RoadVitals

2007 Champion International Low Floor

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Sep 23, 2009
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jul 17, 2008
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2007 Champion International Low Floor, most frequently naming the brakes category. 1 safety recall has been issued covering this model year; and 1 manufacturer communication is on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
08V326000

EQUIPMENT:APPLIANCE:AIR CONDITIONER

Jul 17, 2008
68 units potentially affected
The defect: CHAMPION IS RECALLING 68 MY 2007-2009 TRANSIT BUSES. THE FASTENERS THAT ARE USED TO HOLD ELECTRICAL CONNECTORS IN PLACE ON THE ROOF MOUNTED AIR CONDITIONER CONTROL PANEL MAY NOT BE TIGHTENED DOWN TO THE PROPER TORQUE AND/OR THERE MAY BE A POSSIBLE FRAYED WIRE AT THE CONNECTION POINT.
The risk: IF THESE CONNECTIONS ARE LOOSE, IT COULD RESULT IN OVERHEATING AND CAUSE A FIRE.
The remedy: DEALERS WILL INSPECT THE FASTENERS ON THE ELECTRICAL CONTROL BOARD AND TIGHTEN THEM TO THE PROPER TORQUE VALUE IF THEY ARE FOUND TO BE LOOSE. THE RECALL BEGAN ON JULY 1, 2008. OWNERS MAY CONTACT CHAMPION BUS AT 1-810-724-1735.
CHAMPION BUS, INC.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Brakes
Filed Sep 23, 2009
Fire reported

MONTGOMERY COUNTY, MARYLAND HAS A SUB-FLEET OF FIFTY (50) CHAMPION BUSES WITH INTERNATIONAL 3200IM CHASSIS. SINCE THE PURCHASE OF THIS FLEET THERE HAS BEEN NUMEROUS COMPONENT AND SYSTEMS FAILURES. ONE OF THOSE FAILURES BEING THE BOSCH ZOH-T HYDRAULIC BRAKING SYSTEM AND FAILURE OF THE CALIPERS TO RELEASE PRESSURE FROM THE PADS CAUSING A THERMAL HEAT RISE AND WHEEL WELL FIRES. THIS FAILURE IS RANDOM THROUGHOUT THE FLEET AND MAY OCCUR AT ANY TIME.THERE HAVE BEEN SIX (6) THERMAL EVENTS WITH IN THE LAST MONTH THAT HAS RESULTED IN THE GROUNDING OF THE FLEET FROM SERVICE. TO THIS POINT NO PERMANENT SOLUTION HAS BEEN OFFERED BY THE OEM. WHEN FAILURES OCCUR ALL BRAKE COMPONENTS ARE REPLACED WITH OEM COMPONENTS. ALL OEM BRAKE PROCEDURES ARE FOLLOWED AND SYSTEM IS BLED ACCORDING TO MANUFACTURER'S SPECIFICATIONS. *TR

NHTSA ID
10285040
Incident
Jul 27, 2009
Mileage
76,615 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

2018-002

SEATS

The mounting bolt to install the Freedman driver?s seat to the Ford OEM seat track may not have been sufficiently tightened during installation.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.