2021 BMW X7 Engine Problems

On [XXX], while traveling at highway speeds on a public roadway, the vehicle suffered a sudden, violent, and catastrophic mechanical explosion in the front drivetrain. Without any prior warning lights, dashboard messages, or operational symptoms, the front differential and driveshaft structurally shattered. The physical violence of the drivetrain components exploding at high speed sent metallic shrapnel directly into the engine compartment. This flying shrapnel pierced the structural engine block, completely destroying the engine and causing immediate, total power loss while surrounded by highway traffic. This sudden loss of propulsion and mechanical locking created an extreme, life-threatening hazard to myself and surrounding motorists. The vehicle was towed to an authorized dealership (Motorwerks BMW, Bloomington, MN). The service department confirmed the mechanical sequence: the front differential structurally failed first, and its catastrophic disintegration directly caused the secondary destruction of the engine block. The formal repair estimate is $66,124.76. BMW of North America Executive Care has formally reviewed the case and issued a written admission of fault regarding the drivetrain components, offering to cover the differential and driveshaft repairs. However, they are refusing to remedy the catastrophic engine destruction caused directly by their failed safety component. This component failure represents a severe, systemic structural safety risk that warrants an immediate federal safety investigation into 2019–2022 BMW X7/X5 front differential assemblies before an explosion results in a fatal highway collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11752922

Incident

Jun 12, 2026

While driving my 2021 BMW X7 at approximately 32,000 miles, the vehicle suddenly displayed a drivetrain malfunction warning along with a low engine oil pressure warning. At the same time, I noticed excessive heat and a strong burning smell coming from the vehicle. I also heard abnormal mechanical noises coming from the engine, which sounded like knocking or grinding. The engine failure occurred unexpectedly at relatively low mileage and required extensive repairs, with estimated costs of approximately $15,000. A sudden loss of oil pressure and abnormal engine noises while driving creates a serious safety risk because it can lead to engine damage, loss of power, or the vehicle becoming disabled in traffic without warning. Based on the diagnosis and information from the repair facility, the failure may be related to an internal engine or oil pump issue affecting lubrication. I am reporting this incident because similar failures have been reported by other BMW owners, and I believe this condition warrants investigation as a potential safety-related defect.

NHTSA ID

11732539

Incident

Jan 22, 2026

very known issue of catastrophic failure to the oil pump, made in Italy with plastic component, used in my vehicle. The part has been updated to metal components on bmw side without any knowledge to the customers with same part number. Faulty xdrive tranfer case, wheel jerks on low speed turning. Currently in class action lawsuit.

NHTSA ID

11728211

Incident

Oct 1, 2025

The contact owns a 2021 BMW X7. The contact stated that while driving at 20 MPH and depressing the accelerator pedal, the vehicle went into LIMP Mode. The message "Pull Over and Turn Off Your Car - You Have Lost All the Water In the Radiator" was displayed. The contact was able to pull over to the side of the road. The vehicle was able to restart, but was towed to Hawkeye Motorsports LLC, where it was diagnosed that the water pump pulley had shattered. The mechanic replaced the coolant pump, coolant lines, and belts. Additionally, the coolant lines were tested. The vehicle was repaired. The manufacturer was contacted and informed that reimbursement assistance could only be provided if the VIN was included in a related recall. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.

NHTSA ID

11717086

Incident

Nov 18, 2025

Mileage

79,000 mi

Front differential needing completely replaced at 44,000 miles. Might need a transfer case replacement as well. Original quote of $8,300 and if the transfer case is needing replaced, another $8,000-$10,000 job. I have done research online that a lot of other people with X7's are having this issue. Autobahn BMW in Fort Worth, Texas confirmed the issue and that it needs complete replacement done. There were no warnings, no lights on the dash, and nothing that would indicate there was an issue until leaking starting and I could smell the oil burning.

NHTSA ID

11711828

Incident

Jan 16, 2026

Infotainment stopped working, no backup cam no safety features working

NHTSA ID

11700071

Incident

Nov 5, 2025

two fan blades came off and punctured my radiator. I replaced the radiator/fan for 4300 and when I picked it up, it said the power was limited and to get it to a BMW dealership right away and when I took it to BMW, they told me the engine was shot and cylinder four was completely destroyed. Then both through BMW corporate and the dealership that I bought the car at new in 2022 I was told there was nothing that they would do at all. In fact I was told it would cost $46,500 plus tax to replace the engine. The car is only worth 40 and I owe 29 I have been without a car for many months and I don’t know what to do with this card is essentially become a paperweight. I bought it brand new at arrowhead BMW for almost $115,000 with 3000 miles on it. Someone had purchased it new and brought it back and I’m not sure why exactly. It just doesn’t feel right that I should only be able to drive a car for 65,000 miles until it’s completely valueless furthermore, my attorney informed me that there was a class action lawsuit around my engine that was closed and it just doesn’t seem right that they would continue to make this engine. I’m hoping there’s some sort of resolved because it’s a very costly situation for me and my family

NHTSA ID

11695567

Incident

Jul 31, 2025

Car had an error message "drivetrain malfunction" car was drivable. Car has 87000 purchased in 2021. Car needs a new engine. Other Car owners having similar issues with the drivetrain malfunction

NHTSA ID

11647788

Incident

Mar 9, 2025

The water pump pulley "exploded", causing the accessory belt to fall off which drives the alternator. The pulley "shrapnel" was thrown into the cooling system and damaging the hoses causing immediate loss of coolant. The loss of electrical power due to the alternator being inoperable and the loss of cooling could have caused the vehicle to malfunction in a dangerous manner. Fortunately, the vehicle displayed an error message and was towed to the dealer without further incident.

NHTSA ID

11638117

Incident

Jan 22, 2025

2 Issues: 1) The water/coolant pump leaks and fails, leading to overheating. BMW says the following Service Bulletin does not apply: SIB 11 05 21 SERVICE ACTION: REPLACE THE MECHANICAL COOLANT PUMP I'm not really sure why or how it doesn't apply but it should. 2) The front passenger seatbelt has failed, in that it does not retract into its housing.

NHTSA ID

11569126

Incident

Jan 15, 2024

I was driving a car with family and all of a sudden we all started smelling a burning smell but we thought it must be from outside. However, in just few seconds the vents started throwing vapors so I stopped the car hoping it may stop if some minor damage. However, the hood started throwing oranges color fumes and by the time we all left the vehicle the entire front hood/engine area started burning. There were no indications of any faults in the car. This was the most shocking incident we had to face with my family where there were two kids of 4 and 9 along with my wife and her parents who are senior citizens.

NHTSA ID

11447812

Incident

Jan 16, 2022