RoadVitals

2004 Blue Bird TC2000 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Aug 31, 2005
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

05V382000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Aug 31, 2005
5,863 units potentially affected
The defect: CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.
The risk: SHOULD THE BUS SHUT DOWN WHILE IN OPERATION, A VEHICLE CRASH COULD OCCUR.
The remedy: BLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05KAView on NHTSA.gov
05V239000

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

May 20, 2005
8,894 units potentially affected
The defect: CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
The risk: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
The remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05JVView on NHTSA.gov
05V251000

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

May 20, 2005
3,121 units potentially affected
The defect: CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
The risk: SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING MOTORISTS SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
The remedy: BLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R05JWView on NHTSA.gov
03V364000

SEATS

Oct 8, 2003
3,825 units potentially affected
The defect: ON CERTAIN SCHOOL BUSES EQUIPPED WITH OPTIONAL SEAT BELTS OR SEAT BELT "READY" SEATS, SOME BELTS WERE INSTALLED WITH ONLY TWO BOLTS RATHER THAN THE REQUIRED THREE (3) BOLTS.
The risk: THESE SEATS COULD DETACH FROM THE WALL SIDE ATTACHMENT POINTS IN THE EVENT OF A VEHICLE CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
The remedy: BLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO INSTALL THE MISSING BOLT FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO ON NOVEMBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R03HBView on NHTSA.gov
02V302000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Nov 13, 2002
485 units potentially affected
The defect: ON CERTAIN FRONT ENGINE SCHOOL AND TRANSIT BUSES EQUIPPED WITH HYDRAULIC BRAKES, THE REAR HYDRAULIC BRAKE HOSE COULD CONTACT THE FRAME RAIL AND ABRADE, ALLOWING BRAKE FLUID LEAKAGE.
The risk: IF THIS OCCURS, VEHICLE BRAKING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT THE REAR BRAKE HOSE TO FRAME RAIL CLEARANCE AND REPOSITION THE BRAKE HOSE CLAMPS AT THE AXLE TO ENSURE ADEQUATE CLEARANCE. ANY CHAFED BRAKE HOSES WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.
BLUE BIRD BODY COMPANYManufacturer number R02GRView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE05028ClosedPreliminary Evaluation

SCHOOL BUS STALLS

Opened May 25, 2005
Closed Sep 27, 2005

THIS INVESTIGATION WAS OPENED AFTER ODI RECEIVED A COMPLAINT FROM A SCHOOL BUS FLEET REPORTING THAT THREE SEPARATE BUSES HAD STALLED UNEXPECTEDLY WHILE THEY WERE LOADED WITH CHILDREN.REPORTEDLY, EACH TIME THE FAILURE OCCURRED THE MASTER BATTERY SHUT-OFF SWITCH WAS IDENTIFIED AS BEING DEFECTIVE.ODI OPENED THIS INVESTIGATION TO GATHER SPECIFIC INFORMATION AND DETAILS INTO THESE ALLEGATIONS.AS A RESULT OF ODI?S INVESTIGATION, BLUE BIRD HAS AGREED TO INITATE A SAFETY RECALL TO REPLACE THE STANDARD NUT ON THE 10/32 STUD WITH A LOCKING NUT, CHECK FOR PROPER WIRING INSTALLATION , AND REPOSITION THE WIRES SO THAT THEY DO NOT STRESS THE STUD.A COPY OF THE RECALL IS ATTACHED.BLUE BIRD'S ACTION RESOLVES THE ISSUES RAISED BY THIS INVESTIGATION AND THEREFORE, THIS INVESTIGATION IS CLOSED.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLESLed to recall 05V382000

Elsewhere on this vehicle

Data sources