Fuel system
Filed Feb 19, 2026
The contact owns a 2010 Chevrolet Corvette. The contact stated that while the vehicle was parked in the garage, and while driving at undisclosed speeds, there was a strong fuel odor coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was inspected, and the mechanic found a fuel leak on the left side of the fuel tank. The vehicle was not repaired. The contact associated the failure with GMC Special Coverage Adjustment Number: N150682 (15682 Primary Tank Module Flange Fuel and Vapor Leaks). The manufacturer was contacted and informed the contact that the VIN was not included in the Special Coverage. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 75,000.
- NHTSA ID
- 11719076
- Incident
- Feb 12, 2026
- Mileage
- 75,000 mi
Fuel system
Filed Jun 12, 2024
The contact owns a 2010 Chevrolet Corvette. The contact stated that there was an abnormally strong fuel odor coming from the vehicle while parked. The vehicle was taken to a dealer and the contact was informed that the fuel vapors were coming from the fuel pump sending unit. The vehicle was not repaired. The dealer spoke with the manufacturer about the failure however, the manufacturer offered no assistance. The vehicle was not repaired. The failure mileage was approximately 32,000.
- NHTSA ID
- 11593847
- Incident
- Jun 1, 2024
- Mileage
- 32,000 mi
Fuel system
Filed Oct 2, 2023
Purchased 3 weeks ago. Third time filling up and first time in the garage. Noticed the fuel tank is leaking at the pump due to defective plastic. Car only has 55k miles, this should not be an issue. Is Chevy going to fix this or am I out the 2k repair bill?
- NHTSA ID
- 11547825
- Incident
- Sep 29, 2023
Fuel system
Filed Mar 27, 2023
The contact owns a 2010 Chevrolet Corvette. The contact stated there was a strong gasoline odor inside the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed that gasoline was leaking from the fuel tank onto the exhaust pipe. The vehicle was not repaired. The dealer and the manufacturer were not contacted. The failure mileage was 55,000. VIN was not available.
- NHTSA ID
- 11513982
- Incident
- Mar 6, 2023
- Mileage
- 55,000 mi
Fuel system
Filed Nov 24, 2022
The fuel tank is leaking at the pump due to defective plastic. There should be a lot of reports of this happening on this vehicle and it is more dangerous than any other defect I have ever heard of.
- NHTSA ID
- 11494822
- Incident
- Nov 22, 2022
Fuel system
Filed Nov 17, 2022
Have a strong odor of gasoline coming from vehicle parked in garage. Have not noticed any gasoline in the garage floor, only the strong odor.
- NHTSA ID
- 11493972
- Incident
- Nov 17, 2022
Fuel system
Filed Mar 22, 2022
After filling up my gas tank in my 2010 Chevrolet Corvette I notice a strong gas smell that permeates through my entire garage and house. Upon investigation from an auto repair shop it has been determined I need to replace a faulty cracked fuel pump. Upon further investigation it seems there was a "Special Coverage Adjustment" from GM for this repair only for up to 120k miles. This should be a recall!!! as it is a very dangerous situation! So because I am over 120k , (just purchased from dealer) I am responsible for the 3k repair? That is 100% not acceptable. 15682 Primary Tank Module Flange Fuel and Vapor Leaks Copyright 2016 General Motors. Reference Number: N150682 Release Date: January 2017 GWM Number: 2015682
- NHTSA ID
- 11457783
- Incident
- Mar 21, 2022
Fuel system
Filed Mar 20, 2022
Upon filling the car to a full tank that is a strong gas smell that permeates the cab. This smell is persistent even while driving with the convertible top down. People driving behind me were are able to smell the gasoline vapors. The vapors and smell subside once I get below 3/4 tank of gas.
- NHTSA ID
- 11457527
- Incident
- Mar 18, 2022
Fuel system
Filed Nov 28, 2021
Seems to be a common issue and GM has a tsb for it but they only covered the repare for 10 years and 120k I am at 11 with 70k miles. The fuel is leaking from the top of the tank and could cause a fire.
- NHTSA ID
- 11441866
- Incident
- Nov 28, 2021
Fuel system
Filed Nov 15, 2021
My 2010 Chevrolett Grand Sport has developed a very strong odor of gasoline. Both when parked in garage and while driving. It’s obviously leaking gasoline somewhere which could result in a fire or death.
- NHTSA ID
- 11440572
- Incident
- Oct 4, 2021
Fuel system
Filed May 1, 2021
I NOTICED THE HEAVY SMELL OF GAS FUMES AFTER PUTTING GAS IN MY VET. THE SMELL IS MOST PROMINENT WHEN THE CAR IS OFF AND PARKED IN THE GARAGE. I AM SURE THAT THE SMELL IS ALWAYS PRESENT AND THAT BEING PARKED IN A PARKING LOT OR OUTSIDE DISSIPATES THE SMELL. I HAVE TRIED FILLING THE TANK HALF WAY TO SEE IF THAT WOULD HELP BUT THE SMELL OF GAS IS STILL THERE. IT IS STRONGEST IN THE REAR HATCH AREA ON THE DRIVERS SIDE. THE SMELL IN GARAGE IS SO STRONG I HAVE TO LEAVE THE GARAGE DOOR OPEN TO VENT. I AM FEARFUL THAT THE FUMES MAY IGNITE MY GAS WATER HEATER WHICH IS LOCATED ABOUT 7-8FT AWAY OR START A CAR FIRE IF GAS HITS THE HOT EXHAUST PIPE. THIS IS TRULY SOMETHING THAT CHEVY NEEDS TO REVIEW TO SEE IF FAULTY EQUIPMENT WAS PLACED IN THE C6 MODELS. I HAVE HAD THE VET FOR 4 YEARS IT IS A 2010 AND THE MILEAGE IS JUST OVER 55K. I JUST NOTICED THIS ISSUE ABOUT 3 MONTHS AGO, BUT IT SEEMS TO BE GETTING WORSE. I HOPE THAT MY PROPERTY IS NOT DAMAGED BY A FUEL SOURCE ORIGINATING FROM THE CAR OR WORSE YET, A DEATH RELATED TO AN EXPLOSION OR FIRE.
- NHTSA ID
- 11414758
- Incident
- Jan 28, 2021
Fuel system
Filed Apr 2, 2021
I HAVE A STRONG ODOR OF FUEL INSIDE THE CABIN OF THE VEHICLE AND ALSO OUTSIDE BY THE GAS TANK FILLER AREA. IT IS VERY PREVALENT WHEN VEHICLE IS PARKED AFTER RUNNING IT.
- NHTSA ID
- 11406095
- Incident
- Mar 31, 2021
- Mileage
- 67,550 mi
Fuel system
Filed Mar 15, 2021
FUEL VAPORS COMING FROM THE FUEL TANK ;POSSIBLE CRACK IN FUEL PUMP SPRAYING FUEL EVERYWHERE;I CAN CLOSE MY GARAGE DOOR BECAUSE I CAN'T BREATHE BECAUSE OF THE GAS ODOR.IT'S WORSE WHEN I PUT TEN GALLONS OR MORE
- NHTSA ID
- 11403029
- Incident
- Aug 1, 2020
- Mileage
- 45,056 mi
Fuel system
Filed Jan 14, 2021
FUEL VAPORS COMING FROM GAS CAP- EVEN AFTER REPLACING CAP.
- NHTSA ID
- 11387990
- Incident
- Jan 7, 2021
- Mileage
- 72,000 mi
Fuel system
Filed May 12, 2020
SEVERE FUEL SMELL WHEN FUEL LEVEL IS HIGH AND ESPECIALLY WHEN PARKED IN ENCLOSED SPACE. *TR
- NHTSA ID
- 11324234
- Incident
- May 8, 2020
- Mileage
- 58,700 mi
Fuel system
Filed May 1, 2020
A GAS ODOR COMING FROM THE GAS FILL TUBE.
- NHTSA ID
- 11322943
- Incident
- Apr 30, 2020
- Mileage
- 18,235 mi
Fuel system
Filed Apr 7, 2020
STRONG GAS SMELL WHEN CAR GETS FILLED UP. THEN AFTER I GO OUT OF THE GAS STATION CAR ACCELERATES BY ITSELF AFTER STOPPING AND ENGINE STOPS. AFTER TURNING THE CAR ON AGAIN VERY STRONG GAS SMELL. THIS WILL GO ON AFTER SOME OF THE GAS IS WASTED.
- NHTSA ID
- 11320454
- Incident
- Apr 4, 2020
- Mileage
- 1 mi
Fuel system
Filed Mar 4, 2020
BOUGHT 2010 CORVETTE ON 4/29/2020 OUT OF TOWN. LAST 2 DAYS HAVE HAD STRONG GAS SMELL IN GARAGE. SAW ONLINE ABOUT AN ISSUE AND POSSIBLE RECALL?
- NHTSA ID
- 11315995
- Incident
- Mar 3, 2020
- Mileage
- 54,000 mi
Fuel system
Filed Feb 19, 2020
WENT TO FILL UP TANK AND DROVE OFF WITH A VERY BAD GAS SMELL INSIDE THE CAR, PUT CAR IN GARAGE AND SMELL WAS SO BAD HAD TO OPEN GARAGE AND PUT CAR OUT. IT ONLY SMELLS WHEN I FILL UP TANK.
- NHTSA ID
- 11310025
- Incident
- Feb 8, 2020
- Mileage
- 105,000 mi
Fuel system
Filed Feb 13, 2020
WHEN THE VEHICLE SITS IN AN ENCLOSED GARAGE, IT FILLS THE GARAGE WITH RAW FUEL ODOR. THIS HAPPENS MOST OFTEN WHEN IT IS AROUND 3/4 TANK. NO FUEL LEAKS ON THE FLOOR VISIBLE BUT ODOR IS VERY STRONG. GAS MILEAGE HAS DROPPED SIGNIFICANTLY AS WELL.
- NHTSA ID
- 11309048
- Incident
- Feb 13, 2020
- Mileage
- 70,000 mi
Fuel system
Filed Feb 8, 2020
AFTER FUELING AND FOR AT LEAST 100 MILES AFTERWARD THERE IS A DISTINCT GASOLINE SMELL INSIDE THE CAR AND IN THE GARAGE. NO LEAKAGE NOTICED UNDER THE CAR. TOOK IT TO A CHEVROLET DEALER WHO PERFORMED THE SMOKE TEST WHICH IT FAILED. THEY REPLACED THE PUMP AND SENDING UNIT AT NO CHARGE. THIS OFFER FROM CHEVROLET EXPIRES AFTER 10 YEARS OR 120000 MILES CURRENTLY. THIS REMEDIATION SHOULD BE A RECALL OR A PERMANENT TECHNICAL SOLUTION FOR ANY CORVETTE OF THIS MODEL THAT EXPERIENCES THIS INCREASINGLY SERIOUS PROBLEM, NO MATTER WHEN IT OCCURS.
- NHTSA ID
- 11307951
- Incident
- Jun 1, 2019
- Mileage
- 85,000 mi
Fuel system
Filed Dec 16, 2019
GAS SMELL WHEN TANK IS FILLED
- NHTSA ID
- 11289358
- Incident
- Dec 13, 2019
- Mileage
- 32,000 mi
Fuel system
Filed Nov 4, 2019
AFTER FILLING UP MY TANK, I SMELL A STRONG GAS SMELL PRIMARILY FROM THE LEFT REAR (WHERE I FILL UP) SIDE OF THE CAR. IT FILLS MY GARAGE WITH STRONG FUMES AND I DON'T FEEL SAVE STARTING IT, MUCH LESS DRIVING IT. I DON'T SMELL ANYTHING IN THE CABIN, ONLY WHEN IT'S IN THE GARAGE. ALSO LEADS ME TO BELIEVE I'M LOOSING GAS AND FUEL ECONOMY SO THAT'S A DRAG. I'VE LOOKED AT POSSIBLE CAUSES, AND IT COULD BE MANY DIFFERENT THINGS SO IT'S CURRENTLY UKNOWN AS FAR AS WHAT PART IS EXACTLY WRONG. I SMELL THE FUMES WHEN THE CAR IS STATIONARY.
- NHTSA ID
- 11278067
- Incident
- Oct 17, 2017
Fuel system
Filed Aug 22, 2019
GAS SMELL AFTER FILL UP OF TANK APPEARS TO BE THE HIGH PRESSURE LINE FROM THE TOP OF THE FUEL PUMP
- NHTSA ID
- 11245941
- Incident
- Jun 6, 2019
- Mileage
- 59,000 mi
Fuel system
Filed Apr 22, 2019
FUEL SMELL EMITTING FROM VEHICLE. FILLS GARAGE WITH FUMES.
- NHTSA ID
- 11203021
- Incident
- Apr 12, 2019
- Mileage
- 50,000 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.