2001 Chevrolet Express 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Engine150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
DEFECTIVE PAINT. THE PAINT ON FRONT OF VEHICLE AND ROOF CHIPPING AND RUSTING. I HAVE OBSERVED MANY OTHER CHEVROLET VANS WITH THE SAME ISSUE. HAVE NOT NOTICED THE SAME ISSUE WITH OTHER VANS MADE BY OTHER MANUFACTURERS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 2500. THE CONTACT NOTICED ANTIFREEZE LEAKING FROM THE ENGINE AT 15,174 MILES. THE DEALER STATED THAT THERE WAS A LEAK IN THE INTAKE MANIFOLD GASKET AND REPLACED THE GASKET. APPROXIMATELY FOUR YEARS LATER, THE SAME FAILURE OCCURRED AT 57,380 MILES. THE MECHANIC STATED THAT THERE WAS A LEAK IN THE INTAKE MANIFOLD GASKET AND REPLACED IT ONCE MORE. THE CONTACT STATED THAT THE VEHICLE CHECK ENGINE LIGHT ILLUMINATED AT 29,425 MILES. THE DEALER STATED THAT THE CYLINDERS MISFIRED AND THEY REPLACED THE FUEL INJECTION ASSEMBLY. THE FAILURE RECURRED AT 60,100 MILES. THE MECHANIC REPLACED THE FUEL INJECTION ASSEMBLY AGAIN. THE CURRENT MILEAGE IS 60,300 AND FAILURE MILEAGE WAS 15,174.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .