2005 Chevrolet Astro Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Chevrolet Astro, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Tires & wheels220.0%
- Body & structure110.0%
- Brakes110.0%
- Electrical110.0%
- Fuel system110.0%
- Interior & seats110.0%
- Other / unspecified110.0%
- Airbags110.0%
- Visibility110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 CHEVROLET ASTRO. THE CONTACT STATED THAT WHEN HE PURCHASED THE PREOWNED VEHICLE, THE DEALER REPLACED ALL OF THE TIRES. THE SIDEWALL ON ALL FOUR ADVANTA SUV SPECTRA, SIZE P215-70R-16 TIRES WERE CRACKED. THE TIRES HAD LESS THAN 21,000 MILES ON THEM WHEN THE FAILURE WAS DISCOVERED. THE TIRES WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 91,500. UPDATED 12/02/10 *BF THE CONSUMER STATED HE HAS THE INVOICE FOR THE NEW TIRES. UPDATED 12/07/10
TRAVELING SOUTH ON CALIFORNIA INTERSTATE 5, AFTER TEJON PASS IN SOUTHERN CALIFORNIA, THE RIGHT REAR TIRE OF OUR 2005 CHEVY ASTRO LS MINIVAN JUST BLEW OUT. THE TIRE WAS BRIDGESTONE DUELER (SIZE P215 70 R16 99S). I WAS DRIVING WITHIN THE SPEED LIMIT OF 65 MPH. THE FREEWAY ROAD SURFACE WAS CLEAN AND THE WEATHER WAS SUNNY AND CLEAR. THERE'S NO DEBRIS OR ROAD HAZARD ON THE FREEWAY. I CALLED EMERGENCY ROADSIDE ASSISTANCE TO REPLACE THE BLOWN OUT TIRE WITH THE SPARE. I ENDED UP BUYING A NEW REPLACEMENT TIRE. I WAS ABLE TO SAVE ONLY A SMALL PORTION OF THE BLOWN OUT TIRE. FORTUNATELY, THERE'S NO INJURY. THE INCIDENT HAPPENED JULY 20, 2007 ABOUT 1:30 P. M. THE WHOLE FRONT PART OF THE TIRE WERE SHREDDED TO PIECES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
I SIMPLY CLOSED THE PASSENGER DOOR OF MY 2005 CHEVY ASTRO AWD VAN AND THE SIDE MIRROR GLASS FELL OUT, HIT THE DOOR AND BROKE. ALSO, THE PLASTIC MOLDING ON THE DRIVERS DOOR IS COMING LOOSE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
MY BRAKES SUDDENLY FAILED ON MY 2005 CHEVY ASTRO VAN. DEALER REPAIR SAID BRAKE LINE WAS RUBBING AGAINST CHASIS, BROKE AND ALL BRAKE FLUID LEAKED OUT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT THE VEHICLE RANDOMLY STALLED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THE WIRING HARNESS WAS INSTALLED INCORRECTLY. THE WIRING HARNESS WAS CONNECTED TO THE EXHAUST AND THAT SHORTED OUT THE ALTERNATOR AND THE STARTER. THE FAILURE MILEAGE WAS AND CURRENT MILEAGES WERE 24,500.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 CHEVROLET ASTRO. THE CONTACT WAS TRAVELING 20 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PUMP WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 84,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
DT*: THE CONTACT STATED WHEN USING THE LATCH SYSTEM IN THE MIDDLE ROW SEATING, THE THIRD ROW SEATING IS IMPOSSIBLE TO ACCESS. THE PROBLEM OCCURRED WHEN A CHILD PASSENGER WAS IN THE MIDDLE ROW SEAT IN A CAR SEAT AND THAT MADE THE SEAT NOT ABLE TO TILT FORWARD. TILTING FORWARD WOULD HAVE ALLOWED ANY OTHER PASSENGER TO ENTER AND EXIT THE THIRD ROW. THE DEALER AND MANUFACTURER WERE ALERTED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 CHEVROLET ASTRO. WHILE USING THE JACK FOR THE PASSENGER SIDE REAR TIRE, THE VEHICLE BEGAN TO VEER TO THE RIGHT. THE CONTACT PLACED BLOCKS IN FRONT OF THE PASSENGER SIDE FRONT TIRE, BUT THE VEHICLE NEARLY DROVE OVER THE BLOCK. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 14,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
2005 CHEVROLET ASTRO VAN SUSTAINED MINOR FRONT END DAMAGE IN AN ACCIDENT AND BOTH FRONT AIRBAGS ONLY PARTIALLY DEPLOYED. WE'VE NEVER SEEN AIRBAGS ONLY PARTIALLY DEPLOY. THE PASSENGER SIDE CONSOLE SPLIT AND THAT AIRBAG IS VISIBLE FROM THE 1/2 TO 1 INCH SEPARATION OF THE SEAM IN THE CONSOLE. THE DRIVERS SIDE BAG IS MORE VISIBLE BUT CLEARLY DID NOT FULLY INFLATE. CONSEQUENCES: WE ARE CONCERNED THAT THIS MIGHT BE A DEFECT IN THE VEHICLE AND ARE CONCERNED ABOUT FUTURE ACCIDENTS IN THIS TYPE OF VEHICLE - WE HAVE CONCERNS ABOUT FUTURE LIABILITY THAT MAY ARISE. CORRECT FAILURE: WE WILL REPLACE AIRBAG SENSOR AND AIRBAGS WITH MANUFACTURER PARTS.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
I SIMPLY CLOSED THE PASSENGER DOOR OF MY 2005 CHEVY ASTRO AWD VAN AND THE SIDE MIRROR GLASS FELL OUT, HIT THE DOOR AND BROKE. ALSO, THE PLASTIC MOLDING ON THE DRIVERS DOOR IS COMING LOOSE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .