May 20, 2005
3,121 units potentially affected
The defect: CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
The risk: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING MOTORISTS SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
The remedy: BLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05JWView on NHTSA.gov
05V152000

VEHICLE SPEED CONTROL

Apr 7, 2005
486 units potentially affected
The defect: CERTAIN 2001 THROUGH 2005 ALL AMERICAN, COMMERCIAL SERIES, AND Q-BUS SCHOOL AND TRANSIT BUSES EQUIPPED WITH JOHN DEERE 8.1 CNG ENGINES. THE SUBJECT BUSES EQUIPPED WITH THE JOHN DEERE ENGINES MAY SURGE INAPPROPRIATELY DUE TO ERRACTIC OPERATION OF THE AIR THROTTLE IF THE ENGINE IS TAKEN FROM FULL TO ZERO LOAD.
The risk: UNEXPECTED ENGINE SURGE COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.
The remedy: JOHN DEERE WILL NOTIFY BLUE BIRD'S CUSTOMERS AND REPAIR THE ENGINES FREE OF CHARGE. CUSTOMERS ARE BEING INSTRUCTED TO CONTACT JOHN DEERE AT 1-800-JD-ENGINE.
BLUE BIRD BODY COMPANYManufacturer number R05JPView on NHTSA.gov
05V074000

ENGINE AND ENGINE COOLING

Mar 1, 2005
416 units potentially affected
The defect: CERTAIN 2002-2006 MY BLUE BIRD ALL AMERICAN SCHOOL AND TRANSIT BUSES, CONVENTIONAL SCHOOL BUSES, AND COMMERCIAL SERIES TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 21, 2002, AND FEBRUARY 24, 2005. THESE BUSES ARE EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005. THE STAINLESS STEEL BURNER TUBE IS MADE OUT OF A MATERIAL THAT IS NOT TO SPECIFICATION AND COULD FAIL PREMATURELY.
The risk: SHOULD THE BURNER TUBE FAIL, THE COOLANT HEATER COULD OVERHEAT, POSSIBLY RESULTING IN A FIRE.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE BURNER TUBES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05JMView on NHTSA.gov
04V426000

EQUIPMENT ADAPTIVE/MOBILITY

Aug 30, 2004
372 units potentially affected
The defect: CERTAIN BLUE BIRD 1999-2005 ALL AMERICAN, TC/2000, MICRO BIRD, VISION, CONVENTIONAL, AND COMMERCIAL SERIES SCHOOL BUSES EQUIPPED WITH SURE-LOC WHEELCHAIR SECUREMENT SYSTEMS AND MANUFACTURED BETWEEN FEBRUARY 17, 1999, AND AUGUST 13, 2004. CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
The risk: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN SEPTEMBER 21, 2004. OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R04JBView on NHTSA.gov
04V362000

STRUCTURE:BODY:ROOF AND PILLARS

Jul 22, 2004
233 units potentially affected
The defect: CERTAIN MY 2005 BLUE BIRD ALL AMERICAN MODEL SCHOOL BUSES MANUFACTURED FROM MAY 24 THROUGH JULY 12, 2004. THESE BUSES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, SCHOOL BUS BODY JOINT STRENGTH. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP.
The risk: IN THE EVENT OF A CRASH, THESE PANELS COULD SEPARATE, EXPOSING VEHICLE OCCUPANTS TO INCREASED RISK OF INJURY.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND PROVIDE INSTRUCTIONS AND PARTS TO ADD ADDITIONAL RIVETS AS NEEDED. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R04HVView on NHTSA.gov
04V222000

SEAT BELTS

May 7, 2004
291 units potentially affected
The defect: SCHOOL AND TRANSIT BUSES EQUIPPED WITH DRIVER'S 3-POINT SEAT BELTS WITH INCORRECT FASTENERS.
The risk: IN THE EVENT OF A VEHICLE CRASH, THE SHOULDER STRAP CAN FAIL, AND THE DRIVER COULD BE SERIOUSLY INJURED.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS TO MAKE AN APPOINTMENT WITH THEIR BLUE BIRD DISTRIBUTOR TO HAVE THE DRIVER'S 3-POINT SEAT BELT UPPER ATTACHING FASTENERS REPLACED FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 8, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R04HTView on NHTSA.gov
04V213000

STRUCTURE

May 5, 2004
297 units potentially affected
The defect: ALL AMERICAN SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 10 AND APRIL 20, 2004, WHICH THE INSIDE PANELS ADJACENT TO THE REAR CENTER EMERGENCY DOOR (OR REAR CENTER EMERGENCY WINDOW ON REAR ENGINE MODELS) DO NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. ADHESIVE WAS INADVERTENTLT OMITTED FROM THESE JOINTS ON THE AFFECTED POPULATION.
The risk: THE VEHICLE OCCUPANTS MAY BE SERIOUSLY INJURED IN THE EVENT OF A VEHICLE CRASH.
The remedy: OWNERS WILL BE NOTIFIED TO MAKE AN APPOINTMENT WITH THEIR BLUE BIRD DISTRIBUTOR TO HAVE THE INSIDE REAR PANELS REMOVED AND PROPERLY ADHERE THE PANELS. OWNER NOTIFICATION IS EXPECTED TO BEGIN JUNE 9, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R04HSView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE05028ClosedPreliminary Evaluation

SCHOOL BUS STALLS

Opened May 25, 2005
Closed Sep 27, 2005

THIS INVESTIGATION WAS OPENED AFTER ODI RECEIVED A COMPLAINT FROM A SCHOOL BUS FLEET REPORTING THAT THREE SEPARATE BUSES HAD STALLED UNEXPECTEDLY WHILE THEY WERE LOADED WITH CHILDREN.REPORTEDLY, EACH TIME THE FAILURE OCCURRED THE MASTER BATTERY SHUT-OFF SWITCH WAS IDENTIFIED AS BEING DEFECTIVE.ODI OPENED THIS INVESTIGATION TO GATHER SPECIFIC INFORMATION AND DETAILS INTO THESE ALLEGATIONS.AS A RESULT OF ODI?S INVESTIGATION, BLUE BIRD HAS AGREED TO INITATE A SAFETY RECALL TO REPLACE THE STANDARD NUT ON THE 10/32 STUD WITH A LOCKING NUT, CHECK FOR PROPER WIRING INSTALLATION , AND REPOSITION THE WIRES SO THAT THEY DO NOT STRESS THE STUD.A COPY OF THE RECALL IS ATTACHED.BLUE BIRD'S ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION AND THEREFORE, THIS INVESTIGATION IS CLOSED.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLESLed to recall 05V382000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .