2006 Buick Rainier Problems

In driving cross country, filled up the fuel tank and resumed travel when the fuel gauge immediately went to empty (I didn’t even have time to drive up the highway ramp back onto the highway). The alerts started ringing and blinking and dash board told me there was no fuel. I went to a gravel area and inspected the engine compartment, under the car and the interior to be sure I was not missing anything, then restarted the SUV. Could not find any issues anywhere, including leaking fuel. I took off the fuel cap and reattached it to be sure there was no problem there. I had no choice but to get on the highway and continue my journey. The problem continued for the following 1000 ish miles. When I got home I contacted my dealer and set up an appointment to look at vehicle. They found the vehicle needing a sensor kit which was a recall back a few years ago. I had the issue repaired which took 3 days. They may have the removed items. Attached please find the invoice from the repair that shows the message numbers, etc from the inspection prior to and during repair. Since this issue was a recall, but I understand not for my vehicle but for many similar SUV’s and Pickups of the same area of manufacture; I feel the same components were used in my vehicle and should be paid for and included in this recall. Attached please find the invoice if I can figure out how to get it attached to this type of format.

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. WHILE DRIVING 40 MPH, THE VEHICLE JERKED VIOLENTLY WITHOUT WARNING. IN ADDITION, THE POWER WINDOWS WERE JAMMED AND WOULD NOT WIND UP OR DOWN. THE CONTACT STATED THAT THE VEHICLE ALSO LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 105,000.

The contact owns a 2006 Buick Rainier. The contact stated that while the vehicle was parked in his driveway, the contact attempted to use the remote starter key fob to unlock the doors, but the doors failed to unlock. The contact stated that he manually unlocked the doors. The contact stated that he manually attempted to start the vehicle, but the vehicle failed to start. The anti-theft warning light remained illuminated. The contact stated that while the vehicle was being lifted onto the tow truck, he was informed by the tow truck driver that the driver’s side wiring harness had melted. The vehicle was towed to an independent mechanic where it was diagnosed that the wiring harness had melted and needed to be replaced. The vehicle was not repaired. The dealer nor manufacturer were notified of the failure. The failure mileage was approximately 168,000.

Low beam lights go off intermittently while driving and eventually come back on. This does not affect high beams or any other lights on the vehicle. But causes a serious danger to my needing to drive at night due to my job.

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS FAILED TO ILLUMINATE. THE CONTACT CALLED LUTHER BROOKDALE (6701 BROOKLYN BLVD, BROOKLYN CENTER, MN 55429, PHONE NUMBER: (763) 515-2412) AND WAS INFORMED THAT THE PART NEEDED FOR THE REPAIR WOULD BE AVAILABLE IN SIX TO EIGHT WEEKS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V519000 (EXTERIOR LIGHTING) AND 14V404000 (VISIBILITY); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 178,000. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE LOW BEAM HEADLIGHTS FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE HIGH BEAM LIGHTS WERE ACTIVATED IN ORDER TO VIEW THE ROAD. THE CONTACT ALSO STATED THAT THE CONTACT POINTS FOR THE HEADLIGHT MODULE MELTED INTO THE FUSE BOX AND ALSO DAMAGED SOME OF THE FUSES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V519000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 139,607. ....UPDATED 0711/16 *BF *TR

During periods of time with ignition switch on, the wipers will loose the ability to both regulate speed and shut off. The wiper cover AC Delco/GM part number 19120931 will fail and loose control of the wipers (fail to shut off while driving). Because you cannot shut off the wipers, the driver's vision is obscured, and the noise from the wipers on the dry glass is very distracting. This will cause drivers attention to shift from focus on driving to manipulating the wiper switch. GM has not ordered a stock or replacement wiper covers from AC Delco, so trying to locate a fix for this problem is very hard. This is a GM design problem and is very expensive to fix. As a minimum GM needs to stock this part. All of these wiper covers will fail eventually, and accidents from this problem will occur.

BUICK RAINIER 2006: WINDSHIELD WIPERS AND FLUID COME ON BY THEMSELVES. WHEN THIS OCCURS, THE ON / OFF FUNCTION DOES NOT WORK. THEY CANNOT BE SHUT OFF BY CONTROLS. THEY MERELY START AND STOP AT RANDOM. IT HAPPENS BOTH ON VEHICLE START UP WHEN VEHICLE IS IN PARK AND WHILE DRIVING. IT IS VERY DIFFICULT TO SEE TO DRIVE.

WE BOUGHT A BUICK RAINIER 2006 AND IT HAS HAD NOTHING BUT ELECTRICAL, DOOR PROBLEMS AND DOOR HANDLE PROBLEMS. IT HAS A FAULTY BACK WINDOW WIPER. SUSPENSION ISSUES AND A VOTING UNDER BODY CARRIAGE. I BOUGHT IT FROM A DEALER AND NONE OF THESE RECALL ISSUES WHERE TAKEN CARE OF, AND THESE RECALLS DATE BACK TO 2015 I BOUGHT THE RAINER IN MARCH 2018. *TR

REAR OF CAR DROPS TO JUST ABOVE TIRES WHEN CAR SITS FOR A FEW HOURS. AIR SUSPENSION PUMPS IT BACK UP AFTER CAR IS STARTED. AIR SUSPENSION IS LEAKING....UNSAFE TO DRIVE.CAR HAS 94000 MILES

WE BOUGHT A BUICK RAINIER 2006 AND IT HAS HAD NOTHING BUT ELECTRICAL, DOOR PROBLEMS AND DOOR HANDLE PROBLEMS. IT HAS A FAULTY BACK WINDOW WIPER. SUSPENSION ISSUES AND A VOTING UNDER BODY CARRIAGE. I BOUGHT IT FROM A DEALER AND NONE OF THESE RECALL ISSUES WHERE TAKEN CARE OF, AND THESE RECALLS DATE BACK TO 2015 I BOUGHT THE RAINER IN MARCH 2018. *TR

I HAD INVOLVED CAR ACCIDENT WHICH FROM THEY CALLED THROTTLEBODY DUE TO (TPS...SHIFT BY WIRE) YOU CAN FIND IN ASK.COM ENCYCLOPEDIA *(SEE BOTTOM) THAT I EXPERIENCED WHICH I HAD. IT WAS RUNNING IN REVERSE AND HIT STEEL POST THAT PROTECT GAS METER WHILE I TRIED BRAKE BUT ENGINE AND TRANNY WAS IN FULL IDLE AND I TRIED CHANGE TO INTO DRIVE WHILE IT STILL IN FULL IDLE AND MY BRAKE CANT STOP UNTIL I HIT EMERGENCY BRAKE AND TURN ENGINE OFF BY KEY SWITCH. I DID SOME RESEARCH AND FOUND I'M NOT ALONE AND MY INSURANCE (NATIONAL GENERAL WHICH USED BE GMAC) PUSHED MY CAR INTO TOTALED THAT THEY USED BY NEVADA LAW AND BODY SHOP TRYING TO SEND THIS CAR TO DEALER FOR TESTING BUT NEVER HAPPEN CUZ OF TOTALED PROCESSING. WHICH LEAVE ME PUZZLED AND FOUND OUT THAT MY CAR SOLD TO BODY SHOP AND REPAIRED AND SOLD OTHER PEOPLE. MY WORRY IS IF THEY NOT TESTING THROTTLE AND OTHER PEOPLE WHO BOUGHT THIS CAR MAY FACE RISK WHICH I HAD. *DISADVANTAGES THE COST OF DBW SYSTEMS IS OFTEN GREATER THAN CONVENTIONAL SYSTEMS.THAT FALL UNDER THE CATEGORY OF SAFETY CRITICAL SYSTEMSWHICH ARE RECOMMENDED TO BE DEVELOPED UNDER STANDARDS LIKE ISO 26262 WHICH REQUIRE EXTENSIVE CHANGES IN THE DEVELOPMENT PROCESS GENERALLY TAKEN FOR DEVELOPING OTHER TRADITIONAL SYSTEMS.. *TR

JUST PURCHASED CAR 3 WEEKS AGO, IT CAUGHT ON FIRE AT 3 AM AFTER BEING PARKED FOR 6 HOURS.FIRE DEPARTMENT SAYS IT STARTED AT THE DRIVER SIDE HEADLIGHT WIRING OR SWITCH AREA. COMPLETELY DESTROYED MY ENGINE BEFORE FIRE DEPARTMENT ARRIVED.

BUICK RAINIER 2006, [XXX], I HAVE HAD TROUBLE WITH MY SUV TURNING OFF WHILE DRIVING MANY TIMES. ALSO, IT WILL NOT START AFTER SEVERAL ATTEMPTS UNTIL IT JUST WANTS TO. NOW, IT HAS COMPLETELY STOPPED STARTING AND IS SITTING IN A PARKING LOT AFTER TRYING TO START OVER 5 HOURS, I AM SO UPSET AND STRANDED. MY VIN DOES NOT APPEAR ON RECALL LIST FOR SWITCH, BUT THAT IS THE TROUBLE I AM HAVING. WHAT DO I DO NOW? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I HAD INVOLVED CAR ACCIDENT WHICH FROM THEY CALLED THROTTLEBODY DUE TO (TPS...SHIFT BY WIRE) YOU CAN FIND IN ASK.COM ENCYCLOPEDIA *(SEE BOTTOM) THAT I EXPERIENCED WHICH I HAD. IT WAS RUNNING IN REVERSE AND HIT STEEL POST THAT PROTECT GAS METER WHILE I TRIED BRAKE BUT ENGINE AND TRANNY WAS IN FULL IDLE AND I TRIED CHANGE TO INTO DRIVE WHILE IT STILL IN FULL IDLE AND MY BRAKE CANT STOP UNTIL I HIT EMERGENCY BRAKE AND TURN ENGINE OFF BY KEY SWITCH. I DID SOME RESEARCH AND FOUND I'M NOT ALONE AND MY INSURANCE (NATIONAL GENERAL WHICH USED BE GMAC) PUSHED MY CAR INTO TOTALED THAT THEY USED BY NEVADA LAW AND BODY SHOP TRYING TO SEND THIS CAR TO DEALER FOR TESTING BUT NEVER HAPPEN CUZ OF TOTALED PROCESSING. WHICH LEAVE ME PUZZLED AND FOUND OUT THAT MY CAR SOLD TO BODY SHOP AND REPAIRED AND SOLD OTHER PEOPLE. MY WORRY IS IF THEY NOT TESTING THROTTLE AND OTHER PEOPLE WHO BOUGHT THIS CAR MAY FACE RISK WHICH I HAD. *DISADVANTAGES THE COST OF DBW SYSTEMS IS OFTEN GREATER THAN CONVENTIONAL SYSTEMS.THAT FALL UNDER THE CATEGORY OF SAFETY CRITICAL SYSTEMSWHICH ARE RECOMMENDED TO BE DEVELOPED UNDER STANDARDS LIKE ISO 26262 WHICH REQUIRE EXTENSIVE CHANGES IN THE DEVELOPMENT PROCESS GENERALLY TAKEN FOR DEVELOPING OTHER TRADITIONAL SYSTEMS.. *TR

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE AIR CONDITIONER FAILED TO OPERATE. ADDITIONALLY, THE TRANSMISSION EMITTED A LOUD WHINING NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BLOWER MOTOR RESISTER WAS REPLACED. THE FAILURE RECURRED AFTER THE REPAIR WAS PERFORMED. THE VEHICLE HAD NOT BEEN REPAIRED FOR MOST RECENT FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

TL* THE CONTACT OWNED A 2006 BUICK RAINIER. WHILE DRIVING APPROXIMATELY 55 MPH, THERE WERE SMOKE AND FLAMES UNDERNEATH THE DASHBOARD. THE DRIVER EXITED THE VEHICLE QUICKLY BEFORE IT WAS ENGULFED IN FLAMES. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE FAILURE MILEAGE WAS 96,482.

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. THE CONTACT STATED THAT THE EXTERIOR DRIVER LATCH BECAME LOOSE AND THE DRIVER'S SIDE DOOR LATCH WOULD NOT OPEN. THE CONTACT TOOK HER VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND THE STATED THE DOOR LATCH WOULD NEED TO BE REPLACED AND REPAINTED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED TWO ADDITIONAL TIMES. WHENEVER THE FAILURE OCCURRED THE DEALER REPAIRED THE DOOR LATCH HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE IDENTICAL FAILURE OCCURRED WITH THE REAR PASSENGER SIDE EXTERIOR LATCH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. UPDATED 9/*CN/ UPDATED 09/10/2014*JS

TL* THE CONTACT OWNS A 2006 BUICK RAINIER. AFTER PARKING THE VEHICLE, THE FRONT DRIVER SIDE EXTERIOR DOOR HANDLE FRACTURED. THE CONTACT HAD TO ENTER THE VEHICLE THROUGH THE PASSENGER DOOR. THE VEHICLE WAS TAKEN TO A DEALER AND THE HANDLE WAS REPAIRED, BUT THE FAILURE RECURRED FIVE TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

JUST PURCHASED CAR 3 WEEKS AGO, IT CAUGHT ON FIRE AT 3 AM AFTER BEING PARKED FOR 6 HOURS.FIRE DEPARTMENT SAYS IT STARTED AT THE DRIVER SIDE HEADLIGHT WIRING OR SWITCH AREA. COMPLETELY DESTROYED MY ENGINE BEFORE FIRE DEPARTMENT ARRIVED.

The contact owns a 2006 Buick Rainer. The contact stated that while driving at various speeds, the steering wheel jerked independently without warning, causing the contact to lose control of the vehicle. In addition, the contact stated that there was an abnormal grinding sound coming from the brake pedal while depressing the brake pedal. The contact had taken the vehicle to two independent mechanics, where the wheel bearings and ball joints were replaced; however, the failure persisted. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

THERE IS A SHUDDERING OR RUMBLE COMING FROM THE FRONT WHEELS OF OUR BUICK RAINIER AWD AT LOW SPEEDS WHEN BACKING UP OR MAKING TURNS. WE HAVE TAKEN THE VEHICLE TO THE DEALER ON 2 OCCASIONS BUT THE PROBLEM HAS NOT BEEN CORRECTED. *TT

TAKATA RECALL. MY SERVICE AIRBAG LIGHT IS COMING AND ON AND GOING OFF FOR NO APPARENT REASON. REASON UNKNOWN. THIS IS HAPPENING WHILE THE SUV IS IN MOTION, IN DRIVE, ON HIGHWAYS AND SIDE ROADS TRAVELING ANYWHERE FROM 25MPH TO 65MPH. I AM GRAVELY CONCERNED FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS. I CANNOT RISK ANYTHING HAPPENING, THERE ARE CHILDREN INVOLVED. I WENT TO THE GM RECALL WEBSITE AND ENTERED MY VIN# AND MY PARTICULAR MAKE/MODEL/YEAR IS NOT ON THE RECALL LIST AND I AM REQUESTING THAT IT BE ADDED FOR THOSE OF US WHO OWN THEM. PLEASE RESPOND, I AM VERY CONCERNED.

TAKATA RECALL. "SERVICE AIRBAGS" MESSAGE KEEPS POPPING UP. I AM CONCERNED FOR THE SAFETY OF MYSELF AND PASSENGERS. THIS IS HAPPENING WHILE DRIVING, VEHICLE IN MOTION, IN DRIVE ON THE HIGHWAY AND BACK ROADS. THE MESSAGE COMES ON AND GOES OFF SPORADICALLY FOR NO APPARENT REASON. I CHECKED MY VIN# ON THE GM WEBSITE/RECALL LIST BUT MY PARTICULAR MAKE/MODEL/YEAR IS NOT ON THE RECALL LIST. I HAVE CONCERN FOR THE SAFETY OF MYSELF AND PASSENGERS. THE CAUSE IS UNKNOWN. THE SERVICE AIRBAG MESSAGE HAS BEEN COMING ON FOR THE LAST 2 DAYS.

WE HAVE HAD NUMEROUS ELECTRICAL AND MECHANICAL PROBLEMS. THE FAN MOTOR CONTROL MODULE WHEN OUT,THEN THE MODULE THAT CONTROLS THE FUEL INDICATOR AND DISPLAY WENT BAD. NOW LESS THAN 6 MONTHS LATER THE TRANSMISSION HAS GONE BAD. IT IS ONLY WORKING IN 2 & 3. NO OVERDRIVE OR FIRST. THIS LAST PROBLEM SUDDENLY STARTED ON 7/17/11. OUR MECHANIC CAME AND CHECKED IT OUT (HE DID NOT WANT US TO DRIVE IT) AND SAID THE TRANSMISSION WAS ONLY WORKING IN SECOND AND THIRD AND WE SHOULD NOT DRIVE IT AND NEEDS TO BE REPLACED OR REPAIRED. WE ARE STILL PAYING FOR THIS CAR AND FOR THE LAST REPAIRS ON THIS CAR. I HAVE SEEN SEVERAL COMPLAINTS AND SERVICE BULLETINS ON THIS PROBLEM AND THE PROBLEM WITH THE GAS GAUGE. HAS THERE BEEN ANY RECALLS OR ACKNOWLEDGEMENT OF THESE PROBLEMS BY GM? *KB

POSSIBLE FIRE HAZARD AND ACCIDENT DUE TO OIL COOLER LINE CORRODING OUT. NORMAL DRIVING. REPAIR AND REPLACEMENT OF OIL LINES. THIS WAS ONLY BY SHEAR LUCK THAT THIS WAS NOT A SERIOUS ACCIDENT OR FIRE WITH INJURIES OR DEATH. *TR

WE OWN A 2006 BUICK RAINIER. THE CONTACT RECEIVED A RECALL NOTICED FOR NHTSA CAMPAIGN ID NUMBER: 12V406000 (VISIBILITY: POWER WINDOW DEVICES AND CONTROLS). THE CONTACT STATED THAT THE RECALL HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIRED. THE CONTACT STATED THAT THE REPAIRS NEEDED TO BE DONE AS SOON AS POSSIBLE SINCE THE DRIVER DOOR FAILED TO UNLOCKED ELECTRONICALLY OR MANUALLY. THE APPROXIMATE FAILURE MILEAGE WAS 63,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 47,829 WITH IN 9DAYS OF REPAIR DRIVERS SIDE DOOR WOULD NOT OPEN.. CALLED GM AND DEALER BUT IT SEEMS NO ONE THINKS IT HAS ANYTHING TO DO WITH REPAIR. WORK\ED FINE UNTIL REPAIR AN AUTO HAS LITTLE MILEAGE. THEY BLAMED IT ON LIVING NEAR THE BEACH, I DON'T. OWNER OF DEALERSHIP CALL STATED HE WOULD TAKE CARE OF PAYING US BACK BUT IT HAS BEEN WELL WITHIN A TIME TO MAIL A CHECK. GM KEEPS CALLING TO SEE IF DEALER PAID. IT IS FUNNY A DOOR WORKS GREAT PRIOR THEN CAN NOT OPEN 9 DAYS AFTER RETURN. HAD SIMILAR PROBLEM WITH TIRES, AUTO SERVICED EVERY 3,000 MILES BY DEALER WE PURCHASED AUTO AND TIRES WORN DOWN WITHIN LESS THEN 28,000 AND THEY STATED TIRES ARE NOT COVERED BY WARRANTY. YOU PROTECTS THE DISABLED AND SENIORS? NOBODY BECAUSE THEY THINK WE CAN AFFORD THESES COST. WE CAN'T. *TR

The contact owns a 2006 Buick Rainer. The contact stated that while driving at various speeds, the steering wheel jerked independently without warning, causing the contact to lose control of the vehicle. In addition, the contact stated that there was an abnormal grinding sound coming from the brake pedal while depressing the brake pedal. The contact had taken the vehicle to two independent mechanics, where the wheel bearings and ball joints were replaced; however, the failure persisted. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.