RoadVitals

2005 BMW K1200 GT

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Nov 30, 2007
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Aug 10, 2020
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 2 NHTSA owner-reported complaints for the 2005 BMW K1200 GT, most frequently naming the tires & wheels and transmission categories. 3 safety recalls have been issued covering this model year; and 18 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Tires & wheels150.0%
  • Transmission150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
20V471000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Aug 10, 2020
16,926 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.
The risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.
The remedy: BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLCView on NHTSA.gov
10V488000

SUSPENSION:REAR

Oct 8, 2010
11,826 units potentially affected
The defect: BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.
The risk: THIS COULD AFFECT THE HANDLING OF THE MOTORCYCLE INCREASING THE RISK A DRIVER MAY LOSE CONTROL OF THE VEHICLE RESULTING IN A CRASH.
The remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov
07V066000

ENGINE AND ENGINE COOLING

Feb 23, 2007
6,631 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR BLEED VALVE.
The risk: IT IS POSSIBLE THAT A PRESSURE BUILD UP IN THE OIL TANK COULD CAUSE IT TO RUPTURE, ALLOWING OIL TO LEAK ONTO THE REAR TIRE. AN OIL LEAK COULD CAUSE A FIRE. OIL ON THE REAR TIRE COULD CAUSE LOSS OF CONTROL.
The remedy: DEALERS WILL INSTALL A NEW OIL TANK CAP CONTAINING A VALVE TO PREVENT OVERPRESSURE IN THE TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
BMW OF NORTH AMERICA, LLCView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Transmission
Filed Nov 30, 2007

FINAL DRIVE / CLUTCH FAILURE BIKE BROKE DOWN ON THE HIGHWAY NOTHING WAS DONE BY THE DEALER OR MANUFACTURER. *TR

NHTSA ID
10210376
Incident
Oct 15, 2007
Mileage
8,500 mi
Tires & wheels
Filed Jun 26, 2007

HAD 3 BRIDGESTONE BATTLEAX BT TIRES SEPARATE ON THE '05 BMW K1200LT MOTORCYCLE. ALL HAD ABOUT 4500 MILES ON THEM. TIRES WERE PROPERLY INFLATED AT ALL TIMES ON MANUFACTURER'S SUGGESTED PRESSURE LISTED ON SIDEWALLS. INSIDE OF TIRES SHOWED SEPARATION THE SIZE OF MY WRISTS AND ABOUT 12-14" IN LENGTH.*AK ALL FAILURES OCCURRED WITHIN 6 MONTHS OF TIRE INSTALLATION. LAST SET OF TIRES IS AVAILABLE FOR INSPECTIONS. TIRE COMPANY WHERE I BOUGHT REPLACEMENTS FOR THEM ON TRIP IN COLORADO WILL HOLD THEM FOR A FEW WEEKS. SERIAL NUMBERS OF LAST TWO TIRES: DED3405 AND PAA1102

NHTSA ID
10194224
Incident
Jun 21, 2007
Mileage
37,037 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B611305

ELECTRICAL SYSTEM

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

MC160214

FUEL SYSTEM, GASOLINE

BMW Motorrad USA has become aware of a potential durability issue with the film type fuel level sender “Fuel Strip” equipped on certain model year 2005 to 2013 R and K series motorcycles.

MC610107

ENGINE AND ENGINE COOLING

There is a possibility of the "EWS" (electronic immobilizer) error message being displayed in the instrument cluster of the K 1200 GT (K44). If this occurs the engine will not start.

MC460807

EQUIPMENT; STRUCTURE

Manufacturing tolerances between the center stand and the main frame can result in excessive endplay of the center-stand pivot mount.

MC650109

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

IT is no longer necessary to place a PMP coded part order to obtain a Repair Enabling code

B611305

ELECTRICAL SYSTEM; EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY

Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root cause of the discharged battery cannot be identified. This increases the chances of a repeat repair.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW K1200 GT by model year
YearComplaintsRecallsInvestigationsIssue Index
2010000—
2009000—
2008347149.7
2007287146.3
2006115144.6
2005Viewing230—
2004600—
2003200—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.