1987 Chevrolet Astro Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1987 Chevrolet Astro, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Steering1137.9%
- Seat belts620.7%
- Body & structure310.3%
- Interior & seats310.3%
- Engine310.3%
- Driver assistance26.9%
- Other / unspecified13.4%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
BRACKETS SURROUNDING THE POWER STEERING PUMP FAILING IN THIS MODEL VEHICLE WHICH IN TURN CAUSES THE SERPENTINE BELT TO POP WHILE DRIVING LEAVING A POWER FAILURE AND ABILITY TO STEER THE VEHICLE. I NEARLY CRASHED MY VEHICLE IN RUSH HOUR TRAFFIC BECAUSE I COULD NOT STEER TO GET OFF THE ROAD. DOING RESEARCH OVER LAST FEW DATES TALKING TO MECHANICS THIS HAS BEEN SEEN ON NUMEROUS OCCASIONS. THE PART TO FIX THE BRACKET IS HARD TO FIND. *NM
I HAVE A GM ASTRO VAN. THE STEERING COLUMN BOLTS CAME LOOSE THEREFORE ALLOWING THE STEERING WHEEL AND COLUMN TO MOVE ABOUT 2 TO 3 INCHES IN ANY DIRECTION. WHILE THE VAN IS PARKED OR WHILE DRIVING. THIS IS THE THIRD TIME THAT THIS HAS HAPPENED. TWO PREVIUS TIMES THE STEERING COLUMN BOLTS WERE FIXED BY A GM DEARSHIP. TOOK IT BACK FOR THE THIRD TIME. EACH TIME BEING CHARGED TO TIGHTEN THE BOLTS. THIS LATEST REPAIR TO TIGHTEN THE LOOSE BOLTS WORKED FOR A 12 MONTH PERIOD, AND THEN THEY COME LOOSE AGAIN. DEALER ADMITS THAT THERE IS A FLAW IN THE DESIGN BUT THAT NO RECALL HAS BEEN ISSUED BY GM. *JB
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
RIGHT FRON PASSENGER SHOULDER WEBBING SEPERATED
OWNER HAD TO APPLY BRAKES SUDDENLY AND THE SHOULDER AND LAPS BELTS ON THE DRIVER'S SIDE DID NOT LOCK UP TO HOLD THE DRIVER IN THE SEAT. DEALER HAS NOT SEEN. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
RUSTED FRAME WAS DISCOVERED WHEN REPARING BRAKE LINES.
THIS VAN WAS PURCHASED USED IN 1990 AND THE PAINT HAS STEADILY "PEELED" FOR ABOUT THE PAST 4 YEARS. IS THERE A WAY TO HAVE CHEVROLET REPAINT THE VAN? THANKS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
DRIVER'S SEAT WELDS FAILED, CAUSING SEAT TO COLLAPSE.
WHILE DRIVING, PASSENGER REAR/LEFT SEATBACK REST BOLT SHEARED OFF, ALLOWING SEAT BACK TO COLLAPSE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE BRACKET BROKE, CAUSING SERPINTINE BELT TO PUT STRESS ON POWER STEERING PUMP RESULTING IN BREAKAGE OF POWER STEERING PUMP BOLTS. *SD
ENGINE CYLINDER #5 FAILED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
CONSUMER WAS AT A STOP SIGN, WHEN STARTED DRIVING AN THE CRUISE CONTROL CAME ON, CAUSING AN ACCIDENT . PLEASE DESCRIBE. *AK
WHEN STARTING VEHICLE, THE CAR WAS AT FULL THROTTLE, WENT OUT OF CONTROL AND CRASH INTO LIGHT POLE. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
SPARE TIRE IS SUSPENDED UNDER VEHICLE WITH A STEEL CABLE. THIS CABLE BROKE WHILE VEHICLE WAS IN MOTION AND TIRE FELL OFF OF VEHICLE. FORTUNATELY THE VEHICLE WAS TRAVELING AT ONLY 10 MPH. THIS COULD HAVE BEEN VERY SERIOUS! NO LESS THAN 2 PEOPLE HAVE BEEN KILLED IN THE CITY OF SYRACUSE BY SIMILLAR ACCIDENTS OVER THE PAST 15 YEARS! THIS CABLE FAILED BECAUSE IT RUSTED THROUGH. IT IS ALSO IMPOSIBLE TO INSPECT THE CONDITION OF THIS CABLE WITHOUT REMOVING THE SPARE TIRE. THE CABLE SHOULD BE REPLACED WITH A STAINLESS STEEL CABLE. NON-STANLESS STEEL CABLES SHOULD NOT BE ALLOWED IN THIS SAFETY CRITICAL APPLICATION.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .