2014 BMW I3 Engine Problems

The contact owns a 2014 BMW I3. The contact stated that while driving at 49 MPH, the vehicle made an abnormal screeching sound and was leaning on the driver's side rear-end. The vehicle was taken to an independent mechanic, where a rear-end inspection was performed, and the contact was informed that no failure was found. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown engine mount bracket recall. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 154,140.

NHTSA ID

11728191

Incident

Mar 31, 2026

Mileage

154,140 mi

RANGE extender intermittintly doesnt start when electric is low cause dangerous loss of complete power . exacerbated by the fact that it becomes nearly impossible for two people to push in neutral on level ground .

NHTSA ID

11467637

Incident

Jun 5, 2022

I purchased my 2014 BMW i3 from Canada in 2019. It was imported from the U.S and still is registered in the U.S. I brought it into the BMW dealership in Vancouver BC shortly after to do a vehicle inspection. At that time, the dealer printed out a list of defect codes/recalls. It also said that they were done and marked "yes" completed. Fast forward to 2022, I bring my car into the same dealer and they said there is a recall not completed to replace the convenience charging electronics KLE and that they would fix for free. My car was not starting and we thought it could have caused the issue. They also noted at that time that the engine mount screws are now split and need to be replaced. I then discovered it was part of an open recall but when I asked about this, they said the recall closed in 2016 and I would now be responsible to replace this part for $3400+ even though it was a known defective BMW part. Upon further research, the initial part replaced was deemed not good enough and the part was upgraded to aluminum (it is currently a plastic mount bracket). I have tried requesting again for them to complete the recall work but they said they told me: " Yes, there was a recall but it was completed in 2016 in san fran by the looks of it. (<--I don't think it was actually completed) "I can't claim it since its done unfortunately... there is no way for me to claim this to you either as the repairs done more than 2 years ago and the car is out of warrant for 4 years. So BMW will just see it as just wear and tear. I tried to see of any ways I could assist you but there isn't a way for me to claim this with BMW" So my issue, and why I am writing you is that they claim the part has been completed but it has not, it is still the original bracket and screw mount. Plus they admitted they still needed to replace the charging electronics when this was apparently also marked as completed. I suspect someone lied about the recall work being done in San Francisco.

NHTSA ID

11464379

Incident

May 11, 2022

I've had to replace the engine motor mount bolts twice in 3 years

NHTSA ID

11425902

Incident

Jul 20, 2021

WHILE DRIVING THE VEHICLE SUDDENLY JERKED AND LOST ALL POWER WHILE IN MOTION ON A CITY STREET. I CAN'T IMAGINE WHAT WOULD HAVE HAPPENED IF I WAS ON THE FREEWAY WITH TRAFFIC. THE MESSAGE ON THE SCREEN IN MY CAR STATED DRIVETRAIN MALFUNCTION STOP AND TURN OFF ENGINE DO NOT CONTINUE TO DRIVE CALL ROADSIDE ASSISTANCE.

NHTSA ID

11350127

Incident

Aug 16, 2020

Mileage

50,000 mi

I WAS STOPPED AT A STOP SIGN AND WHEN I ACCELERATED THE REAR OF THE CAR FELT LIKE IT GOT REAR ENDED. I WALKED AROUND THE CAR, NOTHING WAS WRONG. IT DROVE FINE UP TO 40 MPH, THEN ON THE HIGHWAY, IT MADE A RRRR SOUND. THE NEXT DAY I FOUND OUT THAT THE ENGINE MOUNT BOLT SNAPPED.

NHTSA ID

11270293

Incident

Oct 17, 2019

Mileage

87,000 mi

TL* THE CONTACT OWNS A 2014 BMW I3. THE CONTACT PURCHASED THE VEHICLE USED IN JUNE OF 2019. IN EARLY AUGUST, A LOUD GRINDING NOISE WAS HEARD WHEN THE AIR CONDITIONING WAS ACTIVATED. WHILE BRAKING, THE CONTACT RELEASED THE ACCELERATOR PEDAL AND HEARD A THUMPING SOUND AND THE DRIVE TRAIN MALFUNCTION INDICATOR ILLUMINATED. THE WARNING INDICATOR INSTRUCTED THE CONTACT TO BRING THE VEHICLE TO THE DEALER FOR SERVICE. THE VEHICLE WAS TAKEN TO BMW SEATTLE (1002 AIRPORT WAY S, SEATTLE, WA 98134, (206) 829-5004) WHERE IT WAS DIAGNOSED THAT THE ENGINE MOUNT BRACKET FRACTURED. THE ENGINE FELL AND PINCHED THE HIGH VOLTAGE CABLE, WHICH CAUSED THE DRIVE TRAIN MALFUNCTION WARNING MESSAGE TO APPEAR. SINCE THE VEHICLE WAS NOT UNDER WARRANTY, IT WOULD COST OVER $5,000 TO REPAIR. THE FAILURE MILEAGE WAS 13,015.

NHTSA ID

11254803

Incident

Aug 5, 2019

Mileage

13,015 mi

WHILE DRIVING THE CAR AND AT A STOP LIGHT THE CAR MADE SOME JERKY NOISE AND GOT THE "DRIVETRAIN MALFUNCTION - STOP AND TURN OFF ENGINE. DO NOT CONTINUE DRIVING. CALL ROADSIDE ASSISTANCE" MESSAGE. THIS HAS HAPPENED ABOUT 6 MONTHS AGO AND HAD THE CAR TOWED TO THE SERVICE AND THEY NEVER FOUND ANY PROBLEM. NOW IN THE SPAN OF A DAY IT HAS HAPPENED 3 TIMES. WHEN I TURN OFF ENGINE, WAIT A MINUTE OR SO AND START AGAIN, I WAS ABLE TO DRIVE THE CAR AGAIN. I AM NOT SURE WHY THIS IS HAPPENING AND I HAVE LOOKED THROUGH ALL BMW FORUMS AND FACEBOOK PAGES AND NOBODY SEEMS TO HAVE AN ANSWER. I AM WORRIED ABOUT DRIVING THE CAR AND HAVING IT COMPLETELY HALT IN THE MIDDLE OF DRIVING ON THE FREEWAY. THIS NEEDS TO BE ADDRESSED BY BMW AND I HAVE YET TO GET AN ANSWER.

NHTSA ID

10872244

Incident

Jun 1, 2016

Mileage

15,600 mi

CHARGED MY CAR OVERNIGHT IN MY CLIMATE CONTROLLED GARAGE AND WENT OUT THE NEXT MORNING TO RUN ERRANDS. TURNED IT ON, PUT IT IN DRIVE, HEARD A POP OR CLUNK FROM THE REAR AND THEN GOT A DRIVE TRAIN NOT AVAILABLE - DO NOT MOVE VEHICLE ERROR. COULDN'T EVEN PUT THE CAR IN NEUTRAL FOR TOWING - BMW ROADSIDE HAD TO SEND A TOW TRUCK WITH SKATES TO PROP UP THE BACK END AND PUSH IT OUT OF MY GARAGE. IT'S BEEN AT THE DEALER ALMOST 2 WEEKS NOW - THE LOCAL MECHANICS HAVE HAD CALLS WITH BMW BACK IN GERMANY AND THEY CAN'T SEEM TO FIGURE OUT WHAT THE PROBLEM IS.

NHTSA ID

10820163

Incident

Jan 1, 2016

Mileage

6,500 mi

TWO ISSUES: 1. DRIVING AT HIGHWAY SPEED OF 65 MPH, WITH BATTERY POWER DRAINED, THE REX (RESERVE ENGINE) TURNS ON. SUDDENLY, SPEED DROPS FROM 65 MPH TO 40 MPH WHILE ON A 2-LANE CA FREEWAY, ALMOST CAUSING ME TO BE REAR-ENDED BY TRAFFIC. ONE MONTH LATER, SAME SITUATION, SAME PROBLEM. 2. MANUFACTURER STATES A COMBINED MILEAGE RANGE OF 80 MILES ON BATTERY, 60 MILES ON REX (RESERVE ENGINE), FOR A COMBINED RANGE OF 140 MILES. I HAVE NEVER HAD MORE THAN 60 MILES ON BATTERY AND 40 MILES ON REX FOR A COMBINED MILEAGE OF 100 MILES, 40% LESS THAN BMW STATES, EVEN THOUGH I USE A PROFESSIONALLY INSTALLED LEVEL 2 CHARGER. BROUGHT THE CAR TO THE DEALER TO CHECK THESE ISSUES. THE BMW DEALER?S WRITTEN FINDINGS: "CAR PERFORMED AS DESIGNED; VEHICLE IS EPA RATED TO GO 72 MILES PER CHARGE IN IDEAL CONDITIONS. THIS RANGE WILL VARY DRASTICALLY BASED ON VEHICLE USAGE AS WELL AS WEATHER CONDITIONS. THIS IS NORMAL OPERATION. ROAD TESTED VEHICLE AND WAS EASILY ABLE TO TRAVEL 75 MILES ON A CHARGE. RANGE EXTENDER IS INTENDED TO BE USED AS A FAILSAFE TO GET THE VEHICLE TO A CHARGING STATION AND SHOULD NOT BE CONSIDERED FOR REGULAR USE, ESPECIALLY AT FREEWAY SPEEDS, AS THE ENGINE IS NOT DESIGNED FOR THIS. POWER REDUCTION AND REDUCED VEHICLE SPEED WILL RESULT. UPDATED COMPLETE VEHICLE SOFTWARE. VEHICLE NOW HAS A BATTERY PERCENTAGE DISPLAY AVAILABLE TO HELP GAUGE WHEN POWER REDUCTION IS TAKING PLACE. THESE ARE THE ONLY MEASURES AVAILABLE TO ADDRESS CUSTOMER COMPLAINT AS THE COMPLAINT IS REGARDING A DESIGN PARAMETER OF THE VEHICLE AND NOT AN ACTUAL ISSUE.? I DISAGREE. MY SAFETY HAS BEEN COMPROMISED, AND THE CAR DOES NOT FUNCTION AS ADVERTISED. NEITHER OF THESE ISSUES IS ADDRESSED IN ANY MATERIAL FROM THE MANUFACTURER, DEALER, OTHER WEBSITES OR OTHER INDUSTRY OR WEB-BASED SOURCES. BMW NA SENT AN ENGINEER TO CHECK THE CAR, HE SAID THIS IS THE DESIGN OF THE BMW, NOTHING MORE CAN BE DONE.

NHTSA ID

10805744

Incident

Jun 17, 2015

Mileage

4,960 mi