2009 BMW M3 Problems

TO WHOM IT MAY CONCERN, I AM VERY HAPPY TO SEE YOUR ORGANIZATION TAKING AN INTEREST IN THIS ISSUE. IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. THIS SITUATION IS MOST PRONOUNCED IN THE "AUTO" MODE OF THE DCT TRANSMISSION, BUT ALSO OCCURS TO A LESSER DEGREE WHILE IN THE MANUAL MODE WHEN YOU SELECT SECOND GEAR IN PREPARATION FOR THE TURN. IT IS ALSO VERY REPEATABLE IN BOTH MODES. THESE PROBLEMS STARTED OCCURRING AFTER A PREVIOUS RECALL ON THIS TRANSMISSION WHERE THE ENGINE WOULD STALL UNDER HARD BRAKING OR NOT SHIFT UNDER HARD BRAKING. THE RECALL FIXED THAT PROBLEM, BUT INTRODUCED THIS PROBLEM, WHICH OCCURS ALMOST EVERY DAY WHEREAS THE PREVIOUS PROBLEM ONLY OCCURRED DURING A SPECIFIC SITUATION. THANK YOU FOR LOOKING INTO THIS DANGEROUS MATTER. *TR

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) DEAR [XXX], I AM VERY HAPPY TO SEE YOUR ORANIZATION TAKING AN INTEREST IN THIS ISSUE. IT IS A VERY DANGEROUS PROBLEM WITH THIS VEHICLE THAT BMWNA IS WELL AWARE OF, BUT INSISTS THAT IT IS "NORMAL BEHAVIOR" FOR MY CAR/TRANSMISSION. I BROUGHT THE CAR INTO THE DEALER, AND THEY WERE ABLE TO REPRODUCE IT, BUT THEY WERE TOLD BY BMW THAT THIS WAS "NORMAL BEHAVIOR." THE PROBLEM OCCURS WHEN YOU SLOW DOWN- LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE TROUBLE FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE ONSET OF POWER- UP TO 2-3 SECONDS. BY THIS TIME, THE DRIVER IS USUALLY REALLY DIGGING INTO THE THROTTLE. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES INVOKING THE ANTI-SKIP CONTROL. THE DANGER IN THIS BEHAVIOR OCCURS WHEN MAKING A TURN INTO ON-COMING TRAFFIC AFTER SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT YOU HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. THIS SITUATION IS MOST PRONOUNCED IN THE "AUTO" MODE OF THE DCT TRANSMISSION, BUT ALSO OCCURS TO A LESSER DEGREE WHILE IN THE MANUAL MODE WHEN YOU SELECT SECOND GEAR IN PREPARATION FOR THE TURN. IT IS ALSO VERY REPEATABLE IN BOTH MODES. THESE PROBLEMS STARTED OCCURING AFTER A PREVIOUS RECALL ON THIS TRANSMISSION WHERE THE ENGINE WOULD STALL UNDER HARD BRAKING OR NOT SHIFT UNDER HARD BRAKING. THE RECALL FIXED THAT PROBLEM, BUT INTRODUCED THIS PROBLEM, WHICH OCCURS ALMOST EVERY DAY WHEREAS THE PREVIOUS PROBLEM ONLY OCCURED DURING A SPECIFIC SITUATION. THANK YOU FOR LOOKING INTO THIS DANGEROUS MATTER. *TR

I RECEIVED A RECALL FOR THE AIRBAG ON MY CAR. I CONTACTED BMW TO REPLACE BUT THEY WERE UNABLE TO REPLACE AT THAT TIME. I HAVE TRIED TO CONTACT THEM SINCE TO ARRANGE REPLACEMENT AND THEY HAVE NOT RETURNED MY CALLS.

TAKATA RECALL - I HAVE BEEN WAITING 2 YEARS TO HAVE THIS RECALL DONE. I WAS ONCE SCHEDULED TO GET THE SERVICE AND THEN AFTER I DROPPED OFF THE CAR THEY CALLED ME BACK AND STATED THAT THEY DIDNT HAVE THE PART IN.

The contact owns a 2009 BMW M3. The contact stated while operating the vehicle, the driver’s and passenger’s side turn signal failed to illuminate. Additionally, the headlights and dashboard lights would flicker on and off. Upon inspection, it was discovered that the electrical wiring insulation was frayed and damaged. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was approximately 84,000.

VEHICLE WOULD NOT START AND ALL ELECTRICAL SYSTEMS WERE DEAD DESPITE A GOOD BATTERY. WAS SOLVED BY REMOVING GLOVE BOX AND FUS BOX AND PUSHING ON THE BATTERY CABLE THAT GOES INTO THE FUSE BOX TO GET A CONNECTION. THIS IS A KNOW ISSUE FOR BMW AND A RECALL WAS ISSUED ON OTHER 3-SERIES VEHICLES (2007 - 2011) WITH THE SAME PART NUMBERS, BUT WILL NOT COVER M3. THIS IS A SAFETY ISSUE AS LOSS OF POWER TO FUSE BOX WHILE DRIVING CAN SHUT DOWN THE CAR.

TAKATA RECALL DRIVING MY CAR FOR ABOUT 30 MINUTES ON THE LOCAL STREET AND STOPPED AT A RED LIGHT, LIGHT TURNS GREEN, I TRY TO ACCELERATE AND ENGINE FELT SLUGGISH AND SHUTS OFF. TOWED THE CAR TO MRF ENGINEERING AND CAR NEEDED AN "ENGINE REPLACEMENT" AS MY ROD BEARINGS CAUSED THE ENGINE TO FAIL. COSTED ROUGHLY AROUND $19,000 IN PARTS AND LABOR.

THE CAR SUDDENLY VIBRATED AND THE WHEELS LOCKED UP AND SKIDDED SLIGHTLY SIDEWAYS BEFORE GOING INTO A REDUCED POWER MODE. IF IT HAD BEEN RAINING OR SNOWING, OR AT A HIGHER SPEED ON HIGHWAY THE SITUATION COULD HAVE BEEN DEADLY. I HAD THE CAR TAKEN TO THE DEALER. I WAS TOLD A THE THROTTLE ACTUATOR VALVE WAS DEFECTIVE. THE CAR HAS ONLY 44K MILES BUT HAS SURPASSED THE 4 YEARS OF WARRANTY. THIS IS A KNOWN ISSUE WITH THOUSANDS OF CARS AFFECTED. BMW REFUSES TO RECALL AND REPAIR THE ITEM IF THE CAR IS NOT UNDER WARRANTY. THE COST FOR REPAIR IS $3000.00 THE PART ALONE IS $1200.00 WHICH I WAS QUOTED. MY VEHICLE IS ALSO AFFECTED BY THE TAKATA AIRBAG RECALL.

THE CAR SUDDENLY VIBRATED AND THE WHEELS LOCKED UP AND SKIDDED SLIGHTLY SIDEWAYS BEFORE GOING INTO A REDUCED POWER MODE. IF IT HAD BEEN RAINING OR SNOWING, OR AT A HIGHER SPEED ON HIGHWAY THE SITUATION COULD HAVE BEEN DEADLY. I HAD THE CAR TAKEN TO THE DEALER. I WAS TOLD A THE THROTTLE ACTUATOR VALVE WAS DEFECTIVE. THE CAR HAS ONLY 44K MILES BUT HAS SURPASSED THE 4 YEARS OF WARRANTY. THIS IS A KNOWN ISSUE WITH THOUSANDS OF CARS AFFECTED. BMW REFUSES TO RECALL AND REPAIR THE ITEM IF THE CAR IS NOT UNDER WARRANTY. THE COST FOR REPAIR IS $3000.00 THE PART ALONE IS $1200.00 WHICH I WAS QUOTED. MY VEHICLE IS ALSO AFFECTED BY THE TAKATA AIRBAG RECALL.

S65 V8 ENGINE IN A BMW M3 E90/92/93 AND M5'S WITH A V10 HAS TWO THROTTLE VALVE ACTUATORS THAT FAIL PREMATURELY AT 40-80K MILES. BOTH THE INTERNAL NYLON GEARS AND ELECTRONICS WILL FAIL, AFFECTING ACCELERATOR PEDAL RESPONSE AND CAUSING HESITATION, ESPECIALLY WITH THE DCT TRANSMISSION. THESE PARTS ARE NOT A MAINTENANCE ITEM. WHEN FAILED, THE ENGINE MALFUNCTION, EXCESS EMISSIONS, SKID CONTROL, AND ABS BRAKING WARNING LIGHTS ARE TRIGGERED. ENGINE GOES INTO LIMP MODE. THIS IS DANGEROUS WHEN IT HAPPENS WHILE DRIVING IN RAINY, SNOWY, AND ICY ROAD CONDITIONS. THE THROTTLE VALVE ACTUATOR DESIGN DEFECT SHOULD HAVE TRIGGERED A BMW RECALL. REPLACEMENT PARTS ARE $1000-1300 EACH PLUS $1000 LABOR AND HAVE NEVER BEEN REDESIGNED BY BMW/BOSCH. SO THE REPLACEMENT PARTS ARE ALSO DEFECTIVE AND WILL FAIL PREMATURELY. REPAIRS OCCURRED ON DEC. 2012 AT 80K MILES FOR $2000 AND ON JAN. 2016 AT 140K MILES FOR $3000. A BMW M3 AND M5 RECALL AND REDESIGNED PARTS ARE WARRANTED. BMW TECHNICAL SERVICE BULLETINS SHOULD BE ISSUED FOR THIS DESIGN FLAW. 8YR/80KM FEDERAL EMISSIONS WARRANTY SHOULD COVER THESE REPAIRS AS WELL.

I WAS DRIVING ON A TWO-LANE STREET (ONE-LANE EACH DIRECTION) AND AS I WAS APPROACHING A STOPLIGHT I TURNED ON MY LEFT TURN SIGNAL AND STARTED TO MOVE INTO THE DEDICATED LEFT-HAND TURN LANE. AS I DID THIS I NEEDED TO DOWNSHIFT AS I SLOWED DOWN FOR THE STOPPED TRAFFIC AHEAD AT THE LIGHT. WHEN I SHIFTED TO SECOND GEAR AND PRESSED THE ACCELERATOR TO MOVE INTO THE TURN LANE MY CAR WOULD NOT ENGAGE INTO GEAR. I WAS ALMOST REAR-ENDED FROM THE CARS BEHIND ME BUT LUCKILY MY CAR'S TRANSMISSION ENGAGED AT THE LAST SECOND AND I CLEARED THE LANE I WAS IN. BUT BECAUSE I WAS PRESSING THE ACCELERATOR SO HARD TO TRY TO GET THE CLUTCH TO ENGAGE, WHEN IT FINALLY DID I SHOT OFF ACROSS THE LEFT-HAND TURN LANE INTO THE LANE OF ON-COMING TRAFFIC. I WAS ABLE TO STEER CLEAR BEFORE BEING HIT HEAD-ON BY ON-COMING TRAFFIC BUT THE EXPERIENCE LEFT ME VERY UNCOMFORTABLE WITH THE TRANSMISSION IN MY VEHICLE. *TR

HELLO. I HAVE A 2009 BMW M3 WITH THE DCT TRANSMISSION. I AM EXPERIENCING SIGNIFICANT DELAYS WHEN DOWN SHIFTING FROM ONE GEAR TO A LOWER GEAR. THE PROBLEM OCCURS WHEN YOU SLOW DOWN, LIKE FOR A TURN, BUT DO NOT COME TO A COMPLETE STOP. THE DCT TRANSMISSION SEEMS TO HAVE A SERIOUS PROBLEM FIGURING OUT WHAT GEAR TO SELECT BECAUSE WHEN YOU STEP ON THE GAS TO ACCELERATE, THERE IS A VERY SIGNIFICANT DELAY IN THE POWER ENGAGING. I WOULD SAY ABOUT 2-4 SECONDS. BY THIS TIME, I AM REALLY STEPPING ON THE GAS PEDAL. THE TRANSMISSION FINALLY PICKS A GEAR, WHICH RESULTS IN THE CAR SUDDENLY LURCHING FORWARD, SOMETIMES ENGAGING THE ANTI-SKIP CONTROL. THIS PROBLEM BECOMES MOST APPARENT WHEN MAKING A TURN INTO ON-COMING TRAFFIC, SLOWING DOWN TO AROUND 10-15 MPH. AFTER THE TURN, THE CAR IS POSITIONED IN THE TRAFFIC LANE, BUT I HAVE NO POWER TO ACCELERATE INTO THE FLOW OF TRAFFIC. THE ONCOMING CARS ARE NOW CLOSING IN ON YOUR CAR AT A FAST RATE, AND YOU'RE BASICALLY STUCK. *TR

THE CAR SUDDENLY VIBRATED AND THE WHEELS LOCKED UP AND SKIDDED SLIGHTLY SIDEWAYS BEFORE GOING INTO A REDUCED POWER MODE. IF IT HAD BEEN RAINING OR SNOWING, OR AT A HIGHER SPEED ON HIGHWAY THE SITUATION COULD HAVE BEEN DEADLY. I HAD THE CAR TAKEN TO THE DEALER. I WAS TOLD A THE THROTTLE ACTUATOR VALVE WAS DEFECTIVE. THE CAR HAS ONLY 44K MILES BUT HAS SURPASSED THE 4 YEARS OF WARRANTY. THIS IS A KNOWN ISSUE WITH THOUSANDS OF CARS AFFECTED. BMW REFUSES TO RECALL AND REPAIR THE ITEM IF THE CAR IS NOT UNDER WARRANTY. THE COST FOR REPAIR IS $3000.00 THE PART ALONE IS $1200.00 WHICH I WAS QUOTED. MY VEHICLE IS ALSO AFFECTED BY THE TAKATA AIRBAG RECALL.

I WAS DRIVING ON A SIDE ROAD AT THE ALLOTTED SPEED LIMIT., I WAS ON A SINGLE LANE ROAD. I THEN WENT OVER A POTHOLE- NOT A HUGE CRATER. AFTER WHICH MY STEERING WHEEL BECAME CROOKED AND THE DSC FAILURE WARNING ON MY BMW CAME UP. I TOOK IT TO THE DEALER SHIP AND THEY SAID THAT I HAVE DAMAGE TO MY REAR SUB FRAME(BENT), I APPARENTLY HAPPENS UNDER NORMAL DRIVING CIRCUMSTANCES-THE COST FOR REPAIRING IS 4000$. IT IS NOT COVERED UNDER WARRANTY. I HAVE TO PAY FOR IT. IT LOOKS LIKE TO AVOID THESE INCIDENTS I SHOULD NOT BE DRIVING ON ROADS - AS I WAS NOT SPEEDING NOR WAS I INVOLVED IN A COLLISION WITH ANOTHER CAR. I COULD HAVE AVOIDED THE POTHOLE - AT THE EXPENSE OF GOING INTO THE OPPOSITE LANE AND HITTING THE OTHER CAR. I HAVE CONTACTED EVERYONE AT BMW., NONE HELPS. I HOPE THIS IS MY LAST RESORT FOR LITTLE PEOPLE LIKE ME. *TR

LOSS OF POWER ON HIGHWAY AND ENGINE MISFIRE/STUTTER. *TR

ERROR MESSAGE: FAULT IN - PASSENGER RESTRAIN SYSTEM AFFECTING AIRBAG, BELT TENSIONER, OR BELT FORCE LIMITER. THIS IS CAUSED BY FAULT SEAT MAT SENSOR IN THE PASSENGER SEAT, WHICH MAY CAUSE THE AIRBAG NOT TO FUNCTION PROPERLY.

The contact owns a 2009 BMW M3. The contact stated while operating the vehicle, the driver’s and passenger’s side turn signal failed to illuminate. Additionally, the headlights and dashboard lights would flicker on and off. Upon inspection, it was discovered that the electrical wiring insulation was frayed and damaged. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was approximately 84,000.