RoadVitals

2000 Chevrolet Express 2500 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jan 17, 2008
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Airbags150.0%
  • Electrical150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Airbags

Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.

1
report

From owner reports, verbatim

TL*THE CONTACT OWNS A 2000 CHEVROLET EXPRESS 2500. WHILE STARTING THE VEHICLE FROM THE OUTSIDE, THE AIR BAGS SUDDENLY DEPLOYED. THE DEALER REFERRED THE CONTACT TO GENERAL MOTORS. THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY A TWO-WAY RADIO THAT WAS INSTALLED IN 2000. A WIRE WAS PINCHED DURING THE INSTALLATION. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 84,000.

NHTSA ID 10215251 · filed Jan 17, 2008

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

MY 2000 CHEVROLET CARGO VAN V8 5.7 L WAS PARK IN MY GARAGE FOR 7 HOURS AND I WAS ALERTED TO THE SMOKE BY THE SMOKE ALARM IN MY GARAGE. TURNS OUT AN ELECTRICAL FIRE SEEM TO HAVE STARTED IN THE FUSE BOX. STILL WAITING ON DEALER FOR EXTENT OF DAMAGE. I WAS ABLE TO PUT OUT THE FIRE WITH MY HOME WATER HOSE. *NM

NHTSA ID 10179420 · filed Jan 22, 2007

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .