2013 Can-Am Spyder RT Interior & seats Problems

WHILE RIDING ON THE HIGHWAY IN MOTION, DURING A CLEAR DAY ON JULY 16 2016. THE SUBJECT VEHICLE SUFFERED A BLOWN REAR TIRE LEAVING A LARGE CENTER STRIP OF BLENDED STEEL AND RUBBER SHAPED AS A WIDE BELT THAT EXTENDED PAST THE REAR OF THE BIKE. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT P). WHILE ATTEMPTING TO BRING THE BIKE TO A SAFE HALT TO THE SIDE OF THE HIGHWAY, THE ROTATION OF THE WHEEL USING THE STATED BELT BEAT THE PLASTIC REAR END OF THE VEHICLE TO A TOTAL DISMEMBERMENT OF CRUCIAL PARTS. WITH THE REAR END OF THE VEHICLE BEING RIPPED AWAY FROM THE VEHICLE, THE ATTACHED PASSENGER'S PLASTIC SEAT MOUNT WAS ALSO DESTROYED. FINELY AS THE VEHICLE WAS BEING BROUGHT DOWN TO A STOP TO THE SIDE OF THE HIGHWAY, SOMEHOW WITH THE VIBRATION OF THE ROTATING BLOW TIRE AND WHEEL, THE RIGHT FRONT WHEEL STABILIZING CAST IRON MECHANISM BROKE DISLODGING THE LOWER BALL JOINT THAT STABILIZED THE HORIZONTAL POSITION OF THE RIGHT FRONT WHEEL. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT K). THIS SENT THE VEHICLE IN A VIOLENT CLOCK WISE SPIN THAT FINELY OVERCAME THE RIDER'S GRIP DISLODGING THE SEAT AND RIDER ON TO THE SIDE OF THE HIGHWAY, AND THEN FINELY COMING TO A COMPLETE STOP FACING THE ONCOMING HIGHWAY TRAFFIC. HOWEVER, AT NO TIME DID THE VEHICLE HIT ANY CAR, CURB, WATER, ICE, TRASH, OR WALL DURING THE RIDE OR DISLODGING OF THE RIDER. NOOR DID IT FLIP OR TURN OVER AT ANY TIME, IN FACT THE VEHICLE DURING ITS REDUCTION IN SPEED, AS WELL AS THE CLOCK WISE SPIN EVER LEAVE THE FINAL LANE THAT THE RIDER WAS DISLODGED FROM THE VEHICLE. PLEASE EXCEPT THIS AS A REPLACEMENT AND UPDATE OF THE REMOVED COMPLAINT 11051430.

NHTSA ID

11074024

Incident

Jul 16, 2017

Mileage

7,900 mi

SEE THE ATTACH NHTSA_COMPLAINT.PDF THE VEHICLE WAS IN MOTION. CAN AM SPYDER SERIAL/VIN # [XXX], MODEL # 000B9DC00. I HAVE PUT THAT I WAS GOING 75 MILES PER HOUR, NOT SURE OF THE NUMBER AS THIS IS A BIKE. MY GOAL IS TO KEEP UP WITH TRAFFIC. HOWEVER THE SPEED LIMIT ON THE HIGHWAY IS 75 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11051430

Incident

Jul 16, 2017

Mileage

7,900 mi

SMELL GAS VAPORS IN THE GARAGE AND HOUSEBAFTER DRIVING IT. SEAT FRONT TOP WHERE IT MEETS THE BODY(STORAGE COMPARTMENT) TO HOT TO TOUCH OR SIT ON WITHOUT A SHEEPSKIN PAD AND STILL VERY UNCOMFORTABLE AND LIKELY DANGEROUS. RIGHT FOOT GETS SO HOT FROM THE MOTOR YOUR CAN'T KEEP YOUR FOOT IN PLACE. HAVE TO WEAR HEAVY BOOTS. HAVE HAD THE RECALL AND ELECTRONIC UPDATES. *TR

NHTSA ID

10651134

Incident

Nov 2, 2013

Mileage

300 mi

I WAS RIDING ON HIGHWAY 291 IN LEES SUMMIT MO TRAVELING AT 65 MPH. THE DAILY TEMP WAS BETWEEN 92 - 95 DEGREES. THE FAN WAS BLOWING THE HOT AIR OUT FROM THE BIKES RADIATOR AREA AND WITH THE BIKE BEING IN MOTION THE HOT AIR WAS BEING ROUTED ONTO MY RIGHT LEG AND I COULD FEEL MY LEG GETTING HOT TO THE POINT THAT I WAS UNABLE TO KEEP MY FOOT ON THE FOOT PEG FOR LONGER THAN 10-15 SECONDS AFTER WHICH, I NEEDED TO KEEP SHIFTING THE LOCATION OF MY FOOT ON THE FOOT PEG. I ALSO NOTICED THAT THE RIGHT SIDE PANELS AND THE AIR COMING FROM UNDER THE SEAT WAS UNCOMFORTABLY HOT. ALSO WHEN REFUELING THE GAS TANK FILLER NECK WAS TOO HOT TO TOUCH. DURING THE FIRST LONG TRIP ON THIS BIKE (WEEKEND OF OCT 25-26) FROM GRAIN VALLEY MO TO EUREKA SPRINGS AR (540 MILES ROUND TRIP). TEMPS WERE IN THE 70'S DURING THE TRIP TO AR AND WHEN REFUELING I NOTICED THAT THE GAS TANK FILLER NECK WAS OVERLY WARM. THE RETURN TRIP, WITH TEMPS IN THE MID 80S, THE HEAT ON MY RIGHT LEG WAS BECOMING UNCOMFORTABLE, THE RIGHT SIDE PANELS WERE HOT AND THE HEAT UNDER THE SEAT WAS OVERLY WARM. REFUELING, THE GAS TANK FILLER NECK WAS ALMOST TOO HOT TO TOUCH. *TR

NHTSA ID

10650717

Incident

Jul 19, 2014

Mileage

3,300 mi

AFTER BUYING MY SPYDER I NOTICED EXCESSIVE HEAT COMING FROM THE ENGINE AREA UNDER MY SEAT. AT TIMES ITS SO HOT THAT I CAN BARELY TOUCH MY GAS CAP WITH IS LOCATED UNDER THE SEAT. THERE HAVE BEEN A FEW TIME THAT AFTER RIDING FOR A EXTENDED PERIOD AND STOPPING THE BIKE I'VE NOTICED THE SMELL OF GASOLINE. I'VE CHECKED FOR FUEL LEAKS AND FOUND NONE, AND CALLED THE DEALERSHIP TO COMPLAIN. THEY TOLD ME THAT IT WAS PROBABLY THE FUEL TANK OVER PRESSURIZING BECAUSE OF THE HEAT AND VENTING TO THE AIR. I WAS ADVISED TO PARK THE BIKE OUT SIDE UNTIL IT COOLED DOWN BEFORE BRINGING IT INTO THE GARAGE. WHILE RIDING THE HEAT COMING UP FROM UNDER THE SEAT IS REALLY BAD, MAKING RIDING NOT MUCH FUN. I'VE CALLED BRP TO COMPLAIN ABOUT THE PROBLEM BUT AS OF YET HEARD ANY THING BACK FROM THEM. I'VE READ THAT SEVERAL SPYDER'S HAVE CAUGHT FIRE, AND STILL NOTHING HAS BEEN DONE. MY FELLOW SPYDER RIDERS HAVE ALL COMPLAINED ABOUT THE HEAT PROBLEM, OTHER THAN THAT THE BIKE IS GREAT. I JUST WANT BRP TO COME UP WITH A SOLUTION TO THE HEAT PROBLEM. *TR

NHTSA ID

10631703

Incident

Aug 11, 2013

Mileage

30 mi

HEAT UNDER THE SEAT IS TO HOT TO RIDE SAFETY. ALWAYS TRYING TO SHIFT AND OPEN LEGS TO TRY AND GET SOME RELIEF. HEAT COMING OFF THE RIGHT SIDE HAS ACTUALLY CAUSED A RED HEAT RASH ON MY RIGHT SHIN FROM MY ANKLE UPWARDS. WHEN REFUELING I AM SO SCARED THAT THE GAS IS GOING TO FLAME UP BECAUSE OF THE FUMES AND THE HEAT RADIATING FROM UNDER THE SEAT WHICH MUST BE LIFTED TO REFUEL. I HAVE TRIED PLACING ALUMINUM FOIL UNDER THE SEAT IN THE HOPES OF DISSIPATING THE HEAT BUT IT HAS NOT WORKED. I STORE MY CAN AM SPYDER IN A TRAILER AND MUST LEAVE ALL THE DOORS OPEN FOR SEVERAL HOURS UNTIL THE FUMES SUBSIDED. I AM AFRAID OF A FIRE AND HAVE MOVED THE TRAILER FAR AWAY FROM MY OTHER VEHICLES AND HOUSE. *TR

NHTSA ID

10631265

Incident

Apr 3, 2014

Mileage

100 mi

HEAT BUILD UP UNDER BODY PANELS AND SEAT AT LOW AND HIGH SPEED, CAUSING BODILY DISCOMFORT, RYDER AND PASSENGER, TO THE POINT OF NEEDING MEDICATION TO THE AFFECTED AREAS COMING IN CONTACT WITH PANELS AND SEAT. GAS CAP HOT-TO-TOUCH, BUILDING UP PRESSURE IN TANK AND CAUSING GAS TO BLOW OUT OF FILLER WHEN REMOVING CAP. ERRATIC GAS FUMES AT ANY TIME. *TR

NHTSA ID

10628215

Incident

Apr 30, 2013

Mileage

600 mi

I FOUND THAT AFTER DRIVING MY MOTORCYCLE THE SEAT IS VERY HOT AND THE GAS CAP IS TOO HOT TO TOUCH. I ALSO HAVE NOTICED EXCESSIVE HEAT ON MY RIGHT LEG THAT GETS VERY UNCOMFORTABLE WITH PROPER RIDING GEAR. THE BIKE HAS HAD NO MODIFICATION DONE TO IT. I LOVE RIDING IT BUT IT MAKES VERY HARD ON HOT DAYS. *TR

NHTSA ID

10622664

Incident

Aug 13, 2014

I WAS OUT FOR A RIDE AND NOTICED THE HEAT ON MY THIGH AND LEG I REPORTED IT TO THE DEALER, AND THEY SAID IT WAS A RECALL ISSUE AND THEY APPLIED A THIN STRIP OF HEAT TAPE UNDER GLOVE BOX. SO ON JUNE 10TH I NOTICED IT WAS GETTING EVEN HOTTER SO I GOT A THERMOSTAT AND PUT IN GLOVE BOX AND RODE OVER TO THE DEALER, A 20 MINUTE RIDE, THE THERMOSTAT REGISTERED 155 THIS AREA WAS SO HOT IT MELTED MY SEAT AND BURN MY THIGH. SO ON JUNE 23RD I LEFT IT AT DEALERS AND BRP INFORMED THEM TO APPLY MORE HEAT TAPE AND REPLACE THE SEAT,WHICH WAS DONE. I PICKED IT UP ON JULY 9 THE AND RODE IT HOME AND GOT BURNED AND IT REGISTERED 150 AFTER A 20 MINUTE RIDE AND THE OUTSIDE TEMP WAS MID 70'S. SEEMS LIKE HEAT LIKE THAT OVER A GAS TANK IS ASKING FOR TROUBLE BEFORE SOMEONE GET BLOWN UP. BRP HAS NO ANSWERS FOR US, PLEASE INVESTIGATE WHY NOT AND SAVE US FROM INJURIES. *TR

NHTSA ID

10615793

Incident

May 24, 2013

Mileage

220 mi