2018 BMW 640I Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 BMW 640I, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance228.6%
- Body & structure114.3%
- Electrical114.3%
- Engine114.3%
- Powertrain (other)114.3%
- Suspension114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THE CAR ON MY RIGHT CHANGED LANES AND AND HIT THE FRONT OF MY CAR. PHOTO'S OF DAMAGE ATTACHED. THE DAMAGE WAS TO THE RIGHT SIDE OF THE BUMPER AND PANEL ON THE FRONT SIDE. POLICE REPORT ATTACHED. THE CARFAX REPORT PRINTED 5/5/2021 SHOWS DAMAGED AREAS AS FRONT, RIGHT AND REAR. THE DAMAGE WAS LIMITED TO THE SIDE FRONT ONLY AND THE CAR WAS DRIVABLE TO THE REPAIR SHOP. THE ACCIDENT OCCURRED 12/21/2018.
TL* THE CONTACT OWNS A 2018 BMW 640I. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS WITH THE ADAPTIVE CRUISE CONTROL ENGAGED, THE VEHICLE FAILED TO STOP WITHOUT WARNING. THE VEHICLE WAS TAKEN TO BMW OF ANNAPOLIS (31 OLD MILL BOTTOM RD, ANNAPOLIS, MD 21401, (410) 349-9312) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 25,551.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE CAR ON MY RIGHT CHANGED LANES AND AND HIT THE FRONT OF MY CAR. PHOTO'S OF DAMAGE ATTACHED. THE DAMAGE WAS TO THE RIGHT SIDE OF THE BUMPER AND PANEL ON THE FRONT SIDE. POLICE REPORT ATTACHED. THE CARFAX REPORT PRINTED 5/5/2021 SHOWS DAMAGED AREAS AS FRONT, RIGHT AND REAR. THE DAMAGE WAS LIMITED TO THE SIDE FRONT ONLY AND THE CAR WAS DRIVABLE TO THE REPAIR SHOP. THE ACCIDENT OCCURRED 12/21/2018.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 BMW 640I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO BMW OF SILVER SPRING (3211 AUTOMOTIVE BOULEVARD, SILVER SPRING, MD 20904, (888) 295-2096, WHERE THE TECHNICIAN DIAGNOSED AND DETERMINED THAT THE FUEL SYSTEM WAS DEFECTIVE. THE FUEL SENSOR WAS REPLACED HOWEVER, THE FAILURE RECURRED. THERE WAS NO LEAKS PRESENT. THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE RADIATOR SHROUD WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 BMW 640I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO BMW OF SILVER SPRING (3211 AUTOMOTIVE BOULEVARD, SILVER SPRING, MD 20904, (888) 295-2096, WHERE THE TECHNICIAN DIAGNOSED AND DETERMINED THAT THE FUEL SYSTEM WAS DEFECTIVE. THE FUEL SENSOR WAS REPLACED HOWEVER, THE FAILURE RECURRED. THERE WAS NO LEAKS PRESENT. THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE RADIATOR SHROUD WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
I took my vehicle for a regular oil change and vehicle check at 22000 miles. The service advisor performed a routine check and found that the driveshaft flex disc had multiple cracks. If the cracks expand, it could lead to a complete failure of the disc at which point the driveshaft was come loose and can cause an accident along with extensive underbody damage. I do not understand how a certified preowned vehicle with only 22000 miles can have such a major part defect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
I took the car in for a service and mentioned that there is a slight vibration at highway speeds. The dealer performed wheel balancing and found that the issue was still there. Following this, a software update was performed and the issue was still prevalent. The final cause was identified to be the control arm bushings. The problem I see is that a number of bushings/rubber parts are failing in the vehicle and I am being asked to pay out of pocket for what I believe is a defective part/vehicle. In the first instance, the guibo/ flex disk had cracked which was replaced. These are parts that should not fail until about 80k miles while my vehicle only has 28k miles and is barely out of new car warranty.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .