2004 BMW 745LI Owner Complaints

The contact owns a 2004 BMW 745LI. The contact stated that while driving at an undisclosed speed, the passenger's side air bag warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the failure was related to NHTSA Campaign Number: 04V379000 (Seats) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the VIN. The failure mileage was approximately 198,000.

NHTSA ID

11522043

Incident

May 1, 2023

Mileage

198,000 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. WHILE DRIVING UNKNOWN SPEEDS, THE VEHICLE HESITATED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT OIL WAS LEAKING ONTO THE MANIFOLD. ALSO, THE WHEELS AND AXLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO BMW OF STRATHAM (71 PORTSMOUTH AVENUE, STRATHAM, NH 03885, (603) 772-0000), BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALER REFUSED TO WORK ON THE VEHICLE AND ADVISED THE CONTACT TO PURCHASE AN AFTERMARKET WARRANTY. THE CONTACT DECLINED THE RECOMMENDATION. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID

11098844

Incident

Feb 2, 2018

Mileage

160,000 mi

ENGINE VALVE GUIDE SEALS MADE OF IMPROPER MATERIAL THAT FAILS CAUSING OIL LEAKAGE INTO EXHAUST, FOULING OF CATALYTIC CONVERTER, FAILURE TO PASS INSPECTION AND POLLUTION. THE VALVE GUIDE SEALS ARE NOT COMPATIBLE WITH HIGH ENGINE TEMPERATURES WHICH CAUSES THE SEALS TO FAIL AT 80,000 TO 120,000 MILES. MY SEALS FAILED AT APPROXIMATELY 95,000 MILES CAUSING OIL CONSUMPTION IN EXCESS OF 1 QUART PER THOUSAND MILES. REPLACEMENT OF THE VALVE SEALS REQUIRES EXTENSIVE ENGINE READ DOWN AND COSTS APPROXIMATELY $9,000 TO REPAIR.

NHTSA ID

10871765

Incident

Jul 20, 2015

Mileage

95,000 mi

COOLANT TRANSFER PIPE SEAL IS MADE OF IMPROPER MATERIAL THAT IS NOT COMPATBLE WITH HIGH ENGINE TEMPERATURES. SEAL FAILS CAUSING LOSS OF ENGINE COOLANT. SEAL FAILS AT 40,000 TO 110,000 MILES. REPAIR IS APPROXIMATELY $6,000 BECAUSE ENGINE MUST BE TAKEN APART TO REPLACE THE SEAL. MY SEAL FAILED AT 104,000 MILES. LOSS OF POWER STEERING AND VEHICLE STABILITY CONTROL DUE TO COOLANT LEAK ONTO SERPENTINE BELT.

NHTSA ID

10871762

Incident

May 22, 2016

Mileage

104,000 mi

CAR WAS STATIONARY ON THE SIDE OF THE STREET. I SIMPLY GOT OUT OF MY VEHICLE AND THE NEXT THING I KNOW, IT STARTED ROLLING DOWN THE HILLON ITS OWN. VEHICLE HIT ANOTHER VEHICLE AND THEN HIT A NEARBY WALL. TOTAL LOSS.

NHTSA ID

10861418

Incident

Feb 15, 2016

Mileage

121,000 mi

THE VEHICLE AIR BAG SYSTEM DOES NOT WORK DUE TO A DEFECTIVE PASSENGER SEAT OCCUPANCY SENSOR. IT IS A DOCUMENTED ISSUE WITH BMW AND THEY ARE DENYING COVERAGE FOR MY PARTICULAR VIN

NHTSA ID

10747805

Incident

Aug 29, 2013

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE DRIVER SIDE SEAT MAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10669184

Incident

Nov 11, 2014

Mileage

90,000 mi

TL* THE CONTACT OWNS A BMW 745 LI. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE AIR BAG WARNING LIGHT NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10643555

Incident

Oct 1, 2013

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THERE HAD BEEN AN EXTENSIVE OIL LEAK FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES BUT THE FAILURE WAS NOT ABLE TO BE DUPLICATED OR DIAGNOSED. THE CONTACT ALSO DESCRIBED A BURNING METAL AND OIL ODOR IN ADDITION TO A WHILE CLOUD OF SMOKE. THE ALTERNATOR AND BATTERY WERE REPAIRED TWICE BY AN INDEPENDENT MECHANIC HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS THEN TAKEN TO A DIFFERENT REPAIR FACILITY WHERE THE CONTACT WAS ADVISED THAT THE ALTERNATOR, ALTERNATOR SEAL GASKET, VALVE AND SEALS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MULTIPLE TIMES. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. ..UPDATED 05/20/14 *BF UPDATED 06/02/2014 *JS

NHTSA ID

10583375

Incident

Mar 1, 2012

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED. THE CONTACT MENTIONED THAT THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE RESTARTED ON THE FIRST ATTEMPT AND RESUMED NORMALLY. THE FAILURE RECURRED ON SEVEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 73,245. UPDATED 5/8/14*CN THE CONSUMER STATED THE ENGINE KEPT RUNNING AND DID NOT DIE.

NHTSA ID

10578275

Incident

Dec 16, 2010

Mileage

73,245 mi

THE WARNING LIGHT FOR THE SEAT BELT AND AIRBAG CAME ON AND THE TENSION IN THE SEAT BELT IS NON-EXISTENT. *TR

NHTSA ID

10549449

Incident

Oct 21, 2013

Mileage

55,147 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT WHILE DRIVING 30 MPH AND ATTEMPTING TO MERGE ONTO THE HIGHWAY, THE TRANSMISSION SAFE MODE ACTIVATED AS THE VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT ALSO MENTIONED THAT THE DYNAMIC DRIVE WARNING LIGHT ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE HOWEVER, THE CONTACT STATED THAT THE TRANSMISSION CONTROL MODULE COULD POSSIBLY BECOME DEFECTIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE BECAUSE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 120,000. *TR

NHTSA ID

10502105

Incident

Oct 6, 2010

Mileage

94,000 mi

ON THE DASH BOARD THE LOUD WARNING LIGHT COMES ON: DRIVER RESTRAINT SYSTEM FAULT AND PASSENGER RESTRAINT SYSTEM FAULT. I KNOW THAT SEVERAL 2002-2008 BMW 7-SERIES GOT RECALLED REGARDING THE SAME ISSUE AND MANUFACTURE OFFERED 10 YEAR WARRANTY FROM IN SERVICE DATE REGARDING THIS ISSUE. MINE IS A 2004 745LI AND SHOULD BE ONE OF THE RECALLED ONE. CALLED THE MANUFACTURE AND THEY SAD THE VIN NUMBER THAT MY CAR HAS NEVER HAVE BEEN RECALLED WITH THIS PROBLEM. THE PROBLEM IS ON AND I THINK THE MANUFACTURE SHOULD TAKE CARE OF IT. IS A SHAME TO SPEND SO MUCH MONEY FOR THIS VEHICLES AND THEY CAN'T OFFER A SAFE DRIVE. THANKS *TR

NHTSA ID

10499391

Incident

Feb 19, 2013

Mileage

76,000 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THERE WAS AN OIL LEAK FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE HOSE TO THE ENGINE WAS FRACTURED, CAUSING THE OIL LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10491870

Incident

Dec 18, 2012

Mileage

90,000 mi

SENSOR MALFUNCTION CAUSES TRANSMISSION TO SHIFT INTO ALTERNATE GEARS WHILE CAR IS IN MOTION. WHILE IN DRIVE CAR WOULD SHIFT INTO REVERSE OR NEUTRAL BY ITSELF WITH NO OPERATOR CONTROL. *TR

NHTSA ID

10474366

Incident

Jun 1, 2012

Mileage

180,000 mi

WE WERE DRIVING AND ALL OF A SUDDEN THE PASSENGER RESTRAINT SYSTEM LIGHTS AND MESSAGE CAME ON. I HAD THE CAR DIAGNOSED BY MY LOCAL BMW DEALER WHO PIN POINTED THE PROBLEM TO THE STEERING ANGLE SENSOR. I AM NOT SURE HOW THIS HAS ANYTHING TO DO WITH THE STEERING COLUMN. THE FAULT IS CURRENTLY COVERED UNDER A TEN WARRANTY AND I AM NOT SURE WHY THE BMW DEALER WOULD TELL ME THE PROBLEM WAS ELSE WHERE WITH A PRICE TAG OF A 1K PROBLEM. I NEED TO KNOW FROM BMW NORTH AMERICA HOW IS THE PASSENGER RESTRAINT SYSTEM TIED TO THE STEERING ANGLE SENSOR. I WAS TOLD EVERYTHING RUNS THROUGH THIS SENSOR. *TT

NHTSA ID

10459306

Incident

May 19, 2012

Mileage

160,507 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE STALLED. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE WITH MUCH HESITATION FROM THE ENGINE. THE POWER STEERING LIGHT THEN ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. IN ADDITION, THE BRAKE POWER ASSIST WARNING SIGNAL ALSO ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT REFERENCED TWO RECALLS UNDER NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM) AND 04V344000 (POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN EITHER RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

NHTSA ID

10457690

Incident

Mar 12, 2012

Mileage

105,000 mi

TL* THE CONTACT OWNS A 2004 BMW 745 LI. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE DECREASED SPEED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 129,860.

NHTSA ID

10453438

Incident

Mar 29, 2012

Mileage

129,860 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE STALLED. ON A SEPARATE OCCASION, THE VEHICLE WAS PARKED, BUT BEGAN TO ROLL BACKWARD OUT OF A GARAGE. THE CONTACT STOPPED THE VEHICLE BY ENGAGING THE EMERGENCY BRAKE AND ALL OF THE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 80,071.

NHTSA ID

10427928

Incident

Jul 1, 2011

Mileage

80,071 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THE POWER STEERING AND BRAKES FAILED REPEATEDLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE FAILURE REPAIRED TWICE BEFORE LOCATING NHTSA CAMPAIGN ID NUMBER:04V344000 (POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE -TCM, PCM). THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL EVEN THOUGH THE FAILURE WAS IDENTICAL. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10425168

Incident

Sep 5, 2011

TL* THE CONTACT OWNS A 2004 BMW 745LI . THE CONTACT STATED WHILE DRIVING 75 MPH THE ABS LAMP ILLUMINATED, THE VEHICLE STARTED JERKING VIOLENTLY AND THE BRAKES AND THE STEERING WHEEL LOCKED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE STALLED. IN ADDITION, AFTER THE DRIVER WAS ABLE TO TURN THE VEHICLE BACK ON THE TRANSMISSION SAFE MODE WOULD NOT DISENGAGE. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE ALTERNATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THREE YEARS AGO, THE FAILURE OCCURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE IS 86,000. UPDATED 9/13/11 *CN UPDATED 09/28/11

NHTSA ID

10419562

Incident

Dec 1, 2008

Mileage

30,000 mi

TL*THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THE BRAKE PEDAL WAS SOFT AND EXTENDED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WOULD NOT STOP IMMEDIATELY WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE VEHICLE WAS FUNCTIONING NORMALLY. THE DEALER ALSO STATED THAT THE VEHICLE HAD PREVIOUSLY BEEN REPAIRED ACCORDING TO RECALL 10V446000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM). THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 103,000. THE FAILURE MILEAGE WAS APPROXIMATELY 99,000.

NHTSA ID

10398900

Incident

Mar 19, 2011

Mileage

99,000 mi

I PURCHASED A 2004 BMW 745 LI FROM LEXUS DEALERSHIP IN MD, I DROVE TO FAYETTEVILLE, NC BECAUSE IM IN THE MILITARY. 1 WEEK AFTER BEING HOME AT FT BRAGG I STARTED THE CAR IN THE MORNING AND THEN THE TRANSFAIL SAFE LIGHT CAME ON WHEN I ARRIVED AT WORK. 4/12/2011 WHILE DRIVING TO WORK IN FULL HEAVY TRAFFIC THE COOLANT LIGHT CAME ON WITH A YELLOW INDICATOR AND TOLD ME TO DRIVE MODERATELY. WHILE TRYING TO DRIVE TO A GAS STATION THE RED INDICATOR CAME ON AND TOLD ME TO STOP SAFELY AND THIS IS WHILE IN TRAFFIC. THIS COMPUTER IS ALWAYS SAYING SOMETHINGS WRONG WHEN ITS NOT AND IM AFRAID THAT WHEN SOMETHING IS REALLY WRONG I WONT KNOW IF IT IS LEGITIMATE. I CHECKED THE COOLANT LEVEL AND IT WAS FULL. OIL WAS A LITTLE LOW BUT NO INDICATOR CAME ON FOR THAT. STARTED THE CAR BACK UP AND IT DROVE FINE. THERE NEEDS TO BE A RECALL ON THESE COMPUTERS IN BMW CARS. THESE COMPUTER PROBLEM CAN BE A PLOY TO CONSTANTLY PURGE MONIES FROM CONSUMERS POCKET PLEASE HELP. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10395588

Incident

Apr 12, 2011

Mileage

109,115 mi

TL* THE CONTACT OWNS A 2004 BMW 745LI. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM) AND BEGIN TO LEAK OIL ABNORMALLY TWO MONTHS AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THEY PERFORMED A DIAGNOSTIC AND DETERMINED THAT THE OIL LEAK WAS COMING FROM THE VACUUM PUMP. THE CONTACT SECURED AN APPOINTMENT WITH THE DEALER AND WAS AWAITING POSSIBLE REPAIRS. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 100,130. UPDATED 06/01/11*LJ UPDATED 06/02/11

NHTSA ID

10395431

Incident

Mar 1, 2011

Mileage

96,000 mi

VEHICLE TYPE IS A 2004 745LI BMW V-8 6 SPEED TRANSMISSION. WHEN THE CAR IS IN 5TH GEAR THE CAR HICCUPS LIKE IT WANTS TO UP SHIFT BUT THEN DOES NOT. IT CAUSE THE CAR IT JERK EVERY 3 TO 5 SECONDS WHEN IN 5TH GEAR. WHEN THE CAR IS IN ANY OTHER GEAR IN DOES NOT DO THIS. I HAVE HAD A TRANSMISSION FLUID COMPLETELY CHANGED OUT. IN WHICH THE FLUID SMELLED BURNT AND LOOKED BROWN IN COLOR. BMW SAYS THAT IT IS A LIFE TIME FLUID (IT IS NOT). WHEN THE CAR IS ACCELERATING THROUGH 5TH GEAR IT DOES NOT DO THE PROBLEM EITHER. THERE IS SOMETHING CLEARLY WRONG WHICH THE TRANSMISSION. I HAVE TAKING THE CAR TO TWO INDEPENDENT TRANSMISSION SHOPS AND THEY HAVE NO IDEA. I HAVE LEARNED THAT THE CAR WILL STAY IN 6TH GEAR AT 45 MPH AND NORMALLY CRUISE IN THE CITY IN 4TH GEAR AT LOWER SPEEDS AND AVOID 5TH GEAR WITH THE USE OF THE MANUAL SHIFTS ON THE STEERING WHEEL. ALSO, THE DYNAMIC DRIVE SYSTEM FAILS ABOUT ONCE A MONTH IN WHICH YOU CAN TURN THE CAR OFF AND ON AGAIN AND THE CAR DYNAMIC DRIVE SYSTEM WORKS FINE FOR A MONTH OR SO. THIS CAUSES THE CAR CHASSIS TO ROLL WHEN CORNERING. DURING THIS TIME OF FAILURE THE STEREO MAKES ODD NOISES IN WHICH I THINK IT IS BECAUSE THE STEREO VOLUME IS SET TO GET LOUDER AS THE CAR SPEED INCREASES. THESE ISSUES ALL TEND TO HAPPEN AT THE SAME TIME. *TR

NHTSA ID

10394263

Incident

Jan 1, 2010

Mileage

65,000 mi