RoadVitals

1990 Chevrolet Astro Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Newest May 24, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
6 investigations on file

Recall campaigns

7 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06E049000

EXTERIOR LIGHTING

May 24, 2006
27,176 units potentially affected
The defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
CK MOTORSPORT, INC.View on NHTSA.gov
06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
06E026000

EXTERIOR LIGHTING

Mar 23, 2006
61,944 units potentially affected
The defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
PRO-A MOTORS, INC.View on NHTSA.gov
93V187000

SEATS

Nov 16, 1993
604,207 units potentially affected
The defect: THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
The risk: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
GENERAL MOTORS CORP.View on NHTSA.gov
91V164000

SEAT BELTS:FRONT:ANCHORAGE

Sep 20, 1991
4,842 units potentially affected
The defect: SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
The risk: VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
The remedy: REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
SHERROD VANS, INC.View on NHTSA.gov
91V102000

SEAT BELTS:FRONT:ANCHORAGE

Jun 14, 1991
185 units potentially affected
The defect: THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
The risk: SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
The remedy: RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
ASC COLAMCOView on NHTSA.gov
90V146000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Aug 13, 1990
30,640 units potentially affected
The defect: FUEL RETURN HOSES MAY BREAK AT EITHER CRIMPED COUPLING, CAUSING A LEAKAGE OF FUEL.
The risk: IN THE EVENT OF A FUEL RETURN LINE SEPARATION, A FUELLEAK OCCURRING IN THE PRESENCE OF AN IGNITION SOURCE COULD CAUSE A FIRE.
The remedy: INSTALL A PROPERLY CRIMPED FUEL RETURN HOSE.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE97025ClosedPreliminary Evaluation

INSTRUMENT PANEL/DASH ELECTRICAL FIRE

Opened Jun 12, 1997
Closed Nov 26, 1997

ALLEGED ELECTRICAL FIRES MAY OCCUR IN THE DASH AREA WHILE THE SUBJECT VEHICLES ARE BEING OPERATED OR WHILE PARKED.

ELECTRICAL SYSTEM
EA92022ClosedEngineering Analysis

SEAT BACK BOLT BREAKAGE

Opened Jun 24, 1992
Closed Nov 19, 1993

There is no summary currently available

SEATSLed to recall 93V187000
DP92012ClosedDefect Petition

APV FIRES

Opened Jun 9, 1992
Closed Jun 25, 1992

APV FIRES

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
EA91028ClosedEngineering Analysis

BRAKE FAILURE

Opened Jun 10, 1991
Closed Jun 30, 1992

===

SERVICE BRAKES, HYDRAULIC
PE91052ClosedPreliminary Evaluation

BRAKE FAILURE

Opened Feb 22, 1991
Closed Jun 10, 1991

There is no summary currently available

SERVICE BRAKES, HYDRAULIC
PE91038ClosedPreliminary Evaluation

SLIDING DOOR HINGE FAILURE

Opened Jan 23, 1991
Closed May 31, 1991

There is no summary currently available

STRUCTURE

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .