2011 BMW Z4

ON 3 APRIL 2026 I WAS DRIVING MY 2011 BMW Z4 SDRIVE 30I E89 N52K (MANUAL TRANSMISSION) THAT HAS 31,000 MILES ON IT, SUDDENLY A STEERING ASSISTANCE MALFUNCTION TROUBLE LIGHT APPEARED AND I LOST ALL ELECTRONIC POWER STEERING. THIS SUDDEN LOSS OF STEERING CONTROL ALMOST CAUSED AN ACCIDENT!! THEN SHORTLY THEREAFTER THE ELECTRONIC POWER STEERING CONTROL RETURNED. ON APRIL 4 I LOST THE STEERING CONTROL AGAIN AND TOOK IT TO A BMW REPAIR SHOP. THEY CONFIRMED THAT THE PROBLEM WAS WITH THE EPS (ELECTRIC POWER STEERING CONTROL). UPON INVESTIGATION, A SPECIFIC RECALL EXISTS FOR 2012 BMW Z4 REGARDING THE ELECTRIC POWER STEERING (EPS) SYSTEM. (NHTSA RECALL CAMPAIGN #12V302000: ELECTRIC POWER STEERING CONTROL MODULE.) THE RECALL CAMPAIGN NOTES THAT, AFTER THE ENGINE IS SHUT OFF AND THEN RESTARTED, THE EPS MODULE MAY FUNCTION PROPERLY. IN THAT CASE, THE WARNING SYMBOL IN THE INSTRUMENT CLUSTER WILL NO LONGER APPEAR, AND THE AUDIBLE WARNING WILL NOT ACTIVATE. HOWEVER THE CONDITION MAY OCCUR AGAIN. THIS IS EXACTLY WHAT IS OCCURRING WITH MY CAR AND YOU NEVER KNOW WHEN IT WILL OCCUR. THE CAMPAIGN COVERS 2012 Z4'S AND COVERED SOME CARS MANUFACTURED IN LATE 2011. HOWEVER, THE VIN FOR MY 2011 BMW Z4 SDRIVE 30I E89 N52K (MANUAL TRANSMISSION) IS WBALM5C58BE162421 AND IT WAS MANUFACTURED IN 04/2010. THE EPS IN MY 2011 BMW Z4 IS EXACTLY THE SAME AS THE EPS THAT IS COVERED IN THE NHTSA RECALL CAMPAIGN #12V302000: ELECTRIC POWER STEERING CONTROL MODULE.) CLEARLY MY 2011 BMW Z4 SHOULD BE INCLUDED IN THIS CAMPAIGN WHICH REQUIRES A 4 HR REPAIR BY A CERTIFIED BMW DEALER AND REPLACEMENT OF THE EPS UNIT. FOR Z4 MODELS THE TECHNICIANS ARE TO REFER TO REPAIR INSTRUCTION 32 13 370, "REMOVING AND INSTALLING (REPLACING) ELECTRIC STEERING BOX (EPS)." E89 STEERING GEAR PART # 32 10 6 855 888. PLUS FOLLOWING PARTS: ASA BOLT (#32 10 6 773 068); HEX NUT (#33 32 6 768 884); TORX BOLT (#32 30 6 778 609); COMBINATION NUT (#33 30 6 787 062). ALL ABOVE REFERENCED PARTS WERE LISTED IN THE RECALL CAMPAIGN. !

NHTSA ID

11729687

Incident

Apr 2, 2026

Electrical power steering system failed, warning light came on. Vehicle suddenly became very difficult to impossible to steer. Failed to negotiate a turn and nearly hit a tree. I have an appointment set with an independent service dealer near me, but I’m afraid to drive it there, so I may have it towed. The warning light came on just moments before the initial failure.

NHTSA ID

11658036

Incident

Apr 24, 2025

Steering assist failed almost resulting in head on collision. Failure is serious and likely to cause fatalities

NHTSA ID

11650357

Incident

Mar 24, 2025

Power steering is intermittent where assist goes from working to not working changing the effort required to turn the wheel. When power assist goes off it is difficult to steer the car.

NHTSA ID

11621433

Incident

Aug 2, 2024

October, 9, 2024 BMW USA Customer Relations, Recall Services Ms. Ikevia, Thank you following up. My 2021 claim regarding the 2011 BMW Z4 Vanos Bolts recall has been pending since April, 2021. My Z4 almost destroyed itself, after having been left off your recall list. December, 2023 BMW USA provided me written notice my VIN had been added to the recall list so I will be reimbursed for the costly repair. I hope you will help your colleagues who are stonewalling to appreciate my patience as well as my willingness to fight for reimbursement for as long as it takes You do have all my information in your Vanos Bolts Recall file, including detailed photos from my Syncro Car Care professionals who did the repair when you declined to help me. My VIN which is: [XXX] - 2011 Z4 3.0 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11618865

Incident

Apr 15, 2021

Electric power assist intermittently fails without warning making steering impossible. Similar to 2012 z4 recall

NHTSA ID

11607157

Incident

Aug 1, 2024

I have written to you previously to advise of repeated engine issues with my vehicle, a 2011 BMW Z4. I also included invoices of work that was done over time to correct a likely Engineering flaw that caused excessive fuel injector failure. In 2021, there was a 10 year extended warranty to replace them. Prior and after the warranty work, there was almost constant engine misfires and engine warning lights resulting in decreased engine performance, and low oil lights that came on every 300+ miles driven. My recent issue with the car involves a starter quitting while driving at 70mph on [XXX]. It was terrifying. It's impossible to put into words that death was imminent. On [XXX], we were traveling to Orangeburg, SC when the car suddenly "died" on the highway. Once we recovered from our shock, we had the vehicle towed to a local shop. The owner advised us that it needed a new starter. Once that was replaced, the car started with a severe screeching noise. After further assessment, it was determined that there was a bent piston rod and that the engine would have rebuilt or replaced. I, a former automotive Engineer, believe that there was an inherent design flaw that caused the car to excessively use oil. Interestingly, I purchased a new BMW and as a condition of sale, was required to sign a document that I would not sue BMW or participate in a class action lawsuit. I was not provided with a copy of the form that was signed, but doubt that it would be upheld in court. BMW needs to be held accountable for their products and their performance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11599556

Incident

Jun 27, 2024

The contact owns a 2011 BMW Z4. The contact stated while driving at 55 MPH, the vehicle stalled. The vehicle was difficult to restart. The check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

NHTSA ID

11593843

Incident

May 6, 2023

Mileage

30,000 mi

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

While performing a 12-Volt battery jump start, disconnect, or replacement, Vehicle test, and/or Programming procedure- the BMW Footwell Module (FRM) may become unresponsive. As a result, one or more of the following vehicle electric system-related issues may occur: Headlights including the high beams, and/or taillights are not turning on or off Interior lights are not turning on Turn indicators are not working Instrument cluster indicator lights stay on The IHKA climate control system is not working Power windows are not working Folding mirrors are not working, and/or a Functional remote-control key FOB will not unlock and lock the doors

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 240,000 miles as determined from the original first in-service / delivery date.

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.