1992 Chevrolet 1500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1992 Chevrolet 1500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Interior & seats840.0%
- Visibility735.0%
- Tires & wheels315.0%
- Brakes15.0%
- Driver assistance15.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE VEHICLES BENCH SEAT ROCKS BACK AND FORTH EXCESSIVELY, THE CONSUMER NOTICED A CRACK IN EACH OF THE SEAT RAILS ON BOTH SIDES OF THE SEAT, THE CONSUMER WANTS THE MANUFACTURER TO REPLACE THE BROKEN RAILS. NLM
WHILE GOING DOWN THE ROAD PASSENGER SIDE SEAT FELL ALL THE WAY BACK, AND BROKE THE CABLE THAT RELEASES THE LATCH. OWNER LATER RECEIVED A RECALL NOTICE, BUT DEALER REFUSED TO REPAIR THE VEHICLE BECAUSE IT REQUIRED MORE THAN JUST BOLTS TO BE INSTALLED. *AK
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WINDSHIELD WIPERS WORK INTERMITTENTLY, WHEN TAPPING ON WIPER HARNESS MOTOR THEY WILL COME BACK ON. WHEN YOUR DRIVING ON A HIGHWAY AND WINDSHIELD WIPERS STOP OPERATING ITS VERY DANGEROUS BECAUSE DRIVER CAN GET TO THAT WIPER MOTOR FROM INSIDE OF CAR.*AK *JB
I AM EXPERIENCING PAINT DELAMINATION ON THIS VEHICLE. FROM THE INFORMATION I HAVE GATHERED THIS IS LIKELY TO HAVE AN EFFECT UPON WINDSHIELD RETENTION DURING IMPACT. I REQUESTED THAT CHEVROLET REMOVE ALL GLASS AND TRIM, REMOVE TRUCK BED, STRIP ALL PAINT DOWN TO BARE METAL AND REPAINT WITH PPG PRODUCTS. I HAVE ALSO REQUESTED THAT CHEVROLET PAY FOR A SUITABLE RENTAL VEHICLE DURING REPAIR. I AM ALSO IN POSSESION OF THEIR TECHNICAL SERVICE BULLETIN 92-300-10 DATED 10-92 PROVING THAT CHEVROLET WAS AWARE OF THIS PROBLEM BEFORE THEY SOLD ME THE TRUCK. I HAVE ALSO UNCOVERED THE FACT THAT THERE MAY BE A NHTSA SAFETY RECALL CONCERNING WINDSHIELD RETENTION PROBLEMS BECAUSE OF PAINT DELAMINATION. PLEASE LET ME KNOW WHAT YOU FIND CONCERNING THIS COMPLAINT. THANK YOU!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
WHILE DRIVING 25 MPH THE UNDER BODY SPARE MOUNTING DISINTEGRATED. AS A RESULT, THE SPARE TIRE FELL OUT INTO THE MIDDLE OF THE STREET. *AK *SC *JB
I WOULD LIKE TO REPORT A TIRE TREAD SEPARATION AND BLOW OUT ON A UNI ROYAL TIGER PAW XTM, P235/75 R15 TIRE WITH 3/16" TREAD REMAINING. THE DOT IS AVHL AA 481. OTHER NUMBERS ON THE TIRE ARE: ITEM 4165, E24405, D117C, 89C, 89B, 89A, 3452. THE TIRE FAILED ON JULY 26 AT ABOUT 10:00 PM AT THE INTERSECTION OF I255 AND I70 NORTHEAST OF ST. LOUIS. THE TIRE ORIGINALLY WAS ON A NEW 1992 CHEVROLET C1500 AND FOR THE LAST FIVE YEARS HAS BEEN ON A 16 FOOT TANDEM AXLE TRAILER WITH 3500 POUND AXLES. THE TIRE HAS NEVER BEEN RUN LOW, NOR OVERLOADED, NOT RUN HOT. AT THE TIME OF FAILURE THE TIRE WAS RELATIVELY COOL CONSIDERING THE AMBIENT TEMPERATURE. THE TIRE FAILED WITH A 3 FOOT SECTION OF THE TREAD SEPARATING FROM THE TIRE EXPOSING THE STEEL BELT WHICH THEN SEPARATED AND CAUSE A SIDEWALL TO SIDEWALL RUPTURE OF THE TIRE WITH A SUDDEN LOSS OF THE AIR PRESSUE. THE CAUSE OF FAILURE WAS DUE TO FAILURE OF THE VULCANIZATION OF THE TREAD TO THE TIRE. THERE IS A SECTION AT THE EDGE OF THE TREAD THAT IS LOOSE WHILE ANOTHER PART IS STILL TIGHTLY ADHERED TO THE TIRE. THE FAILURE DIDN'T CAUSE ANOTHER OTHER DAMAGE AS THE TRAILER IS STRONG IN THE FENDER AREA. ALSO BECAUSE IT IS A TANDEM AXLE TRAILER, THERE WAS NO STABILITY PROBLEM. THIS WAS JUST ONE OF THOSE INSTANCES WHERE THE TIRE WAS DEFECTIVE IN ONE AREA OF THE VULCANIZATION. WITH THE TREAD LOOSE IT JUST FINALLY LET GO AND THE BELT LOST ITS STRENGTH AND SEPARATED AND THEN OF COURSE THE RADIAL CORDS HAVE NO STRENGTH TO HOLD THE AIR INSIDE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
REAR BRAKE LINE RUSTED THROUGH IN THE AREA LOCATED OVER THE FUEL LINE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THROTTLE: DRIVING DOWN HIGHWAY AND THE THROTTLE STICKS,C AN'T GET IT TO RELEASE . CAUSE OF PROBLEM IS UNKNOWN. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .