2014 BMW I3

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Sudden unintended deceleration on highway Complete loss of propulsion Thermal warning / overheating Date: May 11, 2026 Mileage: approximately 18,966+ Vehicle: 2014 BMW i3 REx, VIN [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11737189

Incident

May 11, 2026

The contact owns a 2014 BMW I3. The contact stated that while driving at 49 MPH, the vehicle made an abnormal screeching sound and was leaning on the driver's side rear-end. The vehicle was taken to an independent mechanic, where a rear-end inspection was performed, and the contact was informed that no failure was found. The vehicle was not diagnosed or repaired. The contact related the failure to an unknown engine mount bracket recall. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 154,140.

NHTSA ID

11728191

Incident

Mar 31, 2026

Mileage

154,140 mi

BMW Service Bulletin SI B22 04 15 to replace motor mount bolts and other components due to failure in 2016 was done on my vehicle in 2016. BMW has replaced all motor mounts in 2014 and 2015 i3's in Europe. The motor mounts were redesigned for 2016 and newer models. From online forums I see that many of the 2014 and 2015 North American i3 motor mounts continue to fail as they have on my BMW i3. I am reporting this failure in order for NHTSA to review this vehicle for a recall on motor mounts for all 2014 and 2015 USA BMW i3's.

NHTSA ID

11721513

Incident

Feb 13, 2026

back in march 2025 my 2014 BMW i3 REX gave out a "Drivetrain Malfunction" error. The car's propulsion died while driving. I was driving in the street on the way home from picking up my chidren from school when the power completely shut off while driving. I had a full battery charge and also had about 44 miles worth of gas to use. I pull over to the side of the road, turn the car off and tried to turn it back on but it wouldnt move. i was about 1 mile from home and was able to get the car towed home using AAA. The error code disappeared the next day and i kept driving the car it felt as if it the problem went away. Fast forward Augist 1 2025, the car once again shut off while in the middle of the street driving. I could not get it back on and once again had to get it towed. Once home it started back up like nothing wihtin a few hours. A week later on August 8 it did it again but this time i was driving on the freeway. I was soo afraid for my life because the car started to slow down as if it was runing out of gas and barely made it to get onto the side of the road away from traffic. Once again the car got towed home i was 4 miles away from home. These occurences continue to happen more frequently now. With each time the car started the error message reappeared and the propulsion died. This is gettting out of hand and becoming dangerous for me.

NHTSA ID

11680869

Incident

Aug 8, 2025

The carbon fiber roof is delaminating and a portion of it came off and hit the front windshield of another car, causing them to partially lose control of their vehicle almost causing an accident. This is a known issue BMW has not taken an action to resolve it. I’m afraid that a larger chunk may hit somebody’s car and cause a severe accident.

NHTSA ID

11618578

Incident

Oct 6, 2024

A large portion of the car's hood (carbon laminate?) has ripped off and is surely to continue to tear and fly off while driving.

NHTSA ID

11613788

Incident

Aug 15, 2024

When the vehicle depletes it's battery and switches over to the range extender or the gas engine, the car will suddenly shut off and a drivetrain error appears. This seems to only happen when the car is traveling over 55 mph. This has happened on repeated occasions. If you then leave the car sit for several minutes and then turn it back on, it is driveable as long as it is driven under 55 mph. Since this only happens at higher speeds, it's been extremely dangerous because other cars are also traveling at high speeds and this has happened once on a freeway where the speed limit was 70 mph. If there's no shoulder to guide the car onto when this happens, the car would be disabled on the road because it will not drive again right away. I've taken it in to fix and the mechanic said it was a software update that was needed. However, the problem happened again a few months later. There was no warning before this happened both times it occurred.

NHTSA ID

11594331

Incident

Jan 13, 2024

AC Compressor for the car battery system failed. There was a check engine light that was on steady, but not flashing. The electric range in the car reduced by 20 to 30% as a result of this fault. It was brought into the BMW dealership for inspection and they determined that was a short in the AC compressor and that the whole AC compressor system would need to be replaced; compressor, lines and radiatorx2 (battery radiator also needed). This was because this typical failure causes metal filings to enter the cooling system and it's not recommended to flush it out. There were no prior warnings or noise leading up to the problem. I'm concerned that there is a high risk that further driving the vehicle or charging it could cause a battery failure and cause it to catch on fire since there is no cooling. Normally a flashing engine light means to stop driving immediately, but there was no flashing light only a steady light. The BWM system check menu reported no issue with the car! The repair bill for this is about $8,400 and is rediculous. This seems to be a common problem when you start searching for it. Seems to also happen to the BMW i8 which shares the same compressor. Note that there are several revisions to the ac compressor part number which seems to suggest that they had to keep changing the part as production went on but did not notify affected cars that they could have a serious problem. This shouldn't be happening at 77k miles.

NHTSA ID

11576295

Incident

Feb 23, 2024

The High-Voltage (HV) Battery Assembly Cell Modules Temperature Sensors (Internal NTC repair kit-specific) limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service/first delivery date.

the High-Voltage (HV) Battery Assembly Cell Modules Temperature Sensors (Internal NTC repair kit-specific) limited warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles as determined from the original in-service/first delivery date.

The Supplemental Restraint System’s (SRS) air bag warning lamp is illuminated, and the air bag control unit’s (ACSM4i) fault memory has stored one or both of the following fault codes: 930904 Airbag Driver 1st Stage: "Resistance too large” 93090A Airbag Driver 2nd Stage: “Resistance too large"

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and was introduced in 3/2014. This uses map North America EVO. The Headunit High 4 (HU-H4, also called MGU21) superseded the MGU starting with certain MY2021 vehicles with option code 6U3 Live Cockpit Professional. This uses map North America JOY. The ENTRY Media/Navigation (HU-B) is the low line business version of the navigation system and was introduced in 3/2014. This uses map North America ROUTE. The ENTRY NAV EVO (HU-B2) replaced Entry Media/Navigation as the low-line business version and was introduced in certain MY2018 vehicles. This uses map North America WAY.

For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to: 15 years/150,000 miles as determined by the vehicle's original in-service date.