1999 Chevrolet Corvette Problems

The contact owns a 1999 Chevrolet Corvette. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 04V060000 (Steering) in 2019. The contact stated that while starting the vehicle, the message "Service - Steering Column Lock" was displayed. The vehicle was taken back to the dealer, who informed the contact that he needed to pay for a diagnostic test to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they would follow up with the dealer. The failure mileage was approximately 37,300.

Something is wrong where it will stall out when you start driving. Soon as I put the car in gear and start rolling forward it dies. And I’ve looked online and it’s quite common.

Something is wrong where it will stall out when you start driving. Soon as I put the car in gear and start rolling forward it dies. And I’ve looked online and it’s quite common.

MY CORVETTE AS WELL AS MANY OTHERS FROM 97-04 SUFFER FROM THE ACTIVE HANDLING ABS/TRACTION CONTROL SYSTEM GOING BAD. THE PART IS KNOWN AS THE EBCM. WHEN IT GOES BAD (IF CRUISE IS ENGAGED) THE CAR WILL DISABLE CRUISE CONTROL SUDDENLY CAUSING CAR TO SLOW DOWN. ALSO, WHEN THE SYSTEM FAILS WHILE MOVING IT CAUSE CAUSE UNEVEN BRAKE FEELING AND YOU LOOSE THE ABS AND TRACTION CONTROL SYSTEMS . GM HAS DISCONTINUED THE PARTS REQUIRED TO REPAIR THIS AND THIS ISSUE HAS BEEN MAJOR SAFETY CONCERNS FOR MANY YEARS NOW AFFECTING MANY 97-04 CORVETTES. ALSO A PART OF THIS SYSTEM IS THE STEELING WHEEL POSITION SENSOR WHICH IS ALSO DISCONTINUED. SWPS CAN SEND WRONG INFO TO THE OTHER COMPUTERS AND THE CAR WILL MAKE ERRONEOUS 'CORRECTIONS' THAT CAN LEAD TO BRAKES BEING APPLIED AT ANY MOMENT WHILE DRIVING.

Almost every C5 (1997-2004) Corvette is affected by a faulty electronic brake control module. When this module fails, the car illuminates the ABS and traction control light. And displays service abs and service traction control messages. This is a serious safety issue as when this happens, the abs brakes no longer work nor does the traction control. It blows my mind how this has never been recalled especially on a rear drive sports car.

MY CORVETTE AS WELL AS MANY OTHERS FROM 97-04 SUFFER FROM THE ACTIVE HANDLING ABS/TRACTION CONTROL SYSTEM GOING BAD. THE PART IS KNOWN AS THE EBCM. WHEN IT GOES BAD (IF CRUISE IS ENGAGED) THE CAR WILL DISABLE CRUISE CONTROL SUDDENLY CAUSING CAR TO SLOW DOWN. ALSO, WHEN THE SYSTEM FAILS WHILE MOVING IT CAUSE CAUSE UNEVEN BRAKE FEELING AND YOU LOOSE THE ABS AND TRACTION CONTROL SYSTEMS . GM HAS DISCONTINUED THE PARTS REQUIRED TO REPAIR THIS AND THIS ISSUE HAS BEEN MAJOR SAFETY CONCERNS FOR MANY YEARS NOW AFFECTING MANY 97-04 CORVETTES. ALSO A PART OF THIS SYSTEM IS THE STEELING WHEEL POSITION SENSOR WHICH IS ALSO DISCONTINUED. SWPS CAN SEND WRONG INFO TO THE OTHER COMPUTERS AND THE CAR WILL MAKE ERRONEOUS 'CORRECTIONS' THAT CAN LEAD TO BRAKES BEING APPLIED AT ANY MOMENT WHILE DRIVING.

THE DRIVER'S SIDE SEAT BELT WILL NOT RETRACT. IT IS EXTENDED ALL THE WAY OUT. THEREFORE, IT WILL NOT FIT NOR WILL IT PROTECT ANYONE FROM INJURY. I FIND THIS TO BE A SEATBELT DEFECT AND A MAJOR SAFETY HAZARD.

MY 1999 CORVETTE SEAT BELT RETRACTOR QUIT WORKING 2 DAYS AGO . MY WIFE WAS UNABLE TO FASTEN THE SEAT BELT AFTER SEVERAL TRIES. I REMOVED BOTH RETRACTORS TO INSPECT AND COULD FIND NO VISIBLE DAMAGE. THERE CAR IS IN SHOWROOM CONDITION. I DID AN INTERNET SEARCH FOR INFO AND FOUND A RECALL CAMPAIGN : NHTSA CAMPAIGN I'D NUMBER 00V111000 APR 6 2000. I CALLED MY CHEVY DEALER [XXX] AND THEY SAID A RECALL HAD BEEN DONE IN 2000 FOR A PLASTIC PART TO STOP BELT TWISTING AND NO FURTHER RECALL WOULD BE HONORED. BUT THIS IS NOT THE PROBLEM! THE RATCHETING MECHANISM IS FAULTY. I NEED THIS FIXED ASAP FROM THE DEFECTIVE SEAT BELT MECHANISM. THIS RESULTS IN A VEHICLE I NOW CANNOT LEGALLY AND SAFELY DRIVE. PLEASE HELP. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN THE VEHICLE TAKES OFF FROM A DEAD STOP OR COMES TO A STOP THE DRIVER AND PASSENGER SEAT MOVE IN THE TRACK ABOUT A QUARTER INCH OR SO CREATING AN UNEASY AND UNSAFE FEELING WHILE OPERATING THE VEHICLE. AFTER DOING EXTENSIVE ONLINE RESEARCH I HAVE FOUND THAT THIS IS A PROBLEM THAT PLAGUES JUST ABOUT EVERY 1997-2004 CHEVROLET CORVETTE EQUIPPED WITH POWER SEATS. I DISCOVERED THAT THE BUSHINGS THAT WERE USED IN THE SEAT TRACKS WERE MADE FROM INFERIOR MATERIALS AND DISINTEGRATE OVER A SHORT PERIOD OF TIME AND ALLOW THE SEAT TO MOVE IN THE TRACK WHILE TAKING OFF OR STOPPING. IT'S NOT A QUESTION OF IF IT WILL HAPPEN BUT WHEN IT WILL HAPPEN. TO MY UNDERSTANDING GENERAL MOTORS HAS MADE NO EFFORT TO FIX THIS PROBLEM ON THEIR OWN. I UNDERSTAND THAT SOME WERE REPAIRED UNDER WARRANTY BY REPLACING THE SEAT TRACK BUT THE NEW TRACK WOULD DO THE SAME THING IN TIME. I PURCHASED THIS CAR USED AND WELL OUT OF WARRANTY AND IF IT WERE AN ISOLATED PROBLEM THEN I WOULD ACCEPT THAT AND TRY TO HAVE IT REPAIRED, BUT IT'S NOT. IT HAS HAPPENED TO JUST ABOUT ALL CORVETTES BUILT BETWEEN 1997-2004. IN FACT THERE IS AN AFTERMARKET REPAIR KIT FOR THIS BUT IT REQUIRES THE REMOVAL OF THE SEAT AND DISASSEMBLY OF THE SEAT TRACK AND A VERY CAREFUL REASSEMBLY AFTER THE BUSHINGS ARE REPLACED. WE ARE NOT ALL MECHANICS NOR CAN WE ALL AFFORD THE 600.00 PER SEAT TO HAVE IT REPAIRED. SOME OF US DO WELL JUST TO BE ABLE TO BUY A CAR LIKE THAT. THAT'S WHY IT'S A 1999 AND NOT A 2015. I LOVE THIS CAR, IT SEEMS A SHAME THAT A CAR THAT COST 40,000.00 WHEN IT WAS NEW SHOULD HAVE SUCH A PROBLEM THAT COULD HAVE BEEN PREVENTED WITH SLIGHTLY BETTER QUALITY. THANK YOU FOR READING THIS AND I HOPE THAT YOU WILL LOOK INTO THIS MATTER. THE PARTS COST FOR G.M. ON THIS REPAIR WOULD NOT BE OUT OF THE QUESTION FOR THEM, HOWEVER THE LABOR INVOLVED FOR THEM TO DO THE REPAIRS WOULD PROBABLY BE WHAT THEY WOULD BALK AT. THANK YOU AGAIN. *TR

BOTH SEATS MOVE ALITTLE BIT WHILE DRIVING. *TR

MY CORVETTE AS WELL AS MANY OTHERS FROM 97-04 SUFFER FROM THE ACTIVE HANDLING ABS/TRACTION CONTROL SYSTEM GOING BAD. THE PART IS KNOWN AS THE EBCM. WHEN IT GOES BAD (IF CRUISE IS ENGAGED) THE CAR WILL DISABLE CRUISE CONTROL SUDDENLY CAUSING CAR TO SLOW DOWN. ALSO, WHEN THE SYSTEM FAILS WHILE MOVING IT CAUSE CAUSE UNEVEN BRAKE FEELING AND YOU LOOSE THE ABS AND TRACTION CONTROL SYSTEMS . GM HAS DISCONTINUED THE PARTS REQUIRED TO REPAIR THIS AND THIS ISSUE HAS BEEN MAJOR SAFETY CONCERNS FOR MANY YEARS NOW AFFECTING MANY 97-04 CORVETTES. ALSO A PART OF THIS SYSTEM IS THE STEELING WHEEL POSITION SENSOR WHICH IS ALSO DISCONTINUED. SWPS CAN SEND WRONG INFO TO THE OTHER COMPUTERS AND THE CAR WILL MAKE ERRONEOUS 'CORRECTIONS' THAT CAN LEAD TO BRAKES BEING APPLIED AT ANY MOMENT WHILE DRIVING.

WHILE TURNING A CORNER AT A NORMAL RATE OF SPEED, ACTIVE HANDLING TURNED ON AND TRIED TO STRAIGHTEN OUT THE VEHICLE, PUTTING ME ON A COLLISION COURSE WITH THE CAR IN THE OPPOSITE LANE. IT WOULD HAVE FORCED CROSSING OVER THE LANE HAD I NOT REACTED QUICKLY. REPAIR SHOP DIAGNOSED AS FAILED STEERING WHEEL POSITION SENSOR; A PART GM CHOSE TO DISCONTINUE YEARS AGO EVEN THOUGH IT IS ONE OF THE MOST CRITICAL SAFETY COMPONENTS OF THE VEHICLE.

AFTER PARKING AND TRYING TO RESTART THE ENGINE THE MESSAGE "STEERING COLUMN MAINTAINANCE NEEDED" THE ENGINE STARTED BUT WHEN I PUT IT IN GEAR THE ENGINE STOPPED. AFTER TRYING TO START THE CAR AGAIN AND AGAIN THE SAME RESULT. I CHECKED THE OWNERS MANUEL AND FOUND NO SUCH ITEM. AFTER SITTING FOR ABOUT 20 MINUTES THE CAT DID START AND I GOT HOME.

FUEL LEAK FROM THE PASSENGER FUEL TANK. THIS IS CREATING A FUEL VAPOR SMELL INSIDE THE CAR AND THE GARAGE WHERE PARKED. THIS IS A FIRE AND SAFETY HAZARD!

TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS REFERRED TO THE LOCAL DEALER. THE CONTACT CALLED A LOCAL DEALER (APPLE CHEVROLET, 8585 159TH ST, TINLEY PARK, IL 60487, 866-399-5963) AND WAS INFORMED THAT DIAGNOSTIC TESTING WAS NEEDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 31,000.

TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE DRIVING 1 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED AND THE "PULL KEY TEN SECONDS" MESSAGE DISPLAYED. THE CONTACT STATED THAT THE VEHICLE WAS SHOWING THE SAME SYMPTOMS AS INDICATED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,300.

AUTOMATIC TRANSMISSION LOST REVERSE AND 2ND GEAR WITHOUT WARNING OF ANY KIND. BROKEN SUN SHELL. *AK

THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS ARE AS FOLLOWED: THE RIGHT WINDOW LEAKED WATER WHERE THE TOP MEETS THE WINDSHIELD(BADLY), THE REAR DIFFERENTIAL AREA LEAKED FLUID WHEN SAT OVERNIGHT, THERE WAS A RATTLING NOISE UNDERNEATH THE VEHICLE DUE TO THE TRANSMISSION COOLER LINERS BEING MISADJUSTED, THERE WAS A RATTLE IN THE ENGINE WHEN ACCELERATED UP A HILL OR WHEN TAKING OFF, THE DRIVER DOOR LEAKED WHEN IT RAINED AND SCRAPES WHEN ROLLED DOWN, THERE WAS A GRINDING IN THE REAR END WHEN BACKED UP OR WHEN IT'S COLD, THE RIGHT DOOR GLASS RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE WIPERS WERE INOPERATIVE. THE CONVERTIBLE TOP WAS REPLACED. *SCC THE FOG LAMP WAS REPLACED AND THE SPOILER WAS LOOSE. *JB

TURN SIGNAL BLINKERS FAIL TO WORK INTERMITTENTLY. *TR

TL*THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT TURNED ON THE RIGHT TURN SIGNAL BUT IT DID NOT FUNCTION. THE FAILURE WAS INTERMITTENT AND OCCURRED WITH BOTH TURN SIGNALS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 136,517.

I HAVE A 1999 CORVETTE CONVERTIBLE. THIS CAR WAS PURCHASED NEW AND I CAN'T ENJOY IT. THIS CAR HAS BEEN IN THE SHOP MORE THAN IT HAS BEEN DRIVEN. IT HAS A BAD LEAK AROUND THE TOP AND YOU CAN SEAT IN THE CAR AND LOOK OUTSIDE THROUGH THE CRACKS . THE TOP HAS BEEN REPLACED THE CAR HAS BEEN PAINTED 3 TIMES. *LA

THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS ARE AS FOLLOWED: THE RIGHT WINDOW LEAKED WATER WHERE THE TOP MEETS THE WINDSHIELD(BADLY), THE REAR DIFFERENTIAL AREA LEAKED FLUID WHEN SAT OVERNIGHT, THERE WAS A RATTLING NOISE UNDERNEATH THE VEHICLE DUE TO THE TRANSMISSION COOLER LINERS BEING MISADJUSTED, THERE WAS A RATTLE IN THE ENGINE WHEN ACCELERATED UP A HILL OR WHEN TAKING OFF, THE DRIVER DOOR LEAKED WHEN IT RAINED AND SCRAPES WHEN ROLLED DOWN, THERE WAS A GRINDING IN THE REAR END WHEN BACKED UP OR WHEN IT'S COLD, THE RIGHT DOOR GLASS RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE WIPERS WERE INOPERATIVE. THE CONVERTIBLE TOP WAS REPLACED. *SCC THE FOG LAMP WAS REPLACED AND THE SPOILER WAS LOOSE. *JB

TL*THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED HE ATTEMPTED TO ENGAGE THE WINDSHIELD WIPERS BUT THEY WOULD NOT COME ON. UPON EXAMINING THE VEHICLE HE NOTICED THAT THERE WAS WATER IN THE WINDSHIELD WIPER MODULE. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE AND IT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 92,000.

99 CORVETTE...GLASS TOP WHICH CAME WITH CAR HAS LARGE WHITE STRIPE FROM FRONT TO BACK ON RIGHT SIDE AND LEFT SIDE HAS PEELING IN LARGE CIRCLE...I HAVE READ ON FORUMS THIS HAS HAPPENED TO MORE THAN JUST ME! HELP!! ALSO TACHOMETER HAS QUIT WORKING. *JB

Almost every C5 (1997-2004) Corvette is affected by a faulty electronic brake control module. When this module fails, the car illuminates the ABS and traction control light. And displays service abs and service traction control messages. This is a serious safety issue as when this happens, the abs brakes no longer work nor does the traction control. It blows my mind how this has never been recalled especially on a rear drive sports car.

TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. AFTER THE KEY WAS PLACED IN THE IGNITION, THE VEHICLE CRANKED. HOWEVER, THE STEERING WHEEL WAS IN A LOCKED POSITION AND THE GEAR SHIFTER FAILED TO SHIFT INTO GEAR. A FEW HOURS LATER, THE STEERING WHEEL UNLOCKED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.

MY WARNING LIGHTS CAME ON INDICATING CHECK ANTI-LOCK BRAKES AND TRACTION CONTROL. AFTER A VISIT TO A CHEVY DEALER, I WAS TOLD THAT THE SENSOR CONTROLLING THESE ITEMS WAS BAD AND GM NO LONGER PRODUCED THE PART. AFTER SEARCHING THE INTERNET WITHOUT SUCCESS FOR THE PART, I WAS TOLD BY ONE PART SUPPLIER THAT HE HAD 15 PEOPLE ON A WAITING LIST FOR THE PART AND NO IDEA WHEN HE WOULD HAVE ONE. IN THE MEANTIME, I AM DRIVING A VEHICLE WITHOUT ANTI-LOCKS AND WITHOUT TRACTION CONTROL, SAFETY OPTIONS I PAID FOR THAT ARE NOW INOPERABLE. SHOULD AN ACCIDENT OCCUR AS A RESULT OF THESE FAILINGS, WOULD GM ACCEPT RESPONSIBILITY?? *TR

MY 1999 CHEVY CORVETTE DISPLAYED BRAKE FAILURE CODES. THE MECHANIC SCANNED IT AND TELLS ME IT NEEDS A BRAKE CONTROL MODULE. I CONTACTED A FEW DEALERS AND LEARNED THAT THE BRAKE CONTROL MODULE IS A DISCONTINUED PART AND NO LONGER AVAILABLE. WHAT DO I DO? *TR

WHILE DRIVING 55 MPH AN ANIMAL JUMPED OUT IN FRONT OF THE VEHICLE WHEN CONSUMER SLAMMED ON THE BRAKES THE FRONT DRIVER SIDE WHEEL ASSEMBLY SEPARATED FROM THE VEHICLE AND ROLLED UNDER THE VEHICLE. AS A RESULT, CONSUMER LOST CONTROL, HITTING A TREE. VEHICLE WAS C TOTALED. DRIVER SUSTAINED HEAD INJURIES. *AK

REAR SWAY BAR BUSHINGS ARE NOISY WHEN VEHICLE IS TURNING/STOPPING, OR ACCELERATING. CONSUMER TOOK VEHICLE TO THE DEALERSHIP BECAUSE STEERING WAS DIFFICULT TO CONTROL AND ERRATIC WHEN CROSSING OVER A BUMP. DEALERSHIP INSTALLED A STABILIZER IN VEHICLE AND REPLACED SWAY BAR BUSHINGS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK

REAR TIRE P275/40ZR18EMT,DOT # M60NACDR428 AND FRONT TIRE P245/45ZR17EMT, DOT #M68KACWR418 HAVE DEVELOPED CRACKS BETWEEN TREAD AND OUTER RIM.*AK ALL FOUR TIRES SHOW CRACKS BETWEEN TREAD AND BOTH OUTER SECTIONS OF TIRES. THE DEALER PRORATED THE TIRES AND REPLACED IT. *YH

THE LEATHER ON THE SEATS EXPERIENCE EXCESSIVE WEAR AND THE LEATHER REQUIRES REPLACEMENT, THE ELECTRICAL SYSTEM FOR THE DRIVERS SEAT MALFUNCTIONED. *MJS