2010 BMW 535I Problems

Consistent fuel pump error code 2AAF

I was told by BMW that the high pressure fuel pump for these vehicles are under warranty for 100,000 miles or 10 years. I just purchased the vehicle to not only drive from new jersey to New York and shut down. Since then it caused an accident and the used dealer is just ignoring everything. I was also told there’s an electric water pump class action suit and also something with the trunk leaking. Now I do know that a vehicle is not supposed to be sold without recalls being stated and fixed. I’m already paid 10k for the car and then 1k for a starter . The vehicle is in the body shop having body repair due to the engine shutting down. If the engine shuts down it displays fuel pump malfunction and within 20-30 mins will start again. The BMW 535i has 96,000 miles on it and I don’t think it’s fair that I should be penalized for someone not following thru with repairs let alone having an accident on my insurance now. I’m asking please just help get the vehicle running again and all future service will absolutely be done through BMW. That’s how I handled my Mercedes’ and plan so with this vehicle. I’m a single father that just took a severe beating financially and had to sell the Mercedes’ and thought buying a BMW was a good choice being I had a similar issue with Mercedes’ and they honored the repair due to the amount of time owned and still being in the mileage range of the defective part. Please help . Email-[XXX] Cell- [XXX] [XXX] Thank you in advance INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-25 MPH, THE VEHICLE LOSS MOTIVE POWER. THE CONTACT COASTED AND MANUALLY STEERED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT STATED THAT THE FUEL PUMP WARNING LIGHT WAS ILLUMINATED. THE CONTACT HAD THE VEHICLE TOWED TO RALLYE BMW (1 BRUSH HOLLOW RD, WESTBURY, NY 11590, (516) 226-7947) WHO HAD REPLACED AN UNKNOWN PART HOWEVER, APPROXIMATELY A WEEK LATER THE FAILURE RECURRED WITH THE SAME WARNING LIGHT ILLUMINATED. THE CONTACT RETURNED THE VEHICLE TO THE SAME DEALER AND THE FUEL PUMP WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BATTERY DISCHARGING MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DRIVE BELTS, BATTERY, INTELLIGENT BATTERY SENSOR (IBS) SYSTEM, BOLTS, HOSE AND ENGINE COOLING SYSTEM NEEDED TO BE REPLACED. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. AN UNKNOWN DEALER WAS CONTACTED AND INFORMED OF THE FAILURE BUT PROVIDED NO ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.*DT

I was told by BMW that the high pressure fuel pump for these vehicles are under warranty for 100,000 miles or 10 years. I just purchased the vehicle to not only drive from new jersey to New York and shut down. Since then it caused an accident and the used dealer is just ignoring everything. I was also told there’s an electric water pump class action suit and also something with the trunk leaking. Now I do know that a vehicle is not supposed to be sold without recalls being stated and fixed. I’m already paid 10k for the car and then 1k for a starter . The vehicle is in the body shop having body repair due to the engine shutting down. If the engine shuts down it displays fuel pump malfunction and within 20-30 mins will start again. The BMW 535i has 96,000 miles on it and I don’t think it’s fair that I should be penalized for someone not following thru with repairs let alone having an accident on my insurance now. I’m asking please just help get the vehicle running again and all future service will absolutely be done through BMW. That’s how I handled my Mercedes’ and plan so with this vehicle. I’m a single father that just took a severe beating financially and had to sell the Mercedes’ and thought buying a BMW was a good choice being I had a similar issue with Mercedes’ and they honored the repair due to the amount of time owned and still being in the mileage range of the defective part. Please help . Email-[XXX] Cell- [XXX] [XXX] Thank you in advance INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BATTERY DISCHARGING MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DRIVE BELTS, BATTERY, INTELLIGENT BATTERY SENSOR (IBS) SYSTEM, BOLTS, HOSE AND ENGINE COOLING SYSTEM NEEDED TO BE REPLACED. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 14V176000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED. AN UNKNOWN DEALER WAS CONTACTED AND INFORMED OF THE FAILURE BUT PROVIDED NO ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.*DT

ALL THE BMW HAVE RECALL ABOUT AIRBAG AND SEAT BELT ,WHY MY 535I BMW 2010 ITS NOT UNDER RECALL,.I HAVE MY LIGHT ON AND I'M SCARED DRIVING IT LOOKS LIKE I'M NOT SAFE,I WAS DRIVING TH CAR IN CITY AND I STOPPED TO DROP OFF MY WIFE SHE TAKE OUT SEAT BELT AND SHE STAND THE LIGHT COMING ON ,IT SAID RESTRAINED SYSTEM MUNFLUCTION .

TAKATA INFLATORS- SHOWS ON MY SCREEN THAT THERE IS A PROBLEM WITH MY RESTRAINT SAFETY SYSTEM.

ALL THE BMW HAVE RECALL ABOUT AIRBAG AND SEAT BELT ,WHY MY 535I BMW 2010 ITS NOT UNDER RECALL,.I HAVE MY LIGHT ON AND I'M SCARED DRIVING IT LOOKS LIKE I'M NOT SAFE,I WAS DRIVING TH CAR IN CITY AND I STOPPED TO DROP OFF MY WIFE SHE TAKE OUT SEAT BELT AND SHE STAND THE LIGHT COMING ON ,IT SAID RESTRAINED SYSTEM MUNFLUCTION .

TAKATA INFLATORS- SHOWS ON MY SCREEN THAT THERE IS A PROBLEM WITH MY RESTRAINT SAFETY SYSTEM.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WATER LEAKED INTO THE VEHICLE FROM THE SUN ROOF. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE OVERHEATED, SHUT OFF, AND ALL THE WARNING INDICATORS ILLUMINATED. FURTHERMORE, THE CONTACT'S WIFE SMELLED A FUEL ODOR EMITTING FROM THE VEHICLE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V746000(FUEL SYSTEM, GASOLINE) AND TOOK THE VEHICLE TO BMW OF MACON (4785 RIVERSIDE DR, MACON, GA 31210, 478-757-7000). THE DEALER PROVIDED A COST ESTIMATE OF $6,000 TO REPAIR THE VEHICLE, WHICH DID NOT INCLUDE THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BY MAIL WHEN THE CONTACT SENT A COPY OF THE RECALL NOTICE HE RECEIVED. THE MANUFACTURER SENT THE RECALL LETTER BACK TO THE CONTACT AND STATED THAT THIS WAS NOT INFORMATION THEY REQUESTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

THE PASSENGER MIRROR WILL MOVE OUT OF POSITION ON ITS OWN WITHOUT TOUCHING ANY CONTROLS. THIS WILL ALSO OCCUR WHEN THE CAR IS TURNED OFF. AFTER REVIEWING VARIOUS INTERNET POSTINGS OTHER BMW OWNERS HAVE EXPERIENCED THE SAME PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AS IT CAN ADVERSELY IMPACT THE DRIVER'S REAR VISION. *TR

WITHIN TWO WEEKS OF TAKING OWNERSHIP OF THIS CAR, I EXPERIENCED A SERIES OF FAULTS IN THE SYSTEM WHERE THE CAR FROZE UP AND HAD TO BE TOWED TO THE DEALER FOR REPAIR. OVER THE PAST TWO YEARS, THE CAR HAS EXPERIENCED A VARIETY OF MALFUNCTIONS IN THE ELECTRONIC WARNING SYSTEM. ON 5/22/12, UPON LEAVING MY RESIDENCE, I LOST MOMENTARY CONTROL OF THE CAR. THE CAR STOPPED, JERKED AND THEN I HIT A CURB AND WHEN I RIGHTED THE CAR, I PRESSED DOWN ON THE BRAKE PEDAL, BUT THE CAR ACCELLERATED TO A HIGH SPEED. I TRAVELLED APPROXIMATELY 100' TO WHERE THERE WERE THREE CARS AND ONE MOTORCYCLE STOPPED AT A RED LIGHT. I WAS UNABLE TO STOP THE CAR AND HIT THE DRIVER OF THE MOTOR CYCLE AT A HIGH SPEED. THE CAR WAS REPAIRED WITH NEARLY $25,000 IN DAMAGE. THE FOLLOWING MORNING AFTER I HAD RECEIVED THE CAR, AND DURING A COLD START, THE CAR DID THE SAME THING AGAIN. IT "JERKED" THE WHEEL TURNED AND THIS TIME I RIGHTED THE CAR. OVER THE NEXT FEW DAYS, THE CAR DID IT AGAIN SEVERAL TIMES. ONE WEEK LATER WHEN I WAS DRIVING IT (AGAIN A COLD START AND WITHIN 1/2 MILE OF MY HOME GARAGE), THE CAR DID THE "JERKING" MOVEMENT AND I TEMPORARILY LOST CONTROL OF THE CAR. I IMMEDIATELY PULLED OVER AND CALLED BMW TO REPORT THE SITUATION AND HAVE THE CAR TOWED. I WAS TOLD THAT IT WAS A FAULT IN THE CAR'S SOFTWARE SYSTEM. BMW HAD THE CAR AT ITS SHOP FOR 10 DAYS, RETURNED IT TO ME AND I'VE NOT EXPERIENCED THE MALFUNCTION SINCE.

I WAS ACCELERATING UP A HILL ON THE HIGHWAY AND MY CAR JUST LOST POWER. *TR

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT THE FRONT PASSENGER'S SIDE FOG LIGHT WOULD NOT ILLUMINATE AND THE HOUSING FOR THE LIGHT HAD BECOME MELTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT THE DEFECT WAS NOT REMEDIED. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THE VEHICLE WAS NOT RECALLED. THE FAILURE MILEAGE WAS 50,100.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT THE BRAKE LIGHTS AND REAR TURN SIGNALS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS TOLD THAT THE WIRES FOR THE BRAKES LIGHTS AND REAR TURN SIGNALS BURNED OUT. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2010 BMW 535I. THE CONTACT STATED THAT WATER LEAKED INTO THE VEHICLE FROM THE SUN ROOF. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE OVERHEATED, SHUT OFF, AND ALL THE WARNING INDICATORS ILLUMINATED. FURTHERMORE, THE CONTACT'S WIFE SMELLED A FUEL ODOR EMITTING FROM THE VEHICLE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V746000(FUEL SYSTEM, GASOLINE) AND TOOK THE VEHICLE TO BMW OF MACON (4785 RIVERSIDE DR, MACON, GA 31210, 478-757-7000). THE DEALER PROVIDED A COST ESTIMATE OF $6,000 TO REPAIR THE VEHICLE, WHICH DID NOT INCLUDE THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BY MAIL WHEN THE CONTACT SENT A COPY OF THE RECALL NOTICE HE RECEIVED. THE MANUFACTURER SENT THE RECALL LETTER BACK TO THE CONTACT AND STATED THAT THIS WAS NOT INFORMATION THEY REQUESTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

THE CAR LUNGES/JERKS AT RANDOM TIMES DURING STARTUP. IT DOES THIS WHETHER THE CAR IS COLD, HOT AND AT RANDOM TIMES DURING THE DAY OR EVENING. THE VEHICLE IS STATIONARY WHEN THIS OCCURS. ENGINE MOUNTS HAVE BEEN REPLACED AND TRANSMISSION MOUNT IF IN GOOD WORKING ORDER. THE DEALER CANNOT IDENTITY THE PROBLEM. AT TIMES THE JERK IS BARELY NOTICEABLE BUT OTHER TIMES THE JERK IS HARSH AND I FEAR THE THE CAR WILL MOVE FORWARD WHILE PARKED.

DESCRIPTION: THE FRONT PASSENGER SIDE DOOR ACTUATOR WENT BAD. AS A RESULT, DOOR WILL NOT UNLOCK WHEN HANDLE IS DOUBLE-PULLED. THE MAIN PROBLEM IS, THE DOOR IS DESIGNED SUCH THAT, IT CANNOT BE UNLOCKED MANUALLY BY PULLING THE LOCK STUD UP... THE ONLY WAY TO UNLOCK THE DOOR IS TO PULL THE HANDLE TWICE. THEREFORE, WHEN THE ACTUATOR MALFUNCTIONS, THE ONLY WAY TO UNLOCK THE DOOR AND GET OUT OF THE CAR IS BY PRESSING THE UNLOCK BUTTON WHICH IS ON THE MAIN CONTROL PANEL. RISK: IF I AM IN AN ACCIDENT WITH A PASSENGER SITTING IN THE FRONT PASSENGER SEAT, SHE WILL NOT BE ABLE TO OPEN THE DOOR AND GET OUT OF THE CAR. IF THE PASSENGER IS A CHILD OR SOMEONE WHO DOES NOT KNOW HOW TO OPERATE THE UNLOCK BUTTON IN THE MAIN CONTROL PANEL, IT MIGHT GET VERY SERIOUS. FREQUENCY: ABOUT SIX MONTHS AGO, MY DRIVER SIDE DOOR ACTUATOR WENT BAD, AND WAS REPLACED UNDER MY WARRANTY (UNDER 50K). BUT, I HAD TO PUT UP A FIGHT TO GET IT COVERED BY WARRANTY. NOW THE PASSENGER SIDE ACTUATOR IS GONE. AND BMW REFUSES TO FIX IT UNDER THE EXTENDED WARRANTY. BROWSING ONLINE, I FOUND QUITE A FEW PEOPLE HAVING SIMILAR ISSUES. HERE IS A DISCUSSION THREAD I OPENED, AND SEVERAL OTHER PEOPLE COMPLAINED ABOUT THE SAME ISSUE: HTTP://WWW.BIMMERFEST.COM/FORUMS/SHOWTHREAD.PHP?T=674994 ALSO, MANY MENTIONED THIS ARTICLE BELOW, WHICH MIGHT HAVE BEEN CAUSED BY THE SAME ISSUE: HTTP://GUARDIANLV.COM/2013/09/14-YEAR-OLD-GIRL-DIED-TRAPPED-INSIDE-LOCKED-CAR-VIDEO/ CONCLUSION: THIS HAPPENED TO ME TWICE IN THE SAME CAR. THIS HAPPENED TO A LOT OTHER PEOPLE. THIS IS, IN MY OPINION, A MANUFACTURER DEFECT AND DEFINITELY POSES GRAVE SECURITY RISK. BMW SHOULD TAKE RESPONSIBILITY OF THE COSTS AND GET THE FAULTY ACTUATORS REPLACED AT NO COST TO THE CONSUMERS. *TR

MY BMW 2010 5 SERIES GT ( CAMPAIGN 10V446000 ) HAS HAD ISSUES PERTAINING TOO A CHECK VALVE OF THE BREAK VACUUM PUMP THAT LEAKS A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS HAS CONTAMINATED MY BRAKE BOOSTER, AND ALSO THERE HAS BEEN ISSUES WITH THE POWER ASSIT BRAKING PERFORMANCE THAT HAS LED TOO LOSS OF POWER ASSIST BRAKING WHICH I'VE DONE RESEARCH AND THAT COULD POTENTIALLY INCREASE A RISK OF AN ACCIDENT. MY FUEL GUAGE HAS ALSO DISPLAYED A LARGER AMOUNT OF FUEL THAN WAS ACTUALLY IN THE TANK, WHICH COULD ALSO INCREASE MY VEHICLE TOO STALL AND INCREASE A CHANCE OF ME BEING IN A ACCIDENT.

CAR HAS STEERED TO RIGHT SINCE IT WAS DELIVERED. BMW HAS CONTENDED THAT THIS WAS A SOFTWARE ISSUE FROM THE BEGINNING. AS OF 8/24/10 I HAVE BEEN TOLD THAT THE SOFTWARE FIX WAS DELIVERED TO BMW NA BUT THE FIX DOES NOT CORRECT THE PROBLEM. SO THE CAR STILL PULLS STRONGLY TO THE RIGHT, IS UNSAFE TO DRIVE AND SHOULD BE RECALLED BY BMW! *TR

I HAD THE CAR SERVICED BY A MECHANIC BECAUSE I HAD CHECK ENGINE LIGHT FAULTS. WATER PUMP AND THERMOSTAT WAS REPLACED. SPARK PLUGS AND COPS WERE REPLACED. SOME OF THE FUEL INJECTORS WERE ALSO REPLACED. MECHANIC ASKED ME TO DRIVE THE CAR FOR 100 MILES TO SEE IF ANY CHECK ENGINE ISSUES WILL REAPPEAR. THE VEHICLE FIRST BEGAN STATING IT HAD LOW OIL PRESSURE AND WOULD NOT ALLOW ME TO CHECK THE OIL LEVEL, IT WOULD CONTINUE TO JUST STOP AT 15%. I THEN RESTARTED THE VEHICLE AND THE INDICATOR WENT AWAY FOR THE LOW OIL PRESSURE. I DROVE ABOUT 10 MORE MILES AND DRIVE TRAIN MALFUNCTION APPEARED AND I PULLED OVER IMMEDIATELY. THE VEHICLE WAS TOWED TO THE MECHANIC. ENGINE WAS SEIZED. WHAT WAS FOUND IN THE ENGINE WAS "SHARDS OF METAL". MANY PEOPLE HAD THE SAME ISSUE WITH THE 5 SERIES BMW ENGINES. I THINK THAT BMW IS RESPONSIBLE FOR THESE ENGINE FAILURES. *TR

ALL THE BMW HAVE RECALL ABOUT AIRBAG AND SEAT BELT ,WHY MY 535I BMW 2010 ITS NOT UNDER RECALL,.I HAVE MY LIGHT ON AND I'M SCARED DRIVING IT LOOKS LIKE I'M NOT SAFE,I WAS DRIVING TH CAR IN CITY AND I STOPPED TO DROP OFF MY WIFE SHE TAKE OUT SEAT BELT AND SHE STAND THE LIGHT COMING ON ,IT SAID RESTRAINED SYSTEM MUNFLUCTION .

TL*THE CONTACT OWNS A 2011 BMW 535I (NA) EQUIPPED WITH GOOD YEAR EAGLE LS-2 TIRES, TIRE SIZE 245/45/18. THE CONTACT NOTICED A BUBBLE ON THE SIDE WALL OF THE FRONT PASSENGER'S SIDE TIRE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 7,800. THE DOT NUMBER WAS UNKNOWN.