RoadVitals

2010 BMW S 1000 Rr

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Mar 18, 2016
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Aug 10, 2020
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 3 NHTSA owner-reported complaints for the 2010 BMW S 1000 Rr, most frequently naming the fuel system, engine and powertrain (other) categories. 3 safety recalls have been issued covering this model year; and 51 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Fuel system240.0%
  • Engine120.0%
  • Powertrain (other)120.0%
  • Transmission120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
20V471000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Aug 10, 2020
16,926 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.
The risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.
The remedy: BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLCView on NHTSA.gov
17E052000

EXTERIOR LIGHTING:TURN SIGNAL

Aug 21, 2017
9,000 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain accessory turn signals manufactured for 2006-2017 R1200GS, 2007-2008 and 2010-2017 R1200GS Adventure, 2017 F700GS and F800GS, 2013-2017 F800GT, 2015-2016 F800R, 2014-2017 F800GS Adventure, 2014-2016 S1000R, 2015-2017 R1200R, 2016-2017 R1200RS, and 2010-2017 S1000RR motorcycles. As designed, these accessory turn signals may be insufficiently visible to other drivers, and, as such, fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The risk: If other drivers cannot easily see the turn signals, there would be an increased risk of a crash.
The remedy: BMW will notify owners, and dealers will replace the turn signals, free of charge. The recall began October 25, 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLCView on NHTSA.gov
13V617000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Dec 12, 2013
50,184 units potentially affected
The defect: BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.
The risk: A fuel leak in the presence of an ignition source may result in a fire.
The remedy: BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].
BMW of North America, LLCView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

EngineFuel systemPowertrain (other)
Filed Mar 18, 2016

MOTORCYCLE ENGINE POWER CAN STOP SUDDENLY, WITHOUT WARNING, AT ANY TIME DURING OTHERWISE NORMAL OPERATION. ENGINE DIES IMMEDIATELY WHEN THE SLIGHTEST BIT OF THROTTLE IS APPLIED, LEAVING THE RIDER POWERLESS AND COMPLETELY VULNERABLE TO SURROUNDING TRAFFIC AND CONDITIONS. MY BMW S1000RR MOTORCYCLE WAS OPERATING COMPLETELY NORMALLY, THEN UPON ENTERING A BUSY STREET FROM A PARKING LOT THE VEHICLE DIED SUDDENLY, WITHOUT ANY WARNING LEAVING ME STRANDED IN ONCOMING TRAFFIC. I IMMEDIATELY STARTED THE ENGINE, ONLY TO HAVE THE ENGINE DIE AGAIN WHEN I APPLIED THE THROTTLE. I PUSHED MYSELF OUT OF TRAFFIC TO SAFETY AND HAD THE VEHICLE TRANSPORTED TO A DEALER. UPON ARRIVAL AT THE DEALERSHIP, THE ENGINE STARTED AND THE BIKE OPERATED NORMALLY FOR A FEW MINUTES BEFORE IT RESUMED THE SUDDEN LOSS OF ENGINE POWER. THE DEALERSHIP TRIED TO FIND OUT WHAT WAS CAUSING THE PROBLEMS BUT WAS UNABLE TO DETERMINE THE CAUSE. AFTER 4 MONTHS BMW MOTORAD FINALLY ADVISED THE DEALER TO REPLACE THE THROTTLE BODIES, WHICH IS APPARENTLY A WELL-KNOWN REMEDY TO A WELL KNOW FACTORY DEFECT THAT EFFECTS THE SUBJECT MOTORCYCLE. I HAVE CONCERNS THAT BMW HAS PRIOR KNOWLEDGE OF SIMILAR MALFUNCTIONS FOR THIS VEHICLE THAT ARE RELATED TO DEFECTIVE OEM PARTS. I BELIEVE THAT BMW MAY HAVE PRODUCED AND SOLD OTHER S1000RR'S THAT MAY HAVE DEFECTIVE OEM PARTS OR OTHERWISE KNOWN SAFETY ISSUES THAT CAN CAUSE EFFECTED BIKES TO TOP SUDDENLY, WITHOUT WARNING, WITH POTENTIALLY LETHAL CONSEQUENCES. IT SEEMS THAT BMW HAS FAILED TO ALERT OWNERS OF THIS PROBLEM, DESPITE HAVING NUMEROUS CASE HISTORIES AND WARRANTY CLAIMS OF A SIMILAR BASIS. BMW SHOULD ACT RESPONSIBLY AND ADVICE OWNERS OF THESES KNOW DEFECTS, SO THEY CAN AVOID RIDING THE SUBJECT BIKES UNTIL THE BIKES ARE CHECKED OUT AND RENDERED SAFE.

NHTSA ID
10850478
Incident
Oct 2, 2015
Mileage
1,800 mi
Fuel system
Filed Dec 3, 2013

I HAVE RADIAL CRACK ON THE FUEL TANK FLANGE CAUSING THE MOTORCYCLE TO LEAK FUEL ON TO THE MOTOR. I QUICK INTERNET SEARCH SHOW THAT THIS HAS BEEN A PROBLEM FOR MANY BMW MOTORCYCLES TO THE POINT WHERE A AFTERMARKET COMPANY IS MAKING A CLAMP TO REPAIR THE PROBLEM. *TR

NHTSA ID
10554673
Incident
Nov 20, 2013
Mileage
15,355 mi
Transmission
Filed Sep 27, 2012

CPSC#I1290121A. 2010 BMW S1000RR. CONSUMER STATED HE STARTED TO HAVE PROBLEMS WITH HIS CLUTCH CABLE AFTER ONLY A FEW THOUSAND MILES. *LN THE CONSUMER STATED THE CLUTCH CABLE BEGAN TO FRAY. HE STATED THE LEVER DESIGN TO ACCEPT THE CLUTCH CABLE WAS NOT CENTERED WITHIN THE CLUTCH PERCH BLOCK AS THE BMW ORIGINAL EQUIPMENT. IT CREATED A SEVERE ANGLE WHICH RESULTED IN THE CABLE GRINDING AGAINST THE INSIDE OF THE PERCH AND HEAT DEVELOPED BY FRICTION ELIMINATED THE CABLE LUBRICATION AND DESTROYED THE CABLE STRANDS ONE AT A TIME AND DESTROYED THE PERCH. THE DEALER DID CONFIRM THAT THE CLUTCH CABLE FAILURE WAS A SYMPTOM OF A POORLY DESIGNED CLUTCH LEVER BY THAT PARTICULAR COMPANY.

NHTSA ID
10477841
Incident
Aug 15, 2012

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B611305

ELECTRICAL SYSTEM

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.

MC310123

SUSPENSION

On the above listed vehicles, lubricant residue can be found on the fork cap on the right side telescoping fork. Vehicles with caps 31 42 1 754 557 and 31 42 1 757 701 can show this residue. These are not leaks at the cap, but assembly grease residue. Forks with this apparent leak have been received and leak testing was performed. NO leaks could be detected.

MC110322

ENGINE AND ENGINE COOLING

During the production of the intake camshaft there was a change in the coolant used to prevent localized overheating of parts of the camshaft. Because of this, certain parts of the camshaft may have a changed surface hardness that can result in increased wear of the rocker arms and camshaft over time.

MC160323

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Vehicle goes into emergency operation mode and a warning light illuminates on the instrument cluster.

SIB-111421

SUSPENSION

CHECK ROCKER ARMS AND REPLACE WHERE NEEDED.

MC000521

ELECTRICAL SYSTEM

One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

BMW S 1000 Rr by model year
YearComplaintsRecallsInvestigationsIssue Index
2026020—
2025120—
2024110—
2023220—
2022420—
2021110—
2020104040.5
2019000—
2018100—
2017020—
2016220—
2015510—
2014020—
2013230—
2012740—
2011140—
2010Viewing330—
2009000—
2008001—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.