2018 BMW 540D Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 BMW 540D, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine250.0%
- Airbags125.0%
- Fuel system125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The 540d has swirl flaps on the intake manifold to regulate air intake so it adjusts how much air the intake manifold feeds the engine. There's an actuator motor that connects to the swirl flap shaft that connects via a plastic linkage. When the linkage breaks, the flaps are no longer controlled by the actuator and stays in its semi closed state. The result is when you give it full throttle, it spews out plumes of black smoke that is thick and the equivalent to rolling coal on a deleted diesel truck. The car still runs, but this poses a danger to those behind you and not very environmentally friendly to spew out soot. BMW's solution is a $6,000 repair bill, because the entire intake manifold has to be replaced for that linkage. This will be a guaranteed fail again - considering I had a check engine light for swirl flap issues starting around 40K miles.
There is an exhaust leak which has developed in the turbo. This causes untreated fumes and soot to be emitted in the engine compartment. This untreated exhaust makes its way into the passenger cabin, putting passengers at safety risk due to untreated exhaust fumes entering the cabin. The dealership has acknowledged the issue and describes it as follows: "The soot that you have seen and the smell is coming out of the wastegate shaft which by design there is a tolerance for it to move, but due to back pressure from the soot build up before the regen has occurred there is some soot that comes out." This problem happens every time I start and drive the car. The dealership is stating that this is not covered by the factory warranty. An exhaust leak like this is a serious passenger safety issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
My passenger restraint system randomly faults. Problem with passenger seat mat. Many BMW owners have reported the issue. Should be recalled by BMW.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The 540d has swirl flaps on the intake manifold to regulate air intake so it adjusts how much air the intake manifold feeds the engine. There's an actuator motor that connects to the swirl flap shaft that connects via a plastic linkage. When the linkage breaks, the flaps are no longer controlled by the actuator and stays in its semi closed state. The result is when you give it full throttle, it spews out plumes of black smoke that is thick and the equivalent to rolling coal on a deleted diesel truck. The car still runs, but this poses a danger to those behind you and not very environmentally friendly to spew out soot. BMW's solution is a $6,000 repair bill, because the entire intake manifold has to be replaced for that linkage. This will be a guaranteed fail again - considering I had a check engine light for swirl flap issues starting around 40K miles.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .