2001 Chevrolet Express 1500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Chevrolet Express 1500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine120.0%
- Interior & seats120.0%
- Exterior lighting120.0%
- Steering120.0%
- Tires & wheels120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
2001 CHEVY EXPRESS VAN/45,000 MILES (PURCHASED WHEN NEW).ANTIFREEZE LEAKING OUT BECAUSE INTAKE MANIFOLD GASKET IS LEAKING. ALTHOUGH SVC. BULLETINS/DEFECT INVESTIGATIONS EXIST FOR THIS PROBLEM, DEALERS SERVICE DEPT. STATES EXTENSIVE COST TO REPAIR THIS IS NOT COVERED BY WARRANTY OR ANY CHEVY/GM WARRANTY ADJUSTMENT. CHEVY CUSTOMER (PHONE) ASSISTANCE CONFIRMS THIS IS A NOTED PROBLEM W/THIS VEHICLE'S YEAR/MODEL BUT REMAINS NON-COMMITTAL REGARDING COVERING COSTS TO REPAIR IT FOR ME. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE DRIVER'S SEAT BASE CONTINUES TO SEPARATE FROM THE SEAT RISER FRAME. THE SEAT BASE HAS BEEN REPLACED 7 OR 8 TIMES BY THE DEALER SINCE 2004. IT IS NOW BROKEN AGAIN AND HAS BEEN FOR AT LEAST A YEAR. I HAVE ONLY 048409 MILES ON THIS VAN AND I AM THE ONLY DRIVER SINCE NEW. I WEIGH ONLY 200 LBS. AND I DON'T THINK IT IS MY FAT ASS CAUSING THE SEAT TO COME APART. AFTER GIVING A FRIEND A RIDE INTO TOWN A FEW WEEKS AGO, HE TOLD ME THE FRONT PASSENGER SEAT DIDN'T FEEL RIGHT. HE WAS CORRECT, THE PASSENGER SEAT IS IN THE SAME SHAPE AS THE DRIVER'S SEAT, BROKEN! I NEED HELP PLEASE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
WIRING DEFECT IN TAIL LIGHT ASSEMBLY CAUSES BRAKE LIGHTS TO MALFUNCTION. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 1500. WHILE ATTEMPTING TO MAKE A RIGHT TURN INTO A PARKING LOT, THE POWER STEERING FAILED. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE STEERING BECAME EXTREMELY STIFF AND REQUIRED ALL OF THE CONTACT'S STRENGTH TO MANEUVER. AN INDEPENDENT MECHANIC STATED THAT THE STEERING SHAFT SNAPPED OFF INSIDE THE STEERING. HE FURTHER STATED THAT THIS FAILURE WAS COMMON FOR THIS SPECIFIC MAKE AND MODEL VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 111,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 1500 EQUIPPED WITH TBC SIGMA SHADOW TIRES, SIZE P235/75/R15. WHILE DRIVING 60 MPH, THE LEFT REAR SIDE TIRE BEGAN MAKING NOISES AND THERE WAS A LOUD TUG. AFTER STOPPING, THE CONTACT NOTICED THAT ABOUT 95% OF THE TREAD WAS OFF THE TIRES. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 56,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .