2009 BMW 335

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

TAKATA RECALL FAULTY AIRBAG DEPLOYMENT DURING MINOR ACCIDENT CAUSING NO DAMAGE TO VEHICLE. IMPACT OCCURED FROM FRONT OF VEHICLE AND AIR BAGS DEPLOYED AFTER VEHICLE WAS AT COMPLETE STOP AFTER ACCIDENT CAUSING NOSE DAMAGE AND BURN AND BRUISE ON LEFT ARM. IRREGULAR DEPLOYMENT OF AIR BAGS BECAUSE THE PASSENGER AIR BAG AS WELL AS THE STEERING WHEEL AIR BAG DEPLOYED. NO ONE WAS SEATED ON PASSENGER SIDE AND THE DRIVER SIDE VEHICLE SIDE AIRBAG WHERE I WAS SEATED DID NOT DEPLOY.

NHTSA ID

11111640

Incident

Jul 14, 2018

Mileage

87,000 mi

TAKATA RECALL; BOUGHT CAR ONLINE FROM SCHMBURG IL. BMW AND THE BMW WAS DELIVERED TO MY HOME ADDRESS IN SAN ANTONIO,TEXAS. CALLED SCHMBURG BMW AND THEY TOLD TO CALL SAN ANTONIO BMW. I DID CALL SAN ANTONIO BMW IN 2-2-2017. HAVE NOT RECEIVED ANYTHING FROM THEM AND IT'S 5/7/2018---HELP!!!

NHTSA ID

11092328

Incident

Feb 2, 2017

SCHOMP BMW, CAR DEALERSHIP, LOCATED IN HIGHLANDS RANCH COLORADO, IS ILLEGALLY SELLING RECALL AFFECTED BMWS. THE ABOVE VIN IS ONLY ONE OF SEVERAL BMW'S SOLD LAST MONTH WITHOUT THE DEALER REPAIRING THE NHTSA BMW US BLOWER MOTOR WIRING HARNESS RECALL. ANOTHER RECALLED AFFECTED BMW 3 SERIES SCHOMP BMW SOLD IN THE PAST 60 DAYS: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11065301

Incident

Jan 2, 2018

ISSUE: WHEN SEAT UNOCCUPIED, WILL RECEIVE SEAT BELT WARNING AS IF A PERSON IS IN THE SEAT. ISSUE: WHEN PASSENGER IS IN SEAT, AIRBAG AND SEAT BELT LIGHT COMES ON, WITH WARNING ON THE DISPLAY THAT THERE IS A RESTRAINT SYSTEM MALFUNCTION. DEFECT WITH FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR MAT, THERE ARE SEVERAL RECALLS FOR THIS ISSUE IN DIFFERENT YEARS/MODELS. MY YEAR IS NOT COVERED FOR THE CURRENT RECALLS, EVEN THOUGH ITS THE SAME EXACT ISSUE, AND LIKELY THE SAME MAT AND/OR SEATS. EXAMPLE RECALLS: 17V-428 13V-564 17V-605

NHTSA ID

11063038

Incident

Jul 4, 2016

Mileage

95,000 mi

TAKATA RECALL IN LATE SEPTEMBER I WAS TOLD IT WOULD BE A ROUGHLY 3 WEEK WAIT FOR PARTS. CALLED AGAIN THE WEEK OF THANKSGIVING AND WAS TOLD IT WOULD BE 4-6 WEEK WAIT. I'M STILL GETTING THE RUN AROUND BY BMW OF DALLAS AND BELIEVE THEY MAY BE ONLY HELPING SELECT PEOPLE.

NHTSA ID

11056971

Incident

Dec 27, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 BMW 335. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED THE STEVE THOMAS BMW DEALER AND WAS INFORMED THAT THEY WERE UNABLE TO PROVIDE A TIME FRAME FOR WHEN THE REMEDY WOULD BE AVAILABLE AND COMPLETED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11005159

Incident

Jul 13, 2017

TAKATA RECALL DRIVERS FRONT AIRBAG.

NHTSA ID

10934286

Incident

Mar 1, 2016

FUEL INJECTORS ARE FAULTY

NHTSA ID

10930013

Incident

Dec 1, 2016

Mileage

92,000 mi

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. BMW NA, et al

CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. BMW NA, et al

Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal stresses during rapid heating and cooling of the brake discs. Braking from high speed with cold brake components (less than 212 degrees F) increases the likelihood of cracks to form.

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.