RoadVitals

2004 Buell XB9S

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Feb 21, 2007
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Dec 2, 2003
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2004 Buell XB9S, most frequently naming the exterior lighting category. 1 safety recall has been issued covering this model year; and 1 manufacturer communication is on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Exterior lighting1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
03V494000

ELECTRICAL SYSTEM:HORN

Dec 2, 2003
581 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, THE WIRE THAT PROVIDES POWER TO THE HORN, DUE TO MISROUTING, CAN BECOME FRAYED FROM CONTACT WITH THE HORN BRACKET MOUNTING BOLT. AS A RESULT, THE HORN WIRE MAY BECOME EXPOSED, AND WHEN THE HORN BUTTON IS PUSHED, EITHER THE HORN CIRCUIT FUSE OR THE KEY SWITCH FUSE CAN BLOW.
The risk: IF THE KEY SWITCH FUSE BLOWS, THE VEHICLE CAN STALL, WHICH COULD RESULT IN A CRASH. IF THE HORN FUSE BLOWS, THERE WILL BE A LOSS OF POWER TO THE HORN AND REAR BRAKE LIGHT.
The remedy: DEALERS WILL INSPECT AND CORRECT THE WIRE ROUTING, IF NECESSARY. OWNER NOTIFICATION BEGAN ON DECEMBER 23, 2003. OWNERS SHOULD CONTACT BUELL AT 1-414-342-4680.
BUELL MOTORCYCLE CO.Manufacturer number 0828View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Exterior lighting
Filed Feb 21, 2007

HEADLIGHT ON MY BUELL FIREBOLT XB12R IS DANGEROUSLY DIM. THE REFLECTIVE COATING ON THE INSIDE OF THE HEADLAMP HAS DETERIORATED TO THE POINT WHERE I CANNOT SEE AT NIGHT. I HAVE REPLACE THE HOUSING ONCE AND MY NEW HOUSING HAS THE SAME ISSUE AFTER LESS THAN A YEAR OF USE. *NM

NHTSA ID
10183170
Incident
Feb 21, 2007
Mileage
5,400 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

B-087

ENGINE AND ENGINE COOLING:ENGINE

BUELL MOTORCYCLE: THE ENGINE OIL DRAIN PLUG TORQUE HAS CHANGED TO 26-29 FT LBS (35.3-39.3NM) FOR ALL MODELS LISTED. *PE

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.