1977 Chevrolet Chevrolet Truck Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1977 Chevrolet Chevrolet Truck, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system250.0%
- Seat belts125.0%
- Tires & wheels125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
THE DESIGN OF THE FUEL TANK IS MOUNTED OUTBOARD OF FRAME, THE DESIGN HAS BEEN NOTED TO BE FAULTY RESULTING IN FIRES WHEN VEHICLE IS INVOLVED IN COLLISION. CONSUMER HAS NOT EXPERIENCED FIRE, HOWEVER VEHICLE CONTAINS DESIGN FLAW.
VEHICLES GAS TANK OUTSIDE THE FRAME.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE PASSENGER SIDE SEAT BELT FAILED UNDER A RAPID STOP. THE BELT NEVER CAUGHT. IT JUST CONTINUED TO LET BELT OUT UNTIL THE PASSENGER CAUGHT HERSELF NEAR THE DASH. UPON TAKING THE BELT ROLLUP ASSEMBLY APART, I FOUND THAT THE NYLON BRACKET THAT HOLDS THE LEAD (PB) PENDALUM HAD BROKEN. THE LATCHING PENDALUM WAS IN THE BOTTOM OF THE ASSEMBLY. I "SUPER GLUED" THE BRACKET, SO THAT IT IS WORKING AT THE MOMENT, BECAUSE GM DOES NOT MAKE A REPLACEMENT ANYMORE. THIS ANGERS ME. I AM NOW SEARCHING THE JUNK YARDS FOR A GOOD ONE. SINCERELY, [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
LEFT FRONT TIRE TREAD SPARATION WITHOUT WARNING IN HEAVY TRAFFIC ON INTERSTATE 5 - LUCKY TO AVOID HITTING OTHER VEHICLES - TIRES WERE CORRECTLY INFLATED - VEHICLE WAS NOT LOADED( DOT NUMBER: W2HL4FAP3S TIRE SIZE: P235/75R15 )
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .