1999 BMW Z3 Owner Complaints

Hello, NHTSA released a recall warning for BMWs made from 2000 to 2006, regarding Takata airbags. "The risk to vehicle occupants is dire," it said. My 1999 BMW Z3 was made one year before this, and is not included in the recall. I have been trying to determine whether my '99 BMW has Takata airbags as well, thus far with no success. As of today, BMW will only tell me that there are no outstanding recalls for my car - they have not been willing to tell me what type of airbags they originally installed in it. Do your records indicate what type of airbags I have?

NHTSA ID

11576189

Incident

Mar 8, 2024

AIR BAG LIGHT STAYS LIT

NHTSA ID

11288865

Incident

Jul 16, 2017

Mileage

103,000 mi

THE PASSENGER AIR BAG LIGHT IS ON AND STAYS ON. WHETHER CAR IS STATIONARY OR IN MOTION.

NHTSA ID

11288157

Incident

Oct 10, 2019

Mileage

53,000 mi

VERY WELL KNOWN FAILURE, JUST SEARCH FOR "BMW Z3 SUBFRAME FAILURE". IT IS A DESIGN FLAW BY BMW THAT AFFECTS A LOT OF Z3'S THROUGH ALL MODEL YEARS. MINE STARTED TO POP ONE WELD AT 88K MILES. IT CAN CAUSE THE REAR ALIGNMENT TO BE OFF, IN WORST CASE THE TRUNK FLOOR IS TORN OUT AND THE DIFFERENTIAL FALLS TO THE GROUND. CLUNKING FROM THE BACK WHILE SHIFTING IN THE FIRST TWO GEARS IS ONE INDICATOR THIS DAMAGE IS NOT FAR AWAY. THIS IS ONE FORUM THREAD THAT DESCRIBES THE ISSUE WELL: HTTPS://WWW.BIMMERFORUMS.COM/FORUM/SHOWTHREAD.PHP?1979601-SUBFRAME-TRUNK-FLOOR-DIFFERENTIAL-MOUNT-FAILURE

NHTSA ID

11032127

Incident

Oct 6, 2017

Mileage

88,000 mi

TL* THE CONTACT OWNS A 1999 BMW Z3. AFTER THE VEHICLE WAS STARTED AND PLACED INTO REVERSE, A CLANKING SOUND EMERGED FROM THE REAR END WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 99V272000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10874771

Incident

Jun 13, 2016

Mileage

140,000 mi

THE REAR DIFFERENTIAL HOUSING IS SEPARATING FROM THE SUBFRAME OF THE CAR, UNDER OR NEAR THE TRUNK AREA. THIS IS A WELL DOCUMENTED ISSUE WITH THE Z3 SERIES OF VEHICLES. THIS COULD BE A SAFETY HAZARD WHILE OPERATING THE VEHICLE IF THE READ DIFFERENTIAL SEPARATES FROM THE SUBFRAME, AND COULD CAUSE A HAZARD TO OTHER MOTORIST. THIS APPEARS TO BE DUE TO A DESIGN FLAW. THE FRAME WAS DESIGNED FOR A 1.9L ENGINE, AND BMW DID NOT REDESIGN THE SUBFRAME TO ALLOW FOR THE LARGER ENGINES IT LATER SOLD IN THE Z3 SERIES OF CARS. BMW ALSO HAD THIS SAME ISSUE ON 3XX SERIES OF VEHICLES, AND AGREED TO REPAIR THOSE CARS DUE TO A CLASS ACTION LAW SUITE SETTLEMENT. BMW SHOULD BE HELD ACCOUNTABLE FOR THE DESIGN ISSUE, AND ACKNOWLEDGE THE SAFETY HAZARD. *TR

NHTSA ID

10676809

Incident

Nov 26, 2014

Mileage

101,000 mi

DRIVER SEAT BECAME LOOSE AND WOULD SLIDE FORWARD WHEN BRAKES WERE APPLIED AND BACKWARD ON ACCELERATION. THE MOVEMENT WAS ABRUPT ENOUGH TO BE DISCONCERTING, ESPECIALLY IN AN EMERGENCY MANEUVER. BMW DEALERSHIP ADVISED IT WAS EXPENSIVE TO REPAIR AND NOT DANGEROUS BECAUSE THE SEAT WAS NOT AT RISK OF FULLY DETACHING. I HAVE LIVED WITH IT, BUT IT IS A POTENTIAL CAUSE OF ACCIDENTS AND IT FEELS UNSAFE - AS IF THE SEAT MIGHT COME LOOSE. IT IS VERY DISTRACTING TO ANY DRIVER WHO IS NOT ACCUSTOMED TO IT AND EVEN TO ME - A LIKELY CAUSE OF DRIVER ERROR OR LOSS OF CONTROL DURING ABRUPT MANEUVERS. RECENTLY AS I LOOKED ON THE INTERNET FOR SOLUTIONS I FOUND THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH 1999 M ROADSTER VERSION OF THE Z3. I THINK IT IS SUFFICIENT TO MERIT RECALL, BUT THAT IS WHAT YOU FOLKS DO FOR A LIVING... I HOPE YOU WILL LOOK INTO IT CAREFULLY. PS: THE DATE THAT I ENTERED IS A VERY ROUGH ESTIMATE. I DO NOT RECALL PRECISELY WHEN THE PROBLEM FIRST OCCURRED. THANK YOU *TR

NHTSA ID

10622505

Incident

Aug 18, 2005

MY 1999 BMW ROADSTER ENGINE BEGAN TORQUING FROM IDLE TO VERY FAST WITHOUT ANY WARNING. I HAVE TAKEN IT TO MECHANICS AND THEY DO NOT KNOW WHAT WOULD CAUSE THIS. IT HAS HAPPENED MULTIPLE TIMES SINCE THEN. IT WILL STOP THIS WHEN I SHUT OFF ENGINE AND TURN IT BACK ON. I FEAR THIS COULD CAUSE A SERIOUS ACCIDENT. PLEASE ADVISE ON WHAT TO DO. *TR

NHTSA ID

10578088

Incident

Oct 20, 2011

Mileage

88,000 mi

DRIVER SIDE (DOOR) AIRBAG DEPLOYED WHILE DRIVING ON HIGHWAY. IMPACT CAUSED ME TO SWERVE INTO ONCOMING TRAFFIC LANES. *TR

NHTSA ID

10491929

Incident

Jan 7, 2013

Mileage

117,860 mi

I HAVE SUBFRAME DAMAGE, IN THE TRUNK IT'S MOST VISIBLE WITH THE CARPET OUT, I CAN SEE THE SPOT WELDS HAVE POPPED, CRACKED, BROKE FREE, WHATEVER. THUS CAN CAUSE A MASSIVE RISK TO AS IF ANYMORE POP THE DIFFERENTIAL COULD POSSIBLE TEAR NEXT THE BRACKET THAT HOLDS IT UP. *TR

NHTSA ID

10477242

Incident

Sep 14, 2012

Mileage

100,000 mi

REAR SUBFRAME ON VEHICLE HAS TORN FROM THE REAR UNDER PANEL ON VEHICLE. THE TRUNK FLOOR ON VEHICLE IS FALLING OUT FROM UNDERNEATH, THIS POSES A MASSIVE SAFETY ISSUE. WAS TOLD BY TECHNICIAN VEHICLE IS NO LONGER SAFE TO OPERATE. *TR

NHTSA ID

10389650

Incident

Mar 6, 2011

Mileage

175,556 mi

TL* THE CONTACT OWNS A 1999 BMW Z3. THE CONTACT STATED THAT THE VEHICLE WAS INCREASINGLY HARD TO CONTROL AND THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR AN ALIGNMENT. THE MECHANIC ADVISED THE CONTACT THAT THE REAR DIFFERENTIAL HAD FAILED AND WAS CAUSING THE WHEELS TO FRACTURE FROM THE SUB FRAME. THE MECHANIC ALSO ADVISED THE CONTACT OF THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 99V272000 (POWER TRAIN: DRIVELINE: DIFFERENTIAL UNIT). THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS ADVISED TO HAVE THE VEHICLE TOWED TO THE DEALER. THE VEHICLE WAS TOWED AND THE CONTACT WAS AWAITING DIAGNOSIS AND REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 105,000.

NHTSA ID

10378668

Incident

Jan 16, 2011

Mileage

105,000 mi

MY 1999 BMW Z3 ROADSTER BEGAN DRIVING FUNNY AND MAKING SQUEAKING NOISES, IN THE REAR. THEN I NOTICED THE BACK TIRES, WERE STARTING TO KICK OUT AND LOOK STRANGE. THEN MY CAR BEGAN MAKING A BAD VIBRATING SOUND, COMING FROM THE BACK TIRES, WHEN I WAS IN FIRST GEAR. I TOOK IT TO SHOP. THEY JACKED IT UP, AND FOUND, THAT THE DIFFERENTIAL UNIT, HAS SEPARATED FROM THE SUB-FRAME. *TR

NHTSA ID

10378233

Incident

Jan 17, 2011

Mileage

105,341 mi

1999 BMW Z M ROADSTER REAR GEARBOX(DIFF) TEARING FROM CAR. ALL WELDS ARE BROKEN AND SUPPORT IS TORN IN HALF IN PLACES AND CRACKED. *TR

NHTSA ID

10340816

Incident

Jan 1, 2009

Mileage

91,318 mi

AIR BAG LIGHT ON. SHOP MECHANIC STATED "RETRIEVED DTC CODE FOR DRIVERS SEAT BELT SWITCH OPEN OR SHORT CIRCUIT. CLEANED CONNECTORS, CLEARED DTC INFO OPERATIONAL CHECK OK. IF FAULT RECURS, RECOMMEND REPLACEMENT OF DRIVERS SEAT BELT LATCH ASSEMBLY." PROBLEM FIXED JUNE 18, 2008. NOW PROBLEM WITH AIR BAG LIGHT ON IS BACK. THERE SEEM TO BE A LOT OF PROBLEMS WITH AIR BAG SENSORS AND SEAT BELT LATCHES ON VARIOUS BSM VEHICLES ACCORDING TO INTERNET SEARCHES. *TR

NHTSA ID

10310014

Incident

Feb 12, 2010

Mileage

82,000 mi

I NOTICED A SQUEAKING NOISE COMING FROM THE BACK OF MY 1999 BMW Z3 COUPE. WHEN I HAD IT CHECKED I FOUND IT WAS A SMALL CRACK WHERE THE SUBFRAME HAD BEEN FACTORY REINFORCED. THE REINFORCEMENTS WERE FAILING IN THE BACK OF THE CAR NEAR THE TRUNK FLOORING AND THE SWAYBAR. THE MECHANIC STATED IT WOULD COST $6500 TO REPLACE THE CRACKING FRAME, OR I COULD GO TO ANOTHER SHOP AND HAVE IT SPOT WELDED TO REINFORCE AND STOP THE CRACK FROM GETTING LARGER. *TR

NHTSA ID

10209219

Incident

Nov 16, 2007

Mileage

111,000 mi

1999 Z3 M COUPE DIFFERENTIAL MOUNT TRUNK FLOOR SUPPORT FAILURE. I TOOK IN MY CAR FOR MY 90 THOUSAND MILE SERVICE AND WAS INFORMED BY THE SHOP (WWW.THEMSHOP.COM) LOCATED IN GLENDALE, CA. THAT MY SUBFLOOR WAS CRACKED AND UNLESS I FIXED IT MY CAR WOULD BE USELESS, AND NOT DRIVABLE. I HAD TO SPEND OVER $2,800 TO FIX MY CAR WHICH IS VERY DISAPPOINTING ESPECIALLY SINCE THIS IS A WEEKEND CAR NOW AND WHEN YOU PAY $46,000 FOR A BMW YOU DO NOT EXPECT THE FRAME TO FAIL.... *TR

NHTSA ID

10188514

Incident

Apr 1, 2007

Mileage

84,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH DURING CLEAR CONDITIONS, THE FRONT DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT TO THE VEHICLE. THERE WAS NO DEBRIS OR POTHOLES PRESENT. THE CONTACT SUFFERED CUTS, BRUISING AND SCARING TO THE LEFT ARM. THE CONTACT DROVE TO THE HOSPITAL. THE SERVICE DEALER AND MANUFACTURER WERE NOTIFIED AND PHOTOS WERE TAKEN OF THE VEHICLE AND INJURIES. UPDATED 11/16/2006 -THE GAS GAUGE AND ODOMETER WERE INOPERATIVE. THE DEALER REPLACED THE INSTRUMENT CLUSTER. THE DRIVER'S DOOR GRAB HANDLE WAS REPLACED. THE REAR SHOCKS AND MOUNTS WERE REPLACED. THERE WAS A POWER STEERING LEAK. THE DEALER REPLACED THE POWER STEERING HOSE RES TO PUMP. THE DEALER REPLACED THE FLEX COUPLER ON THE DRIVE SHAFT. *NM

NHTSA ID

10171793

Incident

Sep 6, 2006

Mileage

87,950 mi

I PURCHASED MY CAR FROM ROSE IMPORTS IN VALLEJO, CA. ON 08-22-2006. APPROXIMATELY 1 MONTH LATER, I STARTED TO HEAR A NOISE FROM THE REAR. I WOULD HEAR IT OCCASIONALLY. ON 10-10-2006, I WAS DRIVING HOME ON I-80 AND AS I WAS DRIVING, SUDDENLY I HEAR A LOUD "POP". I PULL OVER AND DID A VISUAL CHECK BUT FOUND NOTHING I COULD SEE SO I CONTINUED TO DRIVE HOME AND HEARD METAL SOUNDS COMING FROM THE BACK. THE NEXT DAY WHILE DRIVING TO WORK, I CONTINUED TO HEAR THE SOUND AND WHEN I RETURNED HOME, ME AND A FRIEND LIFTED THE CAR AND THAT'S WHEN I DISCOVERED THE SNAP OR BREAK IN THE DIFFERENTIAL SUPPORT BRACKET. IT HAS COMPLETELY SEPARATED FROM THE DIFFERENTIAL. THE DEALER WHERE I PURCHASED THE CAR TOLD ME GOOD LUCK. THEY'RE NOT GOING TO DO ANYTHING SINCE IT PASSED THEIR SAFETY INSPECTION. I CALLED MY LOCAL BMW DEALER AND SPOKE TO THE SERVICE DEPT. AND THEY TOLD ME IT WAS NOTHING THEY CAN OR WILL DO BECAUSE IT'S 86K MILES AND OUT OF WARRANTY. NOW I'M STUCK WITH A CAR I JUST PURCHASED AND HAVE A MAJOR BILL 2 MONTHS LATER. *NM

NHTSA ID

10170795

Incident

Oct 10, 2006

Mileage

86,410 mi

I AM THE THIRD OWNER OF THIS CAR, IT WAS ALWAYS GARAGED AND USED AS A WEEKEND PLEASURE VEHICLE. CLEAN CARFAX, NEVER RACED, WHAT I THOUGHT WAS A GOOD PURCHASE. TWO SPOT WELDS IN THE TRUNK WERE NOT ACTUALLY HOLDING ANYTHING TOGETHER (ROBOT ERROR) AND THERE WAS A SMALL CRACK ON MY DIFFERENTIAL MOUNT. I PURCHASED A REINFORCEMENT KIT AND INSTALL FROM SPORTS CAR LLC, WHICH INCLUDES A NEW MOUNT (DUAL EAR FROM AN E36 M3) AND SEVERAL REINFORCING BRACKETS BEING WELDED INTO THE TRUNK AREA. THIS COST ME SEVERAL THOUSAND DOLLARS JUST TO ENSURE MY PERSONAL SAFETY AND KEEP MY CAR AT THE SAME TIME. *NM

NHTSA ID

10141850

Incident

Oct 31, 2005

Mileage

50,000 mi

THE WELDS CONNECTING THE SUBFRAME TO THE FLOOR ON THE UNDERSIDE OF THE REAR OF THE CAR HAVE BEGUN TO FAIL. THIS WAS FOUND AFTER THE AREA BEGAN TO MAKE NOISES WHEN SHIFTING THE CAR OR GOING OVER BUMPS.

NHTSA ID

10133930

Incident

Aug 20, 2005

THE VEHICLE WAS PARKED WHEN THE DRIVER NOTICED THAT THE DIFFERENTIAL WAS HANGING FROM UNDERNEATH THE VEHICLE. THE DRIVER HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE REAR TRUNK SUB FRAME NEEDED REPLACEMENT AND WELDING. *NM *SC

NHTSA ID

10107383

Incident

Jan 13, 2005

Mileage

115,000 mi

I OWN A 1999 BMW Z3 2.3 ROADSTER. THE DIFFERENTIAL MOUNT HAS TORN AWAY FROM THE UNDERBODY OF THE CAR WHERE IT WAS WELDED WHEN DESIGNED. THIS IS THE THIRD COMPLAINT ABOUT THIS PARTICULAR DEFECT ON THIS WEBSITE BUT THERE ARE SEVERAL MORE ON BIMMERFEST.COM. BMW NA SHOULD BE MADE AWARE OF THIS DESIGN FLAW AND FORCED TO DO A RECALL ON ALL CARS THEY MADE WITH THIS FLAW. I WILL SEEK ALL NECESSARY LEGAL ACTION TO HOLD THEM ACCOUNTABLE. YOU DON'T PAY $40,000 FOR A CAR THEY CLAIM AS THE BEST CAR ON THE ROAD TO HAVE A MAJOR SAFETY ISSUE LIKE THIS EXIST. *AK

NHTSA ID

10100977

Incident

Dec 1, 2004

Mileage

118,000 mi

THE CONSUMER NOTICED THE PASSENGER FRONT SEAT ROCKED BACK AND FORTH. HE TOOK THE VEHICLE TO THE DEALER AND WAS TOLD IT WOULD COST HIM. NOW THE DRIVERS SEAT HAS THE SAME DEFECT, HE TOOK IT BACK TO THE DEALER AND WAS TOLD THAT THE MANUFACTURER CAME OUT WITH A RETRO KIT AND THERE WOULD BE A CHARGE FOR THAT. THE MANUFACTURER HAS DENIED HIS CLAIM FOR ANY ASSISTANCE. *JB (SEAT RAIL PROBLEM) *SC *JB

NHTSA ID

10083462

Incident

Jul 21, 2004

Mileage

34,000 mi

I HAVE 1999 BMW Z3 HATCHBACK "COUPE" , AFTER GETTING A LOUD SHUTER IN THE REAR OF MY CAR, I INVESTIGATED THE AREA AND FOUND THAT MY BODY IS TEARING AWAY FROM THE FRAME OF THE CAR IN THE DRIVERS REAR SIDE OF THE CAR. ALSO THE SINGLE REAR DIFFERENTIAL MOUNT ALSO HAS A TEAR INTHE METAL THAT EEQUALS TO ONE AND HALF INCH ON THE MOUNT CONSISTING THAT 33% OF THE MOUNT HAS FAILED AND IS GETTING WORSE. ALSO THE TEARING FROTHE INTERIOR IS ALL THE WAS THOUGH THE CAR ALLOWING EXAUST FUMES INTO THE CABIN OF THE CAR. *AK

NHTSA ID

10075106

Incident

May 1, 2004

Mileage

49,000 mi