2019 Chevrolet Equinox Fuel system Problems

The Fuel Pump Control Module (FPCM) connector corroded and disabled the fuel pump system. My car's fuel system failed while driving, and I had to pull over. After further research, I found that this particular FPCM and connector are located by the rear passenger axle and are exposed to the weather elements. This makes corrosion highly likely and poses a significant security threat for drivers, as there was no warning or engine light indication until moments before the failure. This is a design flaw and should be recalled by the manufacturer immediately.

NHTSA ID

11742004

Incident

May 31, 2026

This issue presents a serious safety concern. During the initial occurrence, the vehicle was unable to sustain highway speeds for extended periods (approximately 10 minutes or more). When coming to a stop, the vehicle would shake, rev unexpectedly, lose power, and shut off completely. During these events, the vehicle would not accelerate, creating a hazardous situation, especially in traffic. The condition has since worsened. The same symptoms now occur upon starting the vehicle and during the warm-up period, increasing the risk of sudden engine shutdown without warning. Additionally, a distinct “gulping” sound is coming from the rear of the vehicle, raising concern that the fuel system may be compromised. No diagnostic or pending fault codes are present, and the local dealership has been unable to identify the cause. The vehicle has fewer than 100,000 miles. Due to the unpredictable loss of power and engine shutdown, this issue poses an immediate safety risk to the driver, passengers, and surrounding motorists.

NHTSA ID

11716345

Incident

Nov 1, 2024

A "Reduced Engine Power" warning in a 2019 Chevrolet Equinox LT usually indicates the car has entered "limp mode" to protect the engine, most commonly caused by a dirty/faulty throttle body, loose Charge Air Cooler (CAC) tube, or sensor issues (MAF/TPS). Common codes include P0299 (turbo underboost). When this occurs, I cannot utilize my remote starter. I purchased an Innova OBD2 Code Reader, connected it to the vehicle and this code P0299 populated. There has been a few times that the engine light would go off, then I was able to use the remote starter to start the engine.

NHTSA ID

11716010

Incident

Oct 4, 2025

Could smell gas, looked under car saw gas dripping on driveway, coming from area where fuel tank is located, looks like it is coming from top of tank. Gas seems to leak only when tank is full and the outside temperature is cold ,below 20 degrees.

NHTSA ID

11713210

Incident

Dec 18, 2025

The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the contact became aware of a fuel-like odor coming from the driver’s side of the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the sealed seam had failed and the fuel tank needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.

NHTSA ID

11704525

Incident

Dec 11, 2025

Mileage

89,000 mi

Drove car down street and the car wouldn’t accelerate. Had towed to mechanic who found the direct injection high pressure fuel pump snapped off. When removed from vehicle they found broken bolt in cylinder head and the steel fuel line from pump to injector rail leaking fuel.

NHTSA ID

11700669

Incident

Nov 12, 2025

I had an issue starting the vehicle. Once it started the check engine light was lit. I stopped at the nearest Autozone for a diagnostic check and the code P00C6 registered for Fuel Pump. I had the vehicle checked by a mechanic and he explained to me this vehicle has (2) fuel pumps. One in the fuel tank and one on the engine, which is considered a high pressure fuel pump. That is where the failure is and the pump requires special tools to install. It is something they can not do and recommend the vehicle go to the dealer. Thank you for taking time to read this & be well.

NHTSA ID

11695922

Incident

Oct 24, 2025

I was stopped at a traffic light and the car just froze. All the dash lights started flashing, the brakes would not work. The car started moving slowly backing up traffic behind me. I barely made it to a parking lot off the road.

NHTSA ID

11690724

Incident

Sep 26, 2025

Fuel pump isn't pumping gas.

NHTSA ID

11647439

Incident

Mar 3, 2025

The contact owns a 2019 Chevrolet Equinox. The contact stated that upon inspecting the vehicle, there was fuel leaking onto the driveway near the fuel tank. No warning lights were illuminated. The contact stated that the dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 19V667000 (FUEL SYSTEM, GASOLINE). The manufacturer was not notified of the failure. The failure mileage was 229,000.

NHTSA ID

11641676

Incident

Jan 27, 2025

Mileage

229,000 mi

Vehicle runs with reduced engine power. Was initially told the turbo needed cleaned, and it continued to happen. Then was told it needed to be replaced. The final result is that the tube that connects to the turbo keeps falling off. Being told there is no fix, and no recall, we just need to keep putting it back on when it pops off.

NHTSA ID

11630664

Incident

Aug 1, 2024

I have had my vehicle in for repair three times for an EVAP code. The first visit they found nothing wrong. The second visit they placed the EVAP canister. The third visit they said if the light comes on again it's a faulty part. The light is on again. Since the first occurence, I have noticed the some of the same issues that were reported for the 2020 Equinox fuel pump issues, e.g. hesitation, choking,

NHTSA ID

11622414

Incident

May 15, 2024

The same issue has occurred on my vehicle but the dealership is stating my vehicle is not covered even thought it states it has all the issues stated in this bulletin. N192271200 Charge Air Cooler Disconnect at Throttle Body. The car blows off the hose at the throttle body even after I replace the retainer clip myself. I am now having the dealership repair the hose and clip as it needs both they said. It obviously is a flaw in more vehicles than what they have disclosed. Very unfortunate they do not cover this for all owners in the same year as this series of vehicles.

NHTSA ID

11613436

Incident

Sep 9, 2024

The contact owns a 2019 Chevrolet Equinox. The contact stated while driving at various speeds, the vehicle stalled. The vehicle was able to be restarted. The contact stated the fuel system warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a fuel system failure. The vehicle was not repaired. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 138,000. The VIN was not available.

NHTSA ID

11595699

Incident

Feb 4, 2024

Mileage

138,000 mi

My car is leaking oil and stalling just other cars in NHTSA ID: 20V668000 my car is 2019 Chevy equinox and is leaking oil stalling and a message comes on the street say my steering may might be impacted

NHTSA ID

11574955

Incident

Jan 1, 2024

The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at 65 MPH, he observed flames emanating from underneath the vehicle, prompting him to pull to the shoulder of the roadway. After a visual inspection of the vehicle, the contact observed that the fire originated in the fuel tank. Local emergency fire services arrived and were able to extinguish the flames. A police and fire report was filed, with no injuries reported. The check engine warning light was illuminated. The vehicle was towed to a tow yard, awaiting investigation by the manufacturer. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V667000 (Fuel System, Gasoline), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 93,000.

NHTSA ID

11568478

Incident

Jan 28, 2024

Mileage

93,000 mi

My car is leaking oil they can’t find leak I have oil In my drive way. I have oil leaking when I park my car on street or in parking lots too

NHTSA ID

11550220

Incident

Jun 1, 2023

My vehicle beginning idling and check engine light came on while at red light. So I decided to head to nearest auto parts to see what the code was. The light turned green and my truck didn’t want to go forward. Once it started to pull off it went slow and then gain a little more speed. This could’ve caused an accident. The people from the opposite side of rode would’ve hit and probably killed my son and I. This is not okay and needs to be checked on all vehicles because that’s a very late warning sign and can cause a huge issue. I’m reaching out to Chevrolet tomorrow morning since today is Sunday.

NHTSA ID

11543697

Incident

Sep 10, 2023

Twice the vehicle has gone into limp mode (15 mph max) on busy highway in last month. Diesel particulate filter clogged both times. Currently has been in Chevy dealer shop for over two weeks. Emission system failure and dealer cannot figure out cause. They are currently replacing many parts and cannot assure us this problem will not reoccur. 47,000 miles. Maintenance has been better than recommended for oil changes and filters. Currently awaiting second repair invoice.

NHTSA ID

11537580

Incident

Jun 23, 2023

Something is wrong with the brake assist system. The car was serviced literally towards the end of may and the brake assist service light keeps turning on. It is now causing the vehicle to have a check engine light that comes and goes as it pleases and the car now thinks that it is a bucking bronco at times with how hard it runs at times now. We have spoken and seen now multiple others complaining about the fueling system which does not alloe you to fill the gas tank up all the way. The tank holds 14.9 gallons and if the car is empty and on its last drop the car will only allow 12 gallons at best and that takes nearly 20 minutes of fighting with the car at the pump. The electrical in the vehicle is unstable. Multiple times while driving the radio and power to the car just turn off. I have also seen the recalls for the brake problems but when I enter my VIN it comes back all clear. We had a 2017 Chevy Malibu with multiple issues and spoke to Chevrolet about the issues and it wasn't until we traded it in that we started to receive the recall notices. This vehicle has some of the same problems and we have a toddler that we need to keep safe.

NHTSA ID

11528228

Incident

Apr 16, 2023

There was a recall back in 2019 for this same issue the charge air cooler is still disconnecting from the throttle body. I bought this car in 2021 supposedly the issue was fixed back in 2020 after the recall was issued. The same thing is happening. When I accelerate the air hose connecting to throttle body is disconnecting from and causing the engine warning of reduced engine power to show up. This is very concerning because when driving on the freeway with my family this is happening and this could get someone killed. The fixes back in 2020 are not up to standard or the replacement parts are faulty or the repair was not completed successfully. This has been happening since last year summer

NHTSA ID

11517268

Incident

Jun 20, 2022

This vehicle has started to lose power was taken to firsteam Norfolk Va where purchased took for oil change and tire rotation also loss of engine power at speeds of 20-32 mph and 50-62 mph. Dealership at Norfolk Va sent to firstteam Hampton VA Chevrolet for diagnosis and came back no engine light and small misfire 3/4 sparkplugs needed changed 177.00. After plugs were changed still had misfire then they felt it was number 4 injector 500.00 but never did work. I took it to national shop for recommended injector and when plugs were pulled mechanic found no new plugs. Injector was replaced with gm part and still misfiring. Norfolk firstteam towed vehicle back to Hampton Va firstteam and they are now giving me the run around. They want a blank check to replace parts till they find the problem. Unexceptable to even ask. Service writer has been very disrespectful and hung up on national shop and myself. When asked questions regarding work done service writer would just talk over us and speak to us disrespectful and then hung up. We have requested service manager at Hampton firstteam Chevrolet contact us and we were told she would tell him later. I have contacted Aston Lewis Jr owner of all firstteam dealerships here in Va requesting help three times and still no response. We need this reported so someone can fix the misfire and power loss the dealership does not know how to fix. Car is under power train warranty . Any help would be nice.

NHTSA ID

11514506

Incident

Mar 16, 2023

Purchased 2019 Sept 2021 engine light appeared fixed mass air flow by Reedman Chevy Sept 2022 engine reappears they fixed oxygen sensor Dec 19 2022 engine light reappears. Taken to Reedman 12/28/22 states orifice sensor or tube discover GM is aware of issue bullentin no.:20-NA-047 Reedman refused to honor repairs. States service will be $2,000.00 after contacting GM Protection Plan stated they give a $300 good will offer toward repair however the part is not covered under warranty(confused).

NHTSA ID

11499390

Incident

Dec 29, 2022

I purchased the crossover 2019in or around Sept 2021 the engine light appeared, it was taken to Reedman Toll Chevy of Springfield and they replaced the mass air flow sensor or oxygen sensor. Sept 2022 the engine light appeared again they replaced the oxygen sensor, Dec 19,2022 the engine light appeared again the vehical was taken to Reedman were it remains and I am being told it's th orifice tube(PVC tube). They stated this part is not covered under warranty after research GM bulletin No.: 20-NA-047 states this part is in fact covered. Reedman states the coverage of the service is $2,000.00 I contacted GM warranty dept (Irene) case#9-8392615536 who stated the part is covered also. Reedman refuses to follow the order given under the bulletin and GM.

NHTSA ID

11499311

Incident

Dec 29, 2022

The contact owns a 2019 Chevrolet Equinox. The contact stated the vehicle failed to start, with the check engine warning light illuminated. The contact was able to jumpstart the vehicle and drove to an independent mechanic however, the battery failed after turning off the vehicle. The mechanic associated the failure with NHTSA Campaign Number: 19V667000 (Fuel System, Gasoline) however, the VIN was not included. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was 46,568.

NHTSA ID

11495119

Incident

Nov 13, 2022

Mileage

46,568 mi