1994 Chevrolet C20 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1994 Chevrolet C20, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes433.3%
- Visibility216.7%
- Electrical18.3%
- Airbags18.3%
- Seat belts18.3%
- Tires & wheels18.3%
- Interior & seats18.3%
- Driver assistance18.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
CONSUMER FEELS THERE IS INSUFFICIENT SPACE BETWEEN THE BRAKE PEDAL AND THE ENGINE COVER (THIS IS A VAN WITH THE ENGINE COVER LOCATED BETWEEN THE FRONT PASSENGER AND DRIVERS SEAT). WHEN THE DRIVER REMOVES HIS FOOT FROM THE GAS PEDAL IT WILL OCCASIONALLY GET CAUGHT UNDER THE BRAKE PEDAL. THE CONSUMER STATED THAT THIS IS A DESIGN DEFECT. *YH
AT ANY SPEED WHEN APPLYING BRAKES BRAKING DISTANCE IS NOT WHAT IT SHOULD BE. REAR BRAKES NOT WORKING PROPERLY, LOCK UP. FRONT BRAKES REPLACED TWICE. *AK BRAKES ARE REAL BAD ON WET OR ICY ROADS. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
DRIVER'S SIDE WINDSHIELD HAS AN IRREGULARITY, THIS CAUSES DRIVER'S VIEW TO BE OBSTRUCTED, ESPECIALLY WHEN IT'S RAINING. AREA IS NOT ABLE TO BE CLEANED WHEN WIPER IS IN USE. ROAD IS HARD TO DISCIPHER WHEN THE WEATHER IS CLEAR AND SUNNY.*AK *JB
WINDSHIELD WIPERS STOPPED FUNCTIONING FOR NO APPARENT REASON AND HAVE INTERMITTENT OPERATION. POSSIBLE TO RESTART WIPERS BY TAPPING ON MOTOR HOUSING AND/OR MOVING WIRES THAT PLUG INTO WIPER MOTOR. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
VEHICLE STALLS WITHOUT WARNING WHILE DRIVING AT ANY SPEED, PE94-091 ACTIVE. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
HAD A FRONTAL COLLISION, AIR BAG DID NOT DEPLOY. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
SEAT BELT HAS BEEN REPLACED TWICE, WILL LOCK UP UNEXPECTEDLY. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
1994 CHEVROLET C20, LEFT REAR TIRE BLEW OUT. DRIVER LOST CONTROL AND WENT OFF THE LEFT SIDE OF THE ROAD, STRIKING THE CONCRETE MEDIAN WALL. *BF ACCORDING TO THE POLICE REPORT, THE TIRES SHOWED SUFFICIENT TREAD, BUT SHOWED SIGNS OF DRY ROT AND CRACKING. (OHIO TRAFFIC CRASH REPORT # 10-0469-90) *JB UPDATED 09/13/10*BF
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
DRIVERS SEAT BRACKET THAT SECURES THE FRAME BROKE. *AK THE BRACKET BROKE ON TH BACK SEAT, HAD A ROCKING MOTION WHICH FELT VERY UNSAFE PARTICULARY IF THERE WOULD BE AN ACCIDENT, CONSUMER CONTACTED DEALERSHIP AND THEY REPAIRED IT.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THE CAR IDLES AT 1100 TO 1500 RMP WHEN YOU RELEASE THE PEDAL. HAS TAKEN THE CAR BACK TO DEALERS SEVEN TIMES NOTHING HAPPENED. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .