RoadVitals

2006 BMW R 1200 Gs Adventure Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest Aug 30, 2014
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2006 BMW R 1200 Gs Adventure, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes233.3%
  • Fuel system233.3%
  • Powertrain (other)233.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

PINION BEARINGS FAILED ON FINAL DRIVE UNIT. ADDITIONALLY, PINION SHAFT SEAL FAILURE DUE TO EXCESSIVE PLAY IN SHAFT AS A RESULT OF BEARING FAILURE, CAUSING FINAL DRIVE OIL TO LEAK OUT. THIS CONDITION ALSO CAUSED FAILURE OF ABS/SPEED SENSOR, WHICH RESULTED IN FAILURE OF ABS AND SPEEDOMETER. MOTORCYCLE WAS INOPERABLE AND WAS TOWED. *TR

NHTSA ID 10629647 · filed Aug 30, 2014

REAR BRAKE DISC ROTOR CARRIER FAILED LETTING THE REAR ROTOR FALL AND LOCK UP THE REAR WHEEL AND LOST ALL BRAKING CONTROL . I REPLACED THE FAILED PART NEW ONE WAS MADE OUT OF STEAL OLD PART WAS MADE OUT OF ALUMINUN THIS PROBLEM HAS BEEN REPORTED BY QUITE A FEW RIDERS . I AM STILL IN POCESSION OF OLD CARRIER IF YOU NEED TO EXAMINE IT. *TR

NHTSA ID 10622155 · filed Aug 13, 2014

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

2
reports

From owner reports, verbatim

TL* THE CONTACT OWNS A 2006 BMW ADVENTURE 1200GS MOTORCYCLE. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH, THERE WAS A STRONG GASOLINE ODOR. THE CONTACT ALSO NOTICED A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL PUMP ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID 10575852 · filed Mar 31, 2014

FUEL GAUGE DISPLAYING 1/2 TANK OF FUEL WHEN TANK WAS ACTUALLY EMPTY. MOTORCYCLE RAN OUT OF FUEL ON BUSY FREEWAY WITH LIMITED SHOULDER ACCESS. WAS ALMOST HIT BY NUMEROUS CARS GETTING TO A SAFE PLACE. FUEL LEVEL STRIP HAS BEEN REPLACED TWICE AND IS AGAIN NOT WORKING. THIS IS VERY COMMON ON THESE MOTORCYCLES, AND DANGEROUS AS YOU NEVER KNOW WHEN YOU WILL BE OUT OF GAS. *TR

NHTSA ID 10456143 · filed Apr 23, 2012

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

2
reports

From owner reports, verbatim

PINION BEARINGS FAILED ON FINAL DRIVE UNIT. ADDITIONALLY, PINION SHAFT SEAL FAILURE DUE TO EXCESSIVE PLAY IN SHAFT AS A RESULT OF BEARING FAILURE, CAUSING FINAL DRIVE OIL TO LEAK OUT. THIS CONDITION ALSO CAUSED FAILURE OF ABS/SPEED SENSOR, WHICH RESULTED IN FAILURE OF ABS AND SPEEDOMETER. MOTORCYCLE WAS INOPERABLE AND WAS TOWED. *TR

NHTSA ID 10629647 · filed Aug 30, 2014

BMW 2006 R1200GS ADVENTURE MOTORCYCLE FINAL DRIVE FAILURE WHERE THE FINAL DRIVE SEAL TORN BY METAL PIECES IN THE FINAL DRIVE RESULTING IN THE FINAL DRIVE GEAR OIL BEING DUMPED ON THE REAR WHEEL WHILE RIDING AT HIGHWAY SPEED. *TR

NHTSA ID 10196837 · filed Jul 19, 2007

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .