Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2003 BMW X5 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 17 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Wiring dash fire. Heavy smoke from dash and vehicle completely in flame in minute. My son sent me a recording while it was happening, he did no know what to do or what was happening.
The contact owns a 2003 BMW X5. The contact stated the vehicle was parked, while entering the vehicle he noticed the dashboard was melted, which was caused by a fire that occurred independently. The contact stated he reviewed a camera that was near the location of the vehicle and saw the fire occur on the video. The contact did not call the fire department to report the incident. The contact stated no one was injured nor sought medical attention. The vehicle was not drivable. The contact towed the vehicle to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 137,000.
My 2003 BMW X5 was parked outside of my house, turned off and not driven for hours and burst into flames consuming the whole dashboard, fire department said that fire was due to some electrical problem with car, very scary please help could of killed my family the incident was recorded on home surveillance footage, but I cannot upload because of size
THE CAR STARTED LOSING POWER WHILE ON THE ROAD. IT GOT SLOWER AND SLOWER, TILL IT FINALLY CAME TO A COMPLETE STOP. IT HAD TO BE TOWED THE REST OF THE WAY TO THE HOUSE. THE ENGINE WOULD START UP, BUT IT WOULD NOT ENGAGE ANY OF THE GEARS.
THIS MORNING 03/13/2020 AT APROX. 2:30AM MY BMW X5 2003 WAS ENGULFED IN FLAMES FOR NO REASON AND MY TWO GERMAN SHEPHERDS HEY YOU AND MY BABY DIESEL WERE INSIDE,AND HOW ONE MADE IT OUT AND THE BABY DIDNT, I BUSTED WINDOWS CAUSE I HEARD HIM CRYING ,,,,I COULDNT GET HIM I TRIED TO I TRIED OH MY GOD MY POOR BABY , I WAS INJURED AND SCARED FOR LIFE WITH THAT. MY CAR WAS OFF AND PARKED IN FRONT OF A FRIENDS HOUSE ON A SIDE STREET, ALL A LOSS. NO PICTURES TAKEN ,SEVERAL POLICE AND FIRE DEPT. CAME.
TL* THE CONTACT OWNS A 2003 BMW X5. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 17V047000 (AIR BAGS) AND THE VEHICLE WAS REPAIRED. WHILE THE CONTACT WAS DRIVING HOME FROM THE SERVICE APPOINTMENT AT 55 MPH, THE BATTERY WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED THE BMW STORE (6131 STEWART RD SUITE 1, CINCINNATI, OH 45227, (513) 271-8700) AND WAS INFORMED THAT DIAGNOSTIC TESTING WAS NEEDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE CONTACT STATED THAT THE DEALER CAUSED THE FAILURE DUE TO NOT DISCONNECTING THE BATTERY. THE CONTACT CALLED THE BETTER BUSINESS BUREAU AND WAS PROVIDED COMPLAINT ID NUMBER: 3787246. THE FAILURE MILEAGE WAS 172,000. THE VIN WAS INVALID.
TL* THE CONTACT OWNS A 2003 BMW X5. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS THE SMELL OF PLASTIC BURNING AND THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THAT THERE WAS SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE ENGINE STALLED WITHOUT WARNING. MOMENTS LATER, THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE VEHICLE WAS BURNED DOWN TO THE FRAME. THE VEHICLE WAS DESTROYED AND TOWED TO A BODY SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
I PURCHASED THE VEHICLE USED, I HAVE HAD IT FOR ABOUT 5 MONTHS AND HAVE HAD SOME SERIOUS PROBLEMS (STEERING COLUMN, WINDOW REGULATORS, ENGINE, AND COOLANT LEAKAGE). I SEE WHERE THESE ISSUES SEEM TO BE CONSISTENT WITH THE VEHICLE, BUT AM HAVING A HARD TIME GETTING THE RECALL WORK DONE. I CAN'S AFFORD TO SPEND A LOT ON THIS CAR, BUT I FEEL LIKE I MAY HAVE MORE THAN I BARGAINED FOR. MY EXTENDED WARRANTY IS NOT PAYING FOR MUCH !!! HELP *TR
TL* THE CONTACT OWNS A 2003 BMW X5. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE CAUGHT FIRE WHILE PARKED IN A RESIDENTIAL GARAGE. THE MANUFACTURER INVESTIGATED THE FAILURE AND CONCLUDED THAT CAUSE OF THE FIRE WAS NOT DUE A MANUFACTURING DEFECT. A POLICE REPORT WAS FILED OF THE INCIDENT. THE CONTACT STATED THAT THE BATTERY WAS REPLACED TWICE AND THE COMPUTER SYSTEM WAS REPLACED THREE TIMES PRIOR TO THE FIRE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000. UPDATED 2/15/13 *CN THE CONSUMER BELIEVED THE FIRE WAS DUE TO AN ELECTRICAL FAILURE. UPDATED 02/02/513
THE PIXELS ON THE INSTRUMENT CLUSTER AND THE RADIO DISPLAY ARE FADED OUT WHICH MAKES THE VISIBILITY ON THESE ITEMS EXTREMELY DIFFICULT. THIS IS A KNOWN ISSUE THAT HAS BEEN BROUGHT TO BMWUSA'S ATTENTION AND DISCUSSED ON MANY BMW FORUMS, YET THE MANUFACTURER AND ITS SUPPLIER (SIEMANS VDO) REFUSE TO FIX. *TR
I WAS DRIVING THE VEHICLE IN STOP AND GO TRAFFIC, THE VEHICLE LOST ALL POWER FORCING ME TO COME TO COMPLETE STOP IN THE MIDDLE OF THE HIGHWAY. THIS OCCURRED 3 OTHER TIMES IN THE PAST 4 MONTHS , THE OTHER INCIDENTS WERE IN THE PARKING LOT. THE CAR STARTS UP AND RUNS PERFECTLY BEFORE AND AFTER. I AM CONCERNED ABOUT MY SAFETY. SEARCHING FOR A SOLUTION, I FOUND THAT BMW HAS SERVICE BULLETIN TO ADDRESS THIS ISSUE. I AM SURPRISED THAT THERE IS NO RECALL ON THIS SINCE IT IS A HUGE SAFETY CONCERN. *TR
THE RIGHT REAR BRAKE LIGHT BULB SHORTS OUT. INSTRUMENT WARNING FOR REAR BRAKE / TAIL LIGHTS ACTIVATES. PROBLEM OCCURS MULTIPLE TIMES DUE TO AN APPARENT FLAW IN THE BRAKE LIGHT ASSEMBLY CIRCUIT AND PLASTIC THAT FORMS THE SPLIT CIRCUIT FOR POSITIVE (+) NEGATIVE (-) CONNECTION POINTS TO BULB SOCKET LEADS. TO REPAIR - THE METAL ASSEMBLY NEEDS TO BE BENT OUTWARD (DIRECTION AWAY FROM TAIL LIGHT LENS) TO INCREASE TENSION BETWEEN BULB SOCKET ELECTRICAL CONNECTIONS AND METAL PLATE OF TAIL LIGHT ASSEMBLY. PROBLEM SEEMS TO BE CAUSED BY WEAKENED PLASTIC THAT CAUSES THE METAL PLATE IN TAIL LIGHT ASSEMBLE TO LOOSEN CREATING INADEQUATE BACK SPRING TENSION BETWEEN THE PLATE AND SOCKET CONNECTORS. RECALL ON BMW 3 SERIES FOR: NO. 11V-438: LAMPS IN REAR QUARTER PANEL 2002-2005 3 SERIES IS DESCRIBED AS THE EXACT PROBLEM. *JS
THE LEFT REAR TAIL LIGHT CONTINUES TO WORK INTERMITTENTLY. THE 'CHECK BRAKE, CHECK REAR LIGHT' WARNING ILLUMINATES EVEN AFTER BULBS HAVE BEEN REPLACED. I HAVE REPLACED THE BULBS NUMEROUS TIMES, WITH THE MOST RECENT BEING A FEW DAYS AGO. YET, THE WARNING MESSAGE REAPPEARED THIS EVENING. THE PROBLEM IS SIMILAR TO THOSE RECENTLY INVESTIGATED BY NHTSA ON OTHER BMW MODELS SUCH AS THE 3 SERIES AND IS A COMMON COMPLAINT IN BMW FORUMS AND OTHER FORUMS ON THE INTERNET.
TL*THE CONTACT OWNS A 2003 BMW X5. WHILE PULLING INTO THE DRIVEWAY AT 5 MPH, THE DRIVER NOTICED THAT THE INSTRUMENT PANELS LIGHT BEGAN TO DIM AND THE VEHICLE STALLED. APPROXIMATELY TWO HOURS LATER, THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS DRIVEN TO THE DEALER. THE MECHANIC INFORMED HER THAT THE INSTRUMENT CLUSTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 100,200 AND FAILURE MILEAGE WAS 95,000. UPDATED 03/09/09. *LJ AFTER SHUTTING THE VEHICLE OFF, THE FRONT AND REAR LIGHTS STAYED ON AND THE DOOR LOCKS WERE INOPERATIVE. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE, BUT IT WOULD NOT START. THE DEALER FOUND COMMUNICATIONS FAULTS IN THE INSTRUMENT CLUSTER. UPDATED 03/12/09. *JB
BMW X-5 HAS CAUSED TWO ACCIDENTS BY SPONTANOUS ACCELLERATION - AFTER FIRST ACCIDENT BMW WAS CONTACTED AND ENGINEERS KEPT VEHICLE AND DETERMINED THAT CAUSE OF ACCIDENT DRIVER ERROR-WE PAID FOR REPAIR OF VEHICLE. SAME "ACCELERATION" HAPPENED ABOUT SIX MONTHS LATER ON JANUARY 7 SENDING CAR CRASHING THROUGH FRONT OF BUILDING - ONLY BY MIRACLE PEOPLE WEREN'T INGURED IN THESE ACCIDENTS (THE BUILDING WAS A A RETAIL STORE). THIS IS A LEASED VEHICLE AND WE DON'T KNOW WHAT TO DO. LSO, THESE INCIDENTS HAVE CAUSED OUR INSURANCE TO SKYROCKET.*AK
CONSUMER WAS TRAVELING 45 MPH AND VEHICLE SURGED FORWARD, AND DROVE ROUGHLY. A LOUD GRINDING NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER NOTICED THAT THE CHECK ENGINE LIGHT FLASHED ON THEN OFF. CONSUMER DROVE IT TO THE DEALER, AND MECHANIC DETERMINED THAT TWO IGNITION COIL SPRINGS NEEDED TO BE REPLACED INSIDE OF THE ENGINE. *AK
OCTOBER 2002 I PURCHASED A NEW BMW X5 - SHORTLY THERE AFTER I STARTED TO EXPERIENCE INTERMITTENT ELECTRICAL PROBLEMS - HEADLIGHTS WOULD NOT SHUT OFF WITHOUT RE-STARTING THE CAR, INTERIOR LIGHTS WOULD NOT TURN OFF, THE FLASHERS WOULD COME ON, THE REAR LATCH WOULD DISCONNECT, THE KEYLESS ENTRY INTO THE CAR WOULD NOT WORK, BATTERY WAS BEING DRAINED AND ULTIMATELY THE BATTER WOULDN'T EVEN HOLD A CHARGE. AFTER 3-4 MONTHS OF EXPERIENCING THESE INTERMITTENT PROBLEMS, I INSISTED THE DEALER TAKE THE CAR BACK AND LET ME PURCHASE A 2003 BMW X5. I RECEIVED THE NEWEST BMW X5 ON FEBRUARY 26, 2003 AND ON MARCH 10, 2003, I STARTED EXPERIENCING PROBLEMS AGAIN! THIS TIME, WHEN THE IGNITION WAS TURNED ON, THE FLASHERS CAME ON AND THE INTERIOR LIGHTS WOULD NOT SHUT OFF WITHOUT ME OPENING THE DOOR AND CLOSING IT AGAIN - I HAD TO MANUALLY SHUT OFF THE FLASHERS. MINUTES LATER AFTER DRIVING THE CAR, I SHUT OFF THE IGNITION, GOT OUT OF THE CAR AND USED THE KEYLESS ENTRY SYSTEM TO LOCK THE CAR AND ARM THE ALARM. I WASN'T ABLE TO LOCK THE CAR DOORS BUT THE ALARM WAS ACTIVATED. I HAD TO TURN THE ALARM OFF AND OPEN THE DOOR AND CLOSE IT AGAIN. THEN I WAS ABLE TO LOCK IT. THE CAR HAS BEEN AT THE DEALER SINCE AND THEY DO NOT KNOW WHAT IS CAUSING THIS PROBLEM. *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .