Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2021 BMW X7 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Under FMVSS 101, if a screen experiences a momentary "black screen" or reset cycle while driving, it is considered non-compliant because the driver loses immediate access to the speedometer, safety and ADAS functions of the vehicle. The OEM (BMW North America) does not acknowledge this issue in their vehicles and ignores repairs violating NHTSA standards.
The entire car shut down while on the highway with no prior notifications on/from the system. The entire safety of myself and family was put at risk because there where several cars behind us on the highway that could have hit us. I am not sure the dealer has been able to reproduce the issue - Unknown. There was no warning lamps, messages or symptoms of the problem prior to the failure or the car shutting off on the highway.
The IP cluster (gauges that display speedometer, fuel levels and other ADAS features) was blanking intermittently, BMW service center suggested software update as they believed it to be a software bug. Later, when the software update did not work, they suggested we replace the battery even though we tested it months ago and it was fine. After the battery replacement when the IP cluster was still inoperable, BMW recommended i pay another $3k for the IP replacement. I am seeing Hyundai have a similar issue but they have shared a proper recall and repair notice to consumers at NO COST. Many BMW X7 owners have faced a similar issue to mine. I am hoping to gather the complaints and pursue a national recall bulletin as the IP cluster blanking out mid drive can lead to a catastrophic scenario
The contact owns a 2021 BMW X7. The contact stated that the vehicle failed to start after several attempts, with several unknown warning lights illuminated. The vehicle was towed to an independent mechanic who was initially unable to determine the cause of the issue. The contact reached out to a BMW-certified technician who inspected the vehicle and confirmed a starter failure. The manufacturer was notified of the issue and denied a request for Goodwill assistance. The contact to paid for the repair out of pocket. The vehicle was repaired. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 83,400.
Dear NHTSA Vehicle Safety Hotline Team, I am writing to formally report a serious safety concern regarding my 2021 BMW X7. My vehicle is exhibiting a dangerous condition where it fails to start on the initial attempt, displays a "Repeat Start Attempt" warning message on the dashboard, and then heavily strains to turn over on the second attempt.While I am aware that BMW issued a safety recall (NHTSA Campaign Number 24V-576) regarding starter motor overheating and engine fire risks for certain 2019–2021 models, I believe the current remediation or scope may not fully protect consumers from the immediate hazards of this failure.When the vehicle demands a second start attempt, it forces a high electrical draw that risks severely overheating the starter mechanism. This creates an immediate risk of electrical thermal overload and potential engine compartment fires while trying to get the vehicle moving.Below are the specific details of my vehicle and the safety incident:Vehicle Make and Model: 2021 BMW X7 Vehicle Identification Number: [XXX] Current Mileage: 57226 Incident Description: The vehicle consistently fails its initial ignition sequence. It prompts a "Repeat Start Attempt" notification, forcing a high-stress second startup sequence that poses an immediate electrical fire hazard.I request that the NHTSA review this ongoing issue, ensure that BMW's remedy effectively eliminates the fire risk during these secondary start cycles, and hold the manufacturer accountable for immediate component replacement.Thank you for your prompt attention to this safety matter. I look forward to your investigation. Sincerely, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The water pump pulley "exploded", causing the accessory belt to fall off which drives the alternator. The pulley "shrapnel" was thrown into the cooling system and damaging the hoses causing immediate loss of coolant. The loss of electrical power due to the alternator being inoperable and the loss of cooling could have caused the vehicle to malfunction in a dangerous manner. Fortunately, the vehicle displayed an error message and was towed to the dealer without further incident.
The contact owns a 2021 BMW X7. The contact stated that while the contact's wife was driving at an undisclosed speed, the contact's wife noticed a smoky fume in the interior of the vehicle. The contact's wife continued to drive the vehicle to the intended destination. The contact stated that when the wife returned to the vehicle, the contact's wife noticed that the smoky fume was still in the interior of the vehicle. The vehicle was driven to the contact's residence. The contact stated that upon removing items from the vehicle, the contact noticed that a cardboard box that was seated on the driver's rear seat was on fire. The contact extinguished the fire. No fire report was filed. No injuries were sustained. The contact then contacted BMW and requested the vehicle to be picked up. The vehicle was towed to the dealer. The contact stated that the vehicle had been at the dealer for two weeks. The contact was informed that the failure was due to no fault of the manufacturer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 25,320.
I was driving a car with family and all of a sudden we all started smelling a burning smell but we thought it must be from outside. However, in just few seconds the vents started throwing vapors so I stopped the car hoping it may stop if some minor damage. However, the hood started throwing oranges color fumes and by the time we all left the vehicle the entire front hood/engine area started burning. There were no indications of any faults in the car. This was the most shocking incident we had to face with my family where there were two kids of 4 and 9 along with my wife and her parents who are senior citizens.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .