2016 Chevrolet 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Chevrolet 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Steering228.6%
- Brakes114.3%
- Driver assistance114.3%
- Fuel system114.3%
- Other / unspecified114.3%
- Suspension114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
AT 54,000 MILES, NOTICED 2-3 INCHES IN PLAY IN THE STEERING WILE DRIVING THE VEHICLE. NOW THAT THE STEERING HAS LOOSENED, IT IS A CONTINUAL ISSUE. I HAVE NOT HAD IT DIAGNOSED YET. HOWEVER, IN READING OTHER COMPLAINTS ON THIS SITE, THIS SEEMS TO BE A DESIGN ERROR. AS THIS IS DANGEROUS. THE NHTSA SHOULD FORCE GM TO ISSUE A RECALL.
I REPORTED TO MY DEALER CHARPER CHEVROLET NOV. 2018,I HAD ROUGHLY 23K MILES,THAT MY 2016 CHEVY 3500 HAD DEVELOPED A WOBBLE, SHAKE WHATEVER YOU COULD CALL IT. THEY INVESTIGATED AND TOLD ME MY TIRES POSSIBLY HAD BROKEN BELTS THE TIRES HAD PLENTY OF TREAD LEFT. I WAS TOLD IF I COULD DEAL WITH THE SHAKE TILL I GET NEW TIRES SO BE IT. I RODE THEM TILL JULY 2019 GOT 6 NEW MICHELIN 235/80/17 LTX A/T2 TIRE PACKAGE. THEY RODE OK STILL HAD A LITTLE SHAKE TO START THEN IT GOT WORSE THE MORE I DROVE. LET ME SAY IT NEVER SHOOK ALL THE TIME IT WOULD COME AND GO. SOMETIMES WHEN I HEADED FOR WORK IN THE MORNING SHAKE SHAKE SHAKE OTHER TIMES NOTHING. WHEN GOING AROUND BENDS SHAKE SHAKE THEN NOTHING. IT IS VERY ANNOYING AND NEEDS ATTENTION. MY DEALER WANT TO INVESTIGATE MORE BUT I AM BEING ASKED TO FUND THE INVESTIGATION. WHERE DO I GO FROM HERE? PLEASE ADVISE ME. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
BOUGHT A NEW 2016 CHEV 3500 DULY DIESEL TRUCK. AT ABOUT 14K MILES WE FOUND BRAKE FLUID AND HAD TO HAVE THE TRUCK TOWED TO SHOP. THEY FIXED FOR FREE. ABOUT 7K MILES AFTER THE BREAKS TOTALLY WENT OUT WHILE DRIVING. AT 26K FOUND FLUID AGAIN BUT IN THE BACK. SHOP BLAMED BREAK PADS SAID NO KNOWN ISSUES. FIXED BACK BRAKES. 37K FLUID EVERYWHERE AND BRAKES TOTALLY OUT. GM NOT TAKING RESPONSIBILITY. LARGE TRUCK ON ROAD THAT BRAKES HAVE FAILED FOUR TIMES. TOTAL BREAK FAILURE SEVERAL TIMES CAN NOT BE NORMAL
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
The contact owns a 2016 Chevrolet Low Cab Forward truck. The contact stated that an employee had started the vehicle while parked and placed the vehicle in drive (D), the vehicle independently accelerated and crashed into 2 vehicles parked in front of the contact's vehicle. The contact stated that the employee had not noticed any warning lights. The contact stated that his vehicle had crashed into the front ends of the 2 vehicles and had crushed the hoods front bumper and grills on both vehicles and had pushed both vehicles aside. The contact stated that his vehicle had sustained damage to the driver and passenger side front doors and fenders as well as damage to the front bumper and grill. The police were called, and a report was written. The contact's employee was not injured. The other 2 vehicles were not occupied. The contact stated that the other two vehicles were towed away. The contact stated that his employee was able to drive his vehicle back to his business. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 16V797000 (Vehicle Speed Control). The failure mileage was approximately 62,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2016 SILVERADO DURAMAX. CONSUMER WRITES IN REGARDS TO CP4 FAILURE. *LD *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
I REPORTED TO MY DEALER CHARPER CHEVROLET NOV. 2018,I HAD ROUGHLY 23K MILES,THAT MY 2016 CHEVY 3500 HAD DEVELOPED A WOBBLE, SHAKE WHATEVER YOU COULD CALL IT. THEY INVESTIGATED AND TOLD ME MY TIRES POSSIBLY HAD BROKEN BELTS THE TIRES HAD PLENTY OF TREAD LEFT. I WAS TOLD IF I COULD DEAL WITH THE SHAKE TILL I GET NEW TIRES SO BE IT. I RODE THEM TILL JULY 2019 GOT 6 NEW MICHELIN 235/80/17 LTX A/T2 TIRE PACKAGE. THEY RODE OK STILL HAD A LITTLE SHAKE TO START THEN IT GOT WORSE THE MORE I DROVE. LET ME SAY IT NEVER SHOOK ALL THE TIME IT WOULD COME AND GO. SOMETIMES WHEN I HEADED FOR WORK IN THE MORNING SHAKE SHAKE SHAKE OTHER TIMES NOTHING. WHEN GOING AROUND BENDS SHAKE SHAKE THEN NOTHING. IT IS VERY ANNOYING AND NEEDS ATTENTION. MY DEALER WANT TO INVESTIGATE MORE BUT I AM BEING ASKED TO FUND THE INVESTIGATION. WHERE DO I GO FROM HERE? PLEASE ADVISE ME. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
I REPORTED TO MY DEALER CHARPER CHEVROLET NOV. 2018,I HAD ROUGHLY 23K MILES,THAT MY 2016 CHEVY 3500 HAD DEVELOPED A WOBBLE, SHAKE WHATEVER YOU COULD CALL IT. THEY INVESTIGATED AND TOLD ME MY TIRES POSSIBLY HAD BROKEN BELTS THE TIRES HAD PLENTY OF TREAD LEFT. I WAS TOLD IF I COULD DEAL WITH THE SHAKE TILL I GET NEW TIRES SO BE IT. I RODE THEM TILL JULY 2019 GOT 6 NEW MICHELIN 235/80/17 LTX A/T2 TIRE PACKAGE. THEY RODE OK STILL HAD A LITTLE SHAKE TO START THEN IT GOT WORSE THE MORE I DROVE. LET ME SAY IT NEVER SHOOK ALL THE TIME IT WOULD COME AND GO. SOMETIMES WHEN I HEADED FOR WORK IN THE MORNING SHAKE SHAKE SHAKE OTHER TIMES NOTHING. WHEN GOING AROUND BENDS SHAKE SHAKE THEN NOTHING. IT IS VERY ANNOYING AND NEEDS ATTENTION. MY DEALER WANT TO INVESTIGATE MORE BUT I AM BEING ASKED TO FUND THE INVESTIGATION. WHERE DO I GO FROM HERE? PLEASE ADVISE ME. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .