2013 BMW 550XI Owner Complaints

I WAS DRIVING MY BMW 550 XI ON THE HIGHWAY AT 70 MPH WHEN I HAD WHAT WAS TERMED BY THE BMW SERVICE TECHNICIAN AS A "CATASTROPHIC ENGINE FAILURE". AS I WAS DRIVING DOWN THE HIGHWAY AT I SUDDENLY LOST ALL POWER TO THE DRIVE TRAIN. I IMMEDIATELY HAD TO TAKE EVASIVE ACTION TO AVOID AN ACCIDENT AS ON A BUSY HIGHWAY IN CHICAGO AND SUDDEN LOSS OF POWER IS DANGEROUS. I WAS ABLE TO GET STOPPED AT THE SIDE OF THE ROAD AND WAS UNABLE TO RESTART THE ENGINE. I THEN HAD THE VEHICLE TOWED TO BMW OF ORLAND PARK WHERE THE SERVICE TECHNICIAN DISMANTLED MY ENGINE TO DETERMINE THE CAUSE OF THE ENGINE FAILURE. THE DETERMINATION WAS MADE THAT INDEED THE ENGINE HAD A "ROD BEARING FAILURE" WHICH CAUSED THE CATASTROPHIC FAILURE. AS I UNDERSTAND ENGINES VERY WELL IT IS NOT SURPRISING THAT AN ROD BEARING COULD FAIL. WHY I AM FILING THIS COMPLAINT IS THAT THIS VEHICLE ONLY HAD 67,500 MILES ON IT AND AS I HAVE NOW DISCOVERED, MANY OTHER OWNERS OF THIS YEAR MAKE AND MODEL OF VEHICLE ARE HAVING THE SAME "CATASTROPHIC FAILURES" PUTTING THEM IN DANGEROUS SITUATIONS AS WELL. AS I CONTINUED TO INVESTIGATE THIS ISSUE I HAVE FOUND THAT BMW NA KNOWS ABOUT THIS SITUATION AND HAS TO DATE DONE NOTHING TO EITHER WARN VEHICLE OWNERS OF THIS SITUATION NOR DO ANYTHING ABOUT IT. I DO KNOW THAT MULTIPLE ROD BEARING FAILURES SUCH AS MINE CANNOT BE COINCIDENCE AND NEED TO BE INVESTIGATED AS ENGINE FAILURES AT HIGH SPEEDS ARE THE MOST DANGEROUS OF ALL FAILURES.

NHTSA ID

11144760

Incident

Aug 18, 2018

Mileage

67,500 mi

TL* THE CONTACT OWNS A 2013 BMW 550XI. WHILE THE VEHICLE WAS STATIONARY, THE FRONT PASSENGER DOOR WOULD NOT UNLOCK WHEN PROMPTED. DURING THE FIRST OCCURRENCE OF THE FAILURE, THE VEHICLE REMOTE AUTOMATICALLY UNLOCKED THE FRONT PASSENGER DOOR. THE FAILURE RECURRED AND, OVER TIME, THE REMOTE BECAME COMPLETELY INOPERABLE AND WOULD NOT UNLOCK THE FRONT PASSENGER DOOR. CONSEQUENTLY, THE FRONT PASSENGER DOOR COULD NOT BE UNLOCKED AT ALL. THE VEHICLE WAS TAKEN TO WIDE WORLD OF CARS BMW (124 NY-59, SPRING VALLEY, NEW YORK 10977, (845) 425-2600). THE VEHICLE WAS NOT DIAGNOSED, BUT THE TECHNICIAN STATED THAT IT WAS PROBABLE THAT THE ACTUATOR MAY BE FAULTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11129374

Incident

Aug 30, 2018

TL* THE CONTACT OWNS A 2013 BMW 550XI. WHILE DRIVING AT ANY SPEED, THE VEHICLE EMITTED SMOKE FROM THE EXHAUST PIPE WITHOUT WARNING. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE BMW OF ROANOKE DEALER (2824 FRANKLIN RD SW, ROANOKE, VA 24014, 540-274-2475) WHERE IT WAS DIAGNOSED THAT THE VALVE STEM SEAL IN THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN ALSO STATED THAT THE OCCURRENCE WAS A KNOWN FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE WARRANTY WAS EXPIRED. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. THE VIN WAS NOT PROVIDED.

NHTSA ID

11113868

Incident

Jun 15, 2018

Mileage

115,000 mi

I WOULD BE DRIVING THE VEHICLE AND AT A RANDOM TIME IT WOULD JERK VIOLENTLY AND THEN SLOW WHILE IN TRAFFIC ON THE FREEWAY. THE CAR WOULD GO INTO 'LIMP MODE" AND GIVE A 'DRIVETRAIN MALFUNCTION' ERROR. I RESEARCHED THIS ERROR ONLINE AND IT SEEMED IT COULD BE ANY NUMBER OF THINGS. THE FIRST COUPLE TIMES IT HAPPENED IT WENT AWAY UPON THE CAR BEING OFF. IT HAPPENED A COUPLE MORE TIMES BEFORE THE 'CHECK ENGINE' LIGHT CAME ON WITH THE 'DRIVETRAIN MALFUNCTION' ERROR ON THE CAR'S INFO CENTER. EACH TIME IT INVOLVED A VIOLENT JERKING OF THE CAR AND IMMEDIATE SLOWING DOWN OF THE CAR IN TRAFFIC. I DROVE IT TO NELSON'S AUTOMOTIVE CENTER IN PEWAUKEE, WI AFTER A FEW TIMES OF THIS HAPPENING. THEY DIAGNOSED THIS AS A FUEL PUMP FAILURE AND REPLACED THE FUEL PUMP. BASED ON MY RESEARCH THIS HAS BEEN AN ONGOING ISSUE FOR BMW FOR YEARS. FUEL PUMPS HAVE BEEN RECALLED ON THESE CARS UP TO THE YEAR OF MY CAR WHICH IS DISAPPOINTING.

NHTSA ID

11074691

Incident

Jan 31, 2018

Mileage

76,050 mi

HIGH PRESSURE FUEL PUMP THE CAR STARTED SHAKING WHILE DRIVING LOST POWER CAR WENT INTO LIMP MODE AND KEPT SHAKING. THE CAR WOULD NOT EXCEED 10 MPH AND CREATED A SAFETY ISSUE

NHTSA ID

11024092

Incident

Sep 2, 2017

Mileage

64,000 mi

SUNROOF EXPLODED. SHATTERED WITH GLASS PIECES EVERYWHERE. NO STONE OR EXTERNAL OBJECT HIT THE SUNROOF.

NHTSA ID

11015770

Incident

Aug 11, 2017

Mileage

35,000 mi

BMW 550 XI WAS TRAVELING ON PA TURNPIKE WHEN THE SUNROOF EXPLODED INTO TINY SHARDS OF GLASS. THE CAR WAS GOING THE SPEED LIMIT, OUTSIDE TEMP WAS 24 DEGREES, THE SHADE WAS OPEN WHEN THE SUNROOF EXPLODED. THERE WERE NO ROCKS OR DEBRIS THAT HIT THE SUNROOF. THERE WERE NO CARS IN FRONT OF ME. I WAS NOT TRAVELING UNDER AN OVERPASS.

NHTSA ID

10940013

Incident

Jan 5, 2017

Mileage

30,000 mi