2001 BMW 540 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 BMW 540, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags240.0%
- Driver assistance120.0%
- Engine120.0%
- Steering120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
DEALERSHIP IN CONCORD CALIFORNIA HAS BEEN TRYING TO DELAY REPAIRING MY VEHICLE AIRBAG EVEN AFTER APPOINTMENT. DID NOT EVEN START FIXING MY VEHICLE AFTER WAITING 5 PLUS HOURS.
DT*: THE CONTACT STATED WHILE DRIVING A ROUND ROCK OF 4-5 INCHES IN DIAMETER WAS DROVE OVER AND STRUCK THE FRONT AIR DAM RIGHT OF THE CENTER. AS A RESULT, THE DRIVER SIDE CURTAIN AIR BAG AND THE DRIVER SIDE HEAD PROTECTION AIR BAG DEPLOYED. THE MANUFACTURER WAS ALERTED AND THE CONTACT IS WAITING FOR A RETURN PHONE CALL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
ACCELERATOR PEDAL STCKS WHEN FOOT PRESSURE IS RELEASED. RESPONSE OF ACCELERATOR IS VERY QUICK. DEALER WAS NOTIFIED. *AK GAS PEDAL STUTTERING/ BINDING CONDITION IS WORSE WHEN VEHICLE IS OUT IN SUN FOR A FEW HOURS. DEALER REPLACED PEDAL THREE TIMES. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
RADIATOR FAILED AT 40K MILES IN MIDDLE OF RUSH HOUR TRAFFIC,OBSCURING VISION WHILE DRIVING BETWEEN MANY CARS AND THEN STRANDING CAR FAT DANGEROUS INTERCHANGE. *NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
I WAS DRIVING ALONG AND I HEARD A "PANG" SOUND FOLLOWED BY A LOSS OF POWER STEERING, A MOMENT LATER MY BATTERY LIGHT CAME ON. I WAS ABLE TO GET THE CAR TO A SAFE STOPPING PLACE TO BE TOWED BEFORE THE LOST BELT THAT FOLLOWED OVERHEATED ME. PUMP SNAPPED IN AT LEAST ONE PLACE MAKING THE PULLEY CROOKED, AND SHREDDING THE BELT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .