RoadVitals

2016 Blue Bird Vision Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Feb 27, 2020
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Blue Bird Vision, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes150.0%
  • Engine150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

FAILURE OF THE PROPORTIONING VALVE WHICH IS CAUSING PREMATURE BRAKE PAD WEAR ON THE REAR. THE VEHICLE HAS AIR DISC BRAKES. WE HAVE SEVERAL IN OUR FLEET THAT HAS THIS ISSUE. WE BROUGHT THE BUS IN FOR SERVICE AND UPON INSPECTING THE BRAKES WE DISCOVERED THE ISSUE. WE HAVE CONTACTED THE COMPANY WE PURCHASED THE BUSES FROM AND I WAS TOLD THEY KNEW THERE WAS AN ISSUE AND THEY HAD A FIX BUT IT WOULD COST US $250. MY QUESTION IS WHO APPROVED THE FIX AND WHERE CAN I FIND IT IN WRITING. THEY ARE NOT REPLACING THE VALVE, THEY ARE PUTTING ON A QUICK RELEASE VALVE IN THE REAR.

NHTSA ID 11110684 · filed Jul 11, 2018

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

SCHOOL BUS DRIVER REPORTED AN OIL LEAK AT THE REAR OF THE LEFT SIDE VALVE COVER. I INSPECTED THE BUS AND SAW A LOT OF OIL ON THE FRAME AREA ON THE LEFT SIDE ENGINE AREA. CHECKED THE VALVE COVER BOLTS FOR TIGHTNESS AND FOUND THE BOLTS TO BE TIGHT. AT THE REAR OF THIS VALVE COVER THE AREA IS VERY TIGHT AND THERE ARE HOSES AND WIRES RAN BETWEEN THE VALVE COVER AND THE FIREWALL. I WAS ABLE TO PHYSICALLY MOVE THESE AND FEEL AROUND THE AREA AND DISCOVERED THAT A HOLE HAS BEEN RUBBED COMPLETELT THROUGH THE FIREWALL, THIS IS WHERE THE OIL IS COMING FROM. AM NOT ABLE TO TAKE CLEAR PICTURES BECAUSE OF THE SPACE CONSTRAINTS. I GOT UNDERNEATH OF THE BUS AND DISCOVERED THAT OIL HAS BEEN GETTING ONTO THE EXHAUST ALSO, THIS SEEMS TO BE A FIRE HAZARD. I HAVE CONTACTED THE DEALER, BUT AT THIS TIME IT IS UNKNOWN IF IT WILL BE COVERED UNDER WARRANTY. THIS BUS IS OUT OF SERVICE UNTIL REPAIRS ARE COMPLETE. *LN *AS

NHTSA ID 11311782 · filed Feb 27, 2020

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .