RoadVitals

1994 Chevrolet Cavalier Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jan 23, 1996
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

96I001000

ELECTRICAL SYSTEM:HORN

Jan 23, 1996
417,000 units potentially affected
The defect: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THESE VEHICLES WERE BUILT WITH INSUFFICIENT RETENTION OF THE HORN PAD.
The risk: THE HORN PAD CAN SEPARATE FROM THE STEERING WHEEL FALLING BETWEEN THE STEERING WHEEL SPOKES. THE HORN PAD COULD BECOME JAMMED BETWEEN THE STEERING WHEEL SPOKES AND THE TURN SIGNAL LEVER, RESULTING IN DAMAGE TO THE TURN SIGNAL LEVER, HORN PAD, AND HORN WIRING.
The remedy: DEALERS WILL MODIFY THE HORN PAD RETENTION CLIPS, INSTALL HORN PAD RETENTION BRACKETS TO THE STEERING WHEEL, REINSTALL THE HORN PAD AND ASSURE THAT THE HORN PAD IS PROPERLY RETAINED.
GENERAL MOTORS CORP.View on NHTSA.gov
94V115000

STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM

Jun 24, 1994
65 units potentially affected
The defect: THESE VEHICLES WERE BUILT WITH OVERTORQUED DRIVE AXLE SPINDLE NUTS. THIS CONDITION CAN CAUSE EXCESSIVE LOADS ON THE SPINDLE NUT AND DRIVE AXLE RESULTING IN FAILURE OF THE DRIVE AXLE OR THE SPINDLE NUT. FAILURE OF EITHER OF THESE COMPONENTS CAN RESULT IN SEPARATION OF THE STEERING KNUCKLE TIRE-WHEEL ASSEMBLY FROM THE DRIVE AXLE.
The risk: THIS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE ACCIDENT.
The remedy: DEALERS WILL REPLACE THE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES. CORRECTIVE ACTION: DEALERS WILL REPLACE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA94033ClosedEngineering Analysis

HORN PAD FALLS OFF

Opened Sep 29, 1994
Closed Mar 29, 1996

THIS INVESTIGATION IS CLOSED.GM WILL CONDUCT A SAFETY IMPROVEMENT CAMPAIGN TO ADDRESS THE CONCERNS RAISED BY THE DETACHMENT OF THE HORN PAD FROM THE STEERING WHEEL IN THE SUBJECT VEHICLES.FOR A TECHNICAL ANALYSIS OF THE PROBLEM SEE EA94-033 ENGINEERING TECHNICAL REPORT.

ELECTRICAL SYSTEM:HORN
PE94042ClosedPreliminary Evaluation

HORN BUTTON FALLING OFF

Opened May 23, 1994
Closed Sep 29, 1994

There is no summary currently available

EXTERIOR LIGHTING

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .